Related Manuals for Antunes MS-150
Summary of Contents for Antunes MS-150
- Page 1 MS-150/155 miracle steamers owner’s manual Manufacturing Numbers: 9100419, 9100420, 9100423, 9100425, 9100426, 9100428, 9100442, 9100450, 9100452, 9100456, 9100458, 9100459 www.antunes.com P/N 1010454 Rev. F 12/16...
-
Page 2: Table Of Contents
Model Number under warranty. IMPORTANT The warranty does not extend to: A.J. Antunes & Co. reserves the right to change specifications and product Serial Number • Damages caused in shipment or dam- design without notice. Such revisions do age as result of improper use. -
Page 3: Important Safety Information
• This equipment should be serviced • If a chemical cleaner is used, be sure by qualified personnel only. Contact Antunes Technical Service for adjust- it is safe to use on cast aluminum. Observe all precautions and warnings ment or repair. -
Page 4: Specifications
SPECIFICATIONS Width Depth Height Model No. 21" 21 3/8" 10 1/4" MS-150 (533 mm) (543 mm) (260 mm) 21” 17 1/8" 10 1/4” MS-155 (533 mm) (435 mm) (260 mm) Model & Plug Model & Volts Watts Amps Hertz Agency Approvals Mfg. -
Page 5: Installation
(MS-150 Only) Plug the power cord into the appropriate power outlet. Refer to the specification plate 4. MS-150: Remove and wash the Wire for the proper voltage. Drawer Trivet, Spatula, Spatula Liner, and Drip Pan (Figure 1) in soap and water. -
Page 6: Operating Instructions
PROGRAMMING OPERATING INSTRUCTIONS IMPORTANT: 208V and 220/240V Miracle Steamers are factory programmed for the CYC (Total Cycle Time) refers to the total following recommended settings: 1. Turn the power on and allow the unit programmed steam time set for the product. to preheat for approximately 20-30 •... -
Page 7: Hi-Limit Reset Button
Drip Pan This LED is only lit for approximately 1 second. 2. MS-150: Remove the Spatula, Spatula Liner, Drip Pan, Top Cover, and Steam FAULT CODES Vent (Figure 7). Figure 7. Daily Cleaning–MS-150... -
Page 8: Monthly Maintenance
MONTHLY MAINTENANCE Water Tank Filter The Miracle Steamer utilizes an open steam Wing Nut Generator. Water sprayed onto the Generator surface flashes into steam immediately, Generator Filter Stem but the minerals in the water stay on the Cover Generator surface. A small amount of calcium/ Tank Door mineral deposits are needed for proper opera- Diffuser... -
Page 9: Troubleshooting
The unit should be unplugged when servicing, except when electrical tests are required. Use extreme care during electrical circuit tests. Live circuits will be exposed. If the troubleshooting steps listed below do not solve your machine’s problem, contact Antunes Technical Service for further assistance. - Page 10 TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Unit heats but there is little or no Filter Strainer is restricted. Check and clean the Filter Strainer as described in steam produced the Maintenance section of this manual. Unit is not being cleaned properly (daily/monthly). Clean unit daily and monthly as described in the and/or Maintenance section of this manual.
-
Page 11: Wiring Diagram
WIRING DIAGRAM *NOTE: For 208-240 VAC units, the two primary coils are wired in series with one another. For 120 VAC units, the two primary coils are wired in parallel with one another. P/N 1010454 Rev. F 12/16... -
Page 12: Replacement Parts
REPLACEMENT PARTS P/N 1010454 Rev. F 12/16... - Page 13 Item Part No. Description Qty. 0010159 Filter Assy., Water Tank 1 25 0800359 Trivet, Spatula 57 308P105* Screw, Machine, #8-32 x 1/2" (MS-150 only) 7000652 Relay 58 308P120* Screw, Machine, 26 100P967 Label, Marking 7000320 Spatula Kit #8-32 x 5/8" (sltrshd) (Incl.
- Page 14 REPLACEMENT PARTS (continued) P/N 1010454 Rev. F 12/16...
- Page 15 Item Part No. Description Qty. Item Part No. Description Qty. 0010159 Filter Assy., Water Tank 1 25 0800359 Trivet, Spatula 1/4-20 x 1/2” (MS-150 only) (MS-155 only) 7000652 Relay 26 100P967 Label, Marking 57 308P105* Screw, Machine, 7000320 Spatula Kit #8-32 x 1/2”...
-
Page 16: Limited Warranty
LIMITED WARRANTY Equipment manufactured by Roundup Food Equipment Division of A.J. Antunes & Co. has been constructed of the finest materi- als available and manufactured to high quality standards. These units are warranted to be free from electrical and mechanical defects for a period of one (1) year from date of purchase under normal use and service, and when installed in accordance with manufacturer’s recommendations.
Need help?
Do you have a question about the MS-150 and is the answer not in the manual?
Questions and answers