Pre-Operation And Daily Safety Checklist - Club Car Carryall 1 Owner's Manual

FUEL GAUGE/HOUR METER
Figure 13 Fuel Gauge/Hour Meter and
Low Oil Warning Light
FUEL GAUGE/HOUR METER
The vehicle is equipped with a fuel gauge/hour meter, located on the dash panel (Figure 13). The fuel gauge
allows the operator to monitor the fuel level in the vehicle. The hour meter should be used by the trained tech-
nician to track vehicle usage and determine when periodic service procedures are required. See Periodic
Service Schedule on page 30.
HEADLIGHT CONTROL
The headlight control is located on the front dash between the fuel gauge/hour meter and steering column.
Pull the headlight control knob out to turn headlights on and push the knob in to turn headlights off.
NOTE: Using the headlights for extended periods of time without the engine running, or with the engine
idling will discharge the battery.

PRE-OPERATION AND DAILY SAFETY CHECKLIST

Each Club Car vehicle has been thoroughly inspected and adjusted at the factory; however, upon receiving
your new vehicle(s), you should become familiar with its controls, indicators, and operation. Carefully inspect
each vehicle to ensure that it is in proper working condition before accepting delivery.
Use the following checklist as a guide to inspect the vehicle. This checklist should be used daily to ensure that
the vehicle is in proper working condition and in conjunction with the Periodic Service Schedule on page 31.
Any problems should be corrected by a Club Car distributor/dealer or a trained technician.
• General: All the parts should be in place and properly installed. Be sure that all nuts, bolts, and screws
are tight. Check hose clamps for tight fit and the starter belt for tightness.
• Safety and information decals: Check to ensure that all safety and information decals are in place.
See pages 8 through 13.
• Tires: Check for proper tire pressure on your new vehicle. See Vehicle Specifications on page 37.
Visually inspect tires for wear, damage, and proper inflation on a daily basis.
• Battery: Before using vehicle for the first time check electrolyte to ensure it is at the proper level
(Figure 24). Check battery posts. Wires should be tight and free of corrosion and battery should be
fully charged.
LOW OIL
WARNING LIGHT
2003 Carryall Gasoline Vehicle Owner's Manual
Pre-Operation and Daily Safety Checklist
Page 19