BD Diesel Performance 1030395 Installation Manual page 8

22 September 2015
PCM & TCC
Locate the vehicle's Torque Convertor Control (TCC) as described in the following
chart. Cut the applicable wire and attach one side of a blue Posi-Lock connector to
the wire leading back to the transmission, and, attach one side of another blue Posi-
Lock connector to the wire heading to the vehicles computer (ECM or PCM).
Connect the TorqLoc Yellow wire to the PCM (#6) terminal on the module, and,
connect the Blue wire to the TCC (#7) terminal. Run the Yellow and Blue wire to
the cut Convertor Control wire and cut off leaving some slack. Attach the Yellow
wire to the blue Posi-Lock heading to vehicle's computer. Attach the Blue wire to
the blue Posi-Lock heading back to the transmission. Instead of connectors, you
could also solder the wires.
NOTE: Some vehicles have more than one wiring harness on transmission.
Make/Model
2004-2005
DODGE
1996-2003
(5.9L)
1994-1995
1999-2003
FORD
1995-1997
(7.3L)
1990-1994
1994-2000
CHEVY
(6.5L)
1992-1993
INVERTER #8 Optional Overdrive Disable (Orange Wire)
For 1994-98 Dodges only, connect Orange wire to the Inverter terminal and run it to
the same harness where the O/D Switch and VSS wire were found, cutting of
excess and leaving some slack. Locate the Orange w/White Tracer and using a
gray Posi-Tap™ connector or soldering, connect Orange wire to O/D wire.
For 1999-2002 Dodges, if the overdrive inverter option is desired,
flip Dip Switch #8 to the "UP" position, no matter what gear ratio
BRAKE
This connection is not used in the TorqLoc kit.
U.S. Shipping Address: 88-446 Harrison St, Sumas, WA 98295
TorqLoc# 1030395
#6-7 Converter Control (Yellow #6 and Blue #7 wire))
Year Wire Color
Unplug harness from transmission then look inside
plug and identify which wire is going to the "S" pin
TAN/BK
you set the other switches to.
#9 N/A
BD Engine Brake Inc.
Plant Address: 33541 MacLure Rd. Abbotsford, BC, Canada V2S 7W2
Phone: 604-853-6096 | Fax: 604-853-8749 | Internet: www.bd-power.com
Pin #
Y/LB 25
OR/BK 11
OR/BK 54
VT/Y 54
VT/Y 28
VT/Y 53
(usually Brown)
U.S. Mailing Address: P.O. Box 231, Sumas, WA 98295
Location
ECM C2 50 Pin Connection
PCM C2
PCM
PCM
PCM
PCM
"J" on Transmission
8