Power Steering Hoses; Bleeding The Fuel System - Hyundai Terracan 2004 Owner's Manual

Diesel (2.9 CRDi)
G230A02HP
The power steering fluid level should be checked
daily.
To check the power steering fluid level, be sure
the ignition is "OFF", then check to make cer-
tain that the power steering fluid level is be-
tween the "MAX" and "MIN" level markings on
the fluid reservoir.
NOTE:
Grinding noise from the power steering
pump may be heard immediately after the
engine is started in extremely cold condi-
tions (below - 20°C). If the noise stops dur-
ing warm up, there is no abnormal function
in the system. If is due to a power steering
fluid characteristic in extremely cold condi-
tions.
Recommended Fluid
Use PSF-3 type fluid.
DO-IT-YOURSELF MAINTENANCE
NOTE:
Do not start the engine when the power
steering oil reservoir is empty.
G240A01A-AAT

POWER STEERING HOSES

It is suggested that you check the power steer-
ing hose connections for fluid leakage at regular
intervals. The power steering hoses should be
replaced if there is severe surface cracking,
pulling, scuffing or worn spots. Deterioration of
the hose could cause premature failure.
G350A01HP-GAT

BLEEDING THE FUEL SYSTEM

(FOR DIESEL ENGINE (2.5 TCI))
The fuel system should be bled to remove air as
described in the illustration if the fuel supply is
exhausted during travel, when the fuel filter is
replaced, or if the vehicle is not used for a long
time.
1. Loosen the air bleed bolt at the top of the fuel
filter with a flat-bladed screwdriver or equiva-
lent.
2. Pump the hand pump until there are no more
bubbles in the fuel coming out of the air plug.
When doing this, place a cloth around the air
plug to prevent the escaping fuel from spew-
ing about.
3. Tighten the air bleed bolt when there are no
more bubbles in the fuel.
4. Continue pumping until the hand pump be-
comes stiff.
5. Finally, check to be sure that there is no
leakage of fuel.
If in doubt, consult your nearest authorized
E090A01HP
HYUNDAI dealer.
WARNING:
(1) Do not smoke or have any other open
flame near the vehicle while bleeding the
fuel system.
E090A02HP
6-21