Table of Contents
Advertisement
Quick Links
OWNER'S MANUAL
Instructions for the installation, operation
and maintenance of all Traulsen:
This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated
cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial
refrigeration since 1938. We thank you for your choice and confidence in Traulsen equipment and we know
you will receive many years of utility from this equipment.
All Traulsen units are placed on a permanent record file with the service department. In the event of any
future questions you may have, please refer to the model and serial number found on the name tag affixed
to the unit. Should you need service, however, call us on our toll free number, 800-825-8220 between 7:30
am and 4:30 pm CST, Monday thru Friday. It is our pleasure to help and assist you in every possible way.
COMPLETE THE FOLLOWING INFORMATION PRIOR TO UNIT INSTALLATION
INITIAL START DATE:
MODEL TYPE:
COMPANY/INDIVIDUAL NAME:
INSTALLER:
FORM NUMBER TR35849 REV. 01/12
Quality Refrigeration
Reach-In Even Thaw Refrigerator Models*
RET132EUT
RET232EUT
RET232NUT
*For roll-in even-thaw models please refer to form number TR35867.
INSTALLER
SERIAL NO.
P/N 375-60214-00
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Traulsen RET132EUT
Summary of Contents for Traulsen RET132EUT
- Page 1 All Traulsen units are placed on a permanent record file with the service department. In the event of any future questions you may have, please refer to the model and serial number found on the name tag affixed to the unit.
-
Page 2: Table Of Contents
The serial tag is a permanently affixed sticker on SERIAL MODEL which is recorded vital electrical and refrigeration VOLTS data about your Traulsen product, as well as the model and serial number. This tag is located in TOTAL CURRENT AMPS the upper right interior compartment on all reach-... -
Page 3: Receipt Inspection
II. RECEIPT INSPECTION III. INSTALLATION (continued) All Traulsen products are factory tested for performance and III. c - INSTALLING LEGS OR CASTERS: are free from defects when shipped. The utmost care has 6” high stainless steel legs are supplied standard for been taken in crating this product to protect against damage all Traulsen reach-in and pass-thru units. -
Page 4: D-Tray Slides
Refer to the wiring diagram for any service work performed setpoint temperature, additional heat is added. Heater op- on the unit. Should you require one, please contact Traulsen eration is controlled proportionally, i.e. the colder the cabinet Service at (800) 825-8220, and provide the model and serial temperature, the longer the heaters remain in operation. -
Page 5: D-Batch Loading
The most important thing you can do to insure a long, reli- load, or up to twenty eight (28) 18” x 26” pans of product. Use able service life for your Traulsen is to regularly clean the of aluminum pans is highly recommended. Product should be condenser coil. -
Page 6: C-Replacing The Gaskets
Traulsen service agent. A complete list of authorized service agents was provided along with your Traulsen unit. If you cannot locate this, you may also obtain the name of a service agent from the Service/Contact page of our website: www.traulsen.com. -
Page 7: Gen'l Use, Operation & Service
SHOOTING VII. a - INTRODUCTION/OVERVIEW: VIII. a - INTRODUCTION: The Traulsen Even Thaw is designed to be used as a Even thaw performance is a function of many factors, espe- thawing cabinet. While it may be utilized in a refrigeration cially those involving product types and loading. -
Page 8: E-Incomplete Thawing
If improper loading has been eliminated as a possible cause for extended thaw cycle times, there are several system checks which can be done to diagnose the Traulsen Even- Thaw unit. First, the amp draw should be checked early in the thaw cycle. -
Page 9: Trouble Shooting Guide
IX. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE REMEDY 1. Condensing unit fails to start. Check if cord & plug has been disconnected. 2. Condensing unit operates for Are doors closing properly? prolonged periods or continuously. Dirty condenser or filter. Clean properly. Evaporator coil iced. -
Page 10: Spare Parts List
X. SPARE PARTS LIST X. SPARE PARTS LIST PART NUMBER APPLIES TO MODEL(S) PART NAME AND/OR DESCRIPTION 341-60105-00 RE132E-FHS FULL HEIGHT DOOR GASKET SFO-17357-00 RE232E-FHS FULL HEIGHT DOOR GASKET 341-60060-00 RE232N-HHS HALF HEIGHT DOOR GASKET 341-60059-00 RE232N-FHS FULL HEIGHT DOOR GASKET 325-60103-00 ALL MODELS FILTER DRIER... -
Page 11: Xi. Wiring Diagrams
XI. WIRING DIAGRAM ALL ONE SECTION MODELS ONLY -10-... - Page 12 XI. WIRING DIAGRAM MODELS RET232NUT-FHS & RET232NUT-HHS ONLY -11-...
-
Page 13: Xi. Wiring Diagrams
XI. WIRING DIAGRAM MODELS RET232EUT-FHS & RET232EUT-HHS ONLY -12-... -
Page 14: Warranty Information
TRAULSEN warrants to the original purchaser the Refrigeration Equipment manufactured and sold by it to be free from defects in material and workmanship under normal use and service for a period of one (1) year from date of shipment. Under this warranty, TRAULSEN will reimburse the purchaser for the replacement of any part of said equipment (excluding dryers &... - Page 15 Notes:...
- Page 16 HOURS OF OPERATION: Monday thru Friday 7:30 am - 4:30 pm CST Traulsen 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www.traulsen.com Quality Refrigeration © 2012 Traulsen - All Rights Reserved...