Table of Contents
Advertisement
INSTALLATION AND OPERATION MANUAL
•
DO NOT TRY TO LIGHT ANY APPLIANCE.
•
DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
VEHICLE.
•
IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE.
FOLLOW THE GAS SUPPLIER'S INSTRUCTIONS.
•
IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.
DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE
OR MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO
THIS MANUAL. FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT A
QUALIFIED INSTALLER, SERVICE AGENCY OR THE GAS SUPPLIER.
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR
LIQUIDS NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE. THIS
APPLIANCE SHALL NOT BE INSTALLED IN ANY LOCATION WHERE FLAMMABLE
LIQUIDS OR VAPORS ARE LIKELY TO BE PRESENT.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO WATER HEATER.
OWNER: RETAIN THESE INSTRUCTIONS AND WARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULD BE DIRECTED TO THE COMPANY
LISTED ON THE WARRANTY OR RATING PLATE WHICH CAME WITH YOUR WATER HEATER.
Part Number 204539
03-17-2015
DIRECT VENT
GAS WATER HEATER
MODELS SW4DEL • SW6DEL
SW10DEL • SW12DEL • SW16DEL
Direct Spark Ignition, Electric Element
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
FREEZE WARNING
FOR YOUR SAFETY
AN ODORANT IS ADDED TO THE GAS USED BY THIS WATER HEATER.
AIRXCEL, INC. - SUBURBAN DIVISION
676 Broadway Street
Dayton, Tennessee 37321
423-775-2131
www.Airxcel.com
Advertisement
Table of Contents
Related Manuals for Suburban SW4DEL
Summary of Contents for Suburban SW4DEL
-
Page 1: For Your Safety
INSTALLATION AND OPERATION MANUAL DIRECT VENT GAS WATER HEATER MODELS SW4DEL • SW6DEL SW10DEL • SW12DEL • SW16DEL Direct Spark Ignition, Electric Element FOR INSTALLATION IN RECREATIONAL VEHICLES AND MOBILE HOUSING FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS •... -
Page 2: Safety Warnings
Installation of this appliance must be made in accordance with the written instructions provided in this manual. No agent, representative or employee of Suburban or The board and all wiring to the board must be protected in order to prevent other person has the authority to change, modify or waive any provision of the instructions contained in this manual. - Page 3 INNER COACH WALL INNER COACH WALL FRAMING FRAMING OUTER COACH WALL OUTER COACH WALL FLOORING A=12 3/4"+1/8"-0" FLOORING B=12 3/4"+1/8"-0" A = 16 3/8"±1/16" B = 16 3/8"±1/16" Figure 1A Figure 1 WATER HEATER AS VIEWED FROM INSIDE R.V. FRAMED OPENING FLOOR SECURE CHOCKS, ONE ON EACH SIDE, TIGHTLY AGAINST WATER HEATER JACKET AND FASTEN TO VEHICLE FLOOR TO PREVENT MOVEMENT.
- Page 4 DOOR FRAME FRAMED OPENING (SEE FIGURE NO. 1A) CAULKING DC JUNCTION BOX FRAMED OPENING CAULK AROUND OPENING PLACE SCREW OR SUITABLE FASTENER AS SHOWN. DOOR FRAME WHEN INSTALLED MUST NOT OVERLAP ONTO SCREW HEAD OR FASTENER. AC JUNCTION BOX SPECIAL SCREW GASKET CONTROL HOUSING DETAIL A...
-
Page 5: Safety Information
3. Reset button on ECO is tripped. (see Figure 9) NOT REMOVE PLASTIC FILL TUBE. If burner fails to light, call a Suburban Service Center or a local RV service agency. IMPORTANT: Use a pipe thread compound suitable for potable water or pipe thread tape on all connections to assure they will not leak. -
Page 6: High Altitude Deration
Manufacturing Company for proper derating of the unit. Change-out of the burner/ in Suburban products. They could create an unsafe condition and will also void all warranties. orifice (derating) should be done by the dealer or a qualified service agency. -
Page 7: Parts And Service
Repeat this procedure as often as needed to reduce the frequency of the weeping of the P & T Valve. If the weeping persists after following this procedure, you may Contact a conveniently located recommended Suburban Service Center. elect to install an expansion or accumulator tank in the cold water line between Describe to them the nature of your problem, make an appointment, if necessary, the tank and check valve to relieve the pressure caused by thermal expansion. - Page 8 CORRECT INCORRECT BLUE OR BLUE/ORANGE WELL DEFINED PATTERN NEW ANODE ROD YELLOW OR YELLOW/ ORANGE ERRATIC PATTERN 75% CORRODED ANODE ROD ANODE ROD Figure 12 Figure 11 VENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED CANADIAN INSTALLATIONS US INSTALLATIONS CANADIAN INSTALLATIONS US INSTALLATIONS...
- Page 9 INCORRECT INCORRECT Figure 14 Figure 15 CORRECT Figure 16 - 9 -...
-
Page 10: Two Year Limited Warranty
Suburban. DO NOT PAY THE SERVICE AGENCY FOR WARRANTY REPAIRS; SUCH PAYMENTS WILL NOT BE REIMBURSED. Suburban reserves the right to examine the alleged defect in the water heater or component parts, and it is the owner’s obligation to return the water heater and/or component parts to Suburban or its representative.
Need help?
Do you have a question about the SW4DEL and is the answer not in the manual?
Questions and answers