Suburban SW6P Installation And Operation Manual
Gas water heater
Hide thumbs
Also See for SW6P:
- Installation and operation manual (14 pages) ,
- Service training manual (44 pages) ,
- Service manual (26 pages)
Advertisement
Table of Contents
INSTALLATION AND OPERATION MANUAL
! DO NOT TRY TO LIGHT ANY APPLIANCE.
! DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
VEHICLE.
! IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE. FOLLOW
THE GAS SUPPLIER'S INSTRUCTIONS.
! IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.
DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR
MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO THIS MANUAL.
FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR LIQUIDS
NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE. THIS APPLIANCE
SHALL NOT BE INSTALLED IN ANY LOCATION WHERE FLAMMABLE LIQUIDS OR VAPORS
ARE LIKELY TO BE PRESENT.
AN ODORANT IS ADDED TO THE GAS USED BY THIS W ATER HEATER.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO W ATER HEATER.
OW NER: RETAIN THESE INSTRUCTIONS AND W ARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND W ARRANTY QUESTIONS SHOULD BE DIRECTED TO THE COMPANY
LISTED ON THE W ARRANTY, OR RATING PLATE W HICH CAME W ITH YOUR W ATER HEATER.
DIRECT VENT
GAS WATER HEATER
SW6P • SW6PE • SW6PR • SW6PER
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
FREEZE WARNING
FOR YOUR SAFETY
MODELS
SUBURBAN MANUFACTURING COMPANY
676 Broadway Street
Dayton, Tennessee 37321
423-775-2131
Fax: 423-775-7015
Advertisement
Table of Contents
Related Manuals for Suburban SW6P
Summary of Contents for Suburban SW6P
- Page 1 INSTALLATION AND OPERATION MANUAL DIRECT VENT GAS WATER HEATER MODELS SW6P • SW6PE • SW6PR • SW6PER FOR INSTALLATION IN RECREATIONAL VEHICLES AND MOBILE HOUSING FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS ! DO NOT TRY TO LIGHT ANY APPLIANCE.
-
Page 2: Installation Requirements
INSTALLATION REQUIREMENTS G . Insert door fram e into control housing and secure with three (3) N o. 8-15 x 3 1/2" screws provided. W AR N IN G ! Installation of this appliance m ust be m ade in accordance w ith H . - Page 3 Figure 2 Figure 3...
- Page 4 MAKING WATER CONNECTIONS A. W ater connections are m ade at the rear of the water heater. R efer to Figure 4. C onnect the hot and cold water lines to the 1/2" fem ale pipe fitting provided on rear of tank . T hese fittings are m arked “H O T ” and “C O LD ”. N O T E : Inside each fitting is a plastic fill tube.
-
Page 5: Maintenance
ELECTRICAL CONNECTION (RE-IGNITOR MODELS) A. A pplicable to m odels: S W 6P R and S W 6P E R . B . Make 12 volt D .C . connections to re-ignitor as illustrated in Figure 7. If the power supply is to be from a convertor, we recom m end that the converter system be wired in parallel with the battery. -
Page 6: Pressure Relief Valve
“add-on” electric heating elem ent. Item s such trip shutting down the electric elem ent. as these are not ap p ro ved to be installed in Suburban products. They could create an unsafe condition and w ill also void all w arranties. -
Page 7: For Your Safety Read Before Lighting
FOR YOUR SAFETY READ BEFORE LIGHTING W AR N IN G ! If the user of this appliance fails to m aintain it in the condition in w hich is w as shipped from the factory or if the appliance is n ot used solely for its intended purpose or if appliance is not m aintained in accordance w ith the instruction in this m anual, then the risk of a fire and/or the production of carbon m onoxide exists w hich can cause personal injury, property dam age or loss of life. - Page 8 LIGHTING INSTRUCTIONS FOR REIGNITOR MODELS 12. Feel water before bathing or showering. AP P LIC AB LE TO M O D E LS SW 6P R AN D S W 6P E R N O T E : W hen the reignitor switch is in the “O N ” position, the reignitor will operate autom atically when the pilot flam e is extinguished.
- Page 9 2. P art D escription 3. M odel N o. and Serial N o. of your H eater 4. N um ber of Parts R equired PARTS LIST FOR MODELS SW6P • SW6PR • SW6PE • SW6PER (Figure 12) Item P art Num ber N o.
- Page 10 Figure 12...
- Page 11 This page is intentionally left blank.
-
Page 12: Two Year Limited Warranty
BE REIMBURSED. Suburban reserves the right to examine the alleged defect in the water heater or component parts, and it is the owner=s obligation to return the water heater and/or component parts to Suburban or its representative. When returning a water heater, it must include all component parts and the serial number plate.