System Cleaning/Flushing - Carrier 73TCA005101B Start-Up And Service Instructions

LEAKS — Check any connections that show evidence of oil
or leaks. When unit is properly installed, centered, and lev-
eled (see Owners' Guide), check gaskets and wing panels
for possible air leakage.
CONTROLS — Check unit to ensure all controls are func-
tioning correctly and unit operation is normal.
Table 2 — Physical and Electrical Data — 1993-1995 Model Offerings
SERVICE/
CASING
DISCRETE
(See Table 6)
NO.
73TCA005101B S-1
73TCA005111B S-1
73TCA005121B S-1
73TCA005131B S-1
73TCA005141B S-1
73TCA005151B S-1
73TCA005171B S-1
73TCA005101D S-1
73TCA005101L S-1
73TCA005111L S-1
73TCA005121L S-1
73TCA006101D S-1
73TCA006111D S-1
73TCA006121D S-1
73TCA008101D S-2
73TCA008101P S-2
73TCA010101D S-2
SERVICE/
PF
DISCRETE
(%)
NO.
73TCA005101B 96
73TCA005111B 96
73TCA005121B 96
73TCA005131B 96
73TCA005141B 96
73TCA005151B 96
73TCA005171B 96
73TCA005101D 91
73TCA005101L 96
73TCA005111L 96
73TCA005121L 96
73TCA006101D 92
73TCA006111D 91
73TCA006121D 91
73TCA008101D 99
73TCA008101P 99
73TCA010101D 98
LEGEND
AHAM — Association of Home Appliance Manufacturers
ANSI — American National Standards Institute
DOE — Department of Energy
EER — Energy Efficiency Ratio
FLA — Full Load Amps
PF — Power Factor
V-PH-Hz
VOLTAGE
RANGE
115-1-60
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
115 104-127
FAN MTR
CAPACITOR
CARRIER
(See Table 5)
P/N
RC-1/FC-1 HC01CE118
RC-1/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE117
RC-1/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE117
RC-1/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE117
RC-2/FC-1 HC01CE118
RC-2/FC-1 HC01CE118
RC-3 HC43CE115
RC-4 HC33CE116
RC-4 HC33CE116
Vibrations can cause unwanted noise. Check to be sure no
piping is vibrating against any side of unit.
System Cleaning/Flushing —
and flushing, use the Carrier Totalclaim recovery system, or
a comparable refrigerant recycling system.
COOLING R-22
CAPACITY* CHARGE
(Btuh) (OZ. ± .05)
5100 10.00
5100 13.00
5000 13.70
5000 13.70
5000 10.20
5000 10.20
5000 9.20
5400 11.25
5100 10.00
5000 10.20
5000 9.20
6000 12.50
6000 13.50
6000 13.50
8000 21.50
8600 22.25
9900 24.00
FAN MTR COMPRESSOR
FLA (See Table 7)
0.74 D-1
0.74 D-2
0.74 M-1
0.70 M-1
0.74 D-3
0.74 D-3
0.74 D-3
0.74 M-1
0.74 D-1
0.74 D-3
0.74 D-3
0.74 M-2
0.70 D-4
0.70 D-4
1.25 T-1
1.60 T-1
1.60 T-2
t — Entering wet-bulb temperature minus leaving wet-bulb tem-
perature based on 67 F room wet-bulb temperature and 95 F
dry-bulb outside-air temperature. If conditions vary, wet-bulb t
will vary.
*Based on AHAM Standard RAC-1 and ANSI Z234.1.
3
For proper cleaning
WET BULB
AMPS WATTS
t F
7.5 5.7 630
7.5 5.7 630
7.5 5.4 593
7.5 5.4 593
7.5 5.9 630
7.5 5.9 630
7.5 5.9 625
12.0 5.4 593
7.5 5.7 630
7.5 5.9 630
7.5 5.9 625
11.6 6.5 691
13.0 6.7 697
13.0 6.7 697
12.1 7.5 870
12.2 7.5 862
15.5 9.4 1092
CAPILLARY
THERMISTOR
DATA
(See Table 4)
(See Table 3)
Z-1 CD-1
Z-1 CD-2
Z-1 CD-3
Z-1 CD-3
Z-1 CD-4
Z-1 CD-4
Z-1 CD-4
Z-1 CD-5
Z-1 CD-1
Z-1 CD-4
Z-1 CD-4
Z-1 CD-6
Z-1 CD-7
Z-1 CD-7
Z-1 CD-8
Z-1 CD-9
Z-1 CD-10
EER
(DOE)
8.1
8.1
8.0
8.0
8.0
8.0
8.0
9.1
8.1
8.0
8.0
8.6
8.6
8.6
9.2
10.0
9.0