Suburban SW10D Installation And Operation Manual
Direct vent gas water heater direct spark ignition (dsi)
Hide thumbs
Also See for SW10D:
- Installation and operation manual (24 pages) ,
- Service training manual (44 pages) ,
- Service manual (26 pages)
Advertisement
INSTALLATION AND OPERATION MANUAL
SW10D ! SW10DM ! SW10DE ! SW10DEM
! DO NOT TRY TO LIGHT ANY APPLIANCE.
! DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
VEHICLE.
! IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE. FOLLOW
THE GAS SUPPLIER'S INSTRUCTIONS.
! IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.
DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR
MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO THIS MANUAL.
FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER.
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR LIQUIDS
NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE. THIS APPLIANCE
SHALL NOT BE INSTALLED IN ANY LOCATION WHERE FLAMMABLE LIQUIDS OR VAPORS
ARE LIKELY TO BE PRESENT.
AN ODORANT IS ADDED TO THE GAS USED BY THIS WATER HEATER.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO WATER HEATER.
OWNER: RETAIN THESE INSTRUCTIONS AND WARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULD BE DIRECTED TO THE COMPANY
LISTED ON THE WARRANTY, OR RATING PLATE WHICH CAME WITH YOUR WATER HEATER.
DIRECT VENT
GAS WATER HEATER
DIRECT SPARK IGNITION (DSI)
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
FREEZE WARNING
FOR YOUR SAFETY
MODELS
SUBURBAN MANUFACTURING COMPANY
676 Broadway Street
Dayton, Tennessee 37321
423-775-2131
Fax: 423-775-7015
Advertisement
Table of Contents
Related Manuals for Suburban SW10D
Summary of Contents for Suburban SW10D
- Page 1 INSTALLATION AND OPERATION MANUAL DIRECT VENT GAS WATER HEATER DIRECT SPARK IGNITION (DSI) MODELS SW10D ! SW10DM ! SW10DE ! SW10DEM FOR INSTALLATION IN RECREATIONAL VEHICLES AND MOBILE HOUSING FOR YOUR SAFETY WHAT TO DO IF YOU SMELL GAS ! DO NOT TRY TO LIGHT ANY APPLIANCE.
- Page 2 INSTALLATION REQUIREMENTS B . Secure the control housing to the coach w all (fram ed opening) at the top and s id e s o f control housing com partm ent using screw s or other suitable fasteners. R ecess the screw s or fasten ers b ack far enough from the front edge of control W A R N IN G ! Installation of this appliance m ust be m ade in accordance w ith housing (approxim ately 1 1/2") in order to clear the flange on door fram e.
- Page 3 Figure 2 M O D E LS S W 10D S W 10D E Figure 3 M O D E L S W 10D E M Figure 5 M O D E L S W 10D M Figure 4 Figure 6...
-
Page 4: Maintenance
MAKING ELECTRICAL CONNECTIONS 12 VOLTS D.C. A . A pplicable to follow ing m odels: S W 10D , S W 10D E , S W 10D M , and S W 10D E M . B . R efer to Figure 2 for location o f D .C . junction box on m odels S W 10D and S W 10D E . -
Page 5: Safety Warnings
B . P eriodically inspect unit for soot. If soot is present anyw here on w ater heater, The therm ostat on you r w ater heater is n ot ad justable. It is a tem perature im m ediately shut unit dow n and contact your dealer or a qualified service person. sensing lim it designed to m aintain a w ater te m p e ra ture of 130°F (54°C ). - Page 6 PRESSURE RELIEF VALVE THERMOSTAT AND MANUAL RESET M O D E LS SW 10D E and S W 10D E M The tem perature and pressure relief valve is designed to open if the tem perature The m odel w ater heaters listed above are equipped w ith a high tem perature lim it of the w ater w ithin the heater reaches 210°F, or if the w ater pressure in the heater as a cut-off device.
-
Page 7: For Your Safety Read Before Lighting
FOR YOUR SAFETY READ BEFORE LIGHTING W A R N IN G ! If the user of this appliance fails to m aintain it in the condition in w hich is w as shipped from the factory o r if the appliance is not used solely for its intended purpose or if appliance is not m aintained in accordance w ith the instruction in this m anual, then the risk of a fire and/or the production of carbon m onoxide exists w hich can cause personal injury, property dam age or loss of life. - Page 8 Part Number Description SW10D SW10DE Foam Jacket (2 Required) ..........101781...
- Page 9 Figure 14...
- Page 10 PARTS LIST FOR MODEL SW10DM (Figures 15 and 16) Item Part Number Item Part Number Description SW10DM Description SW10DM Cover, Module Board ........090340 Electrode .
-
Page 11: Cover, Junction Box
PARTS LIST FOR MODEL SW10DEM (Figures 17 and 18) Item Part Number Item Part Number Description SW10DEM Description SW10DEM Cover Module Board ........090340 Burner Assembly with orifice . - Page 12 WHATSOEVER. Some states do not allow the exclusion of incidental or consequential damages, so the above limitation may not apply to you. NO REPRESENTATIVE, DEALER, RECOMMENDED SERVICE CENTERS OR OTHER PERSON IS AUTHORIZED TO ASSUME FOR SUBURBAN MANUFACTURING COMPANY ANY ADDITIONAL, DIFFERENT OR OTHER LIABILITY IN CONNECTION WITH THE SALE OF THIS SUBURBAN PRODUCT.