Page 1
http://www.xiaoyu163.com CDC-X707M 3 7 63 1515 0 CDC-X7070M SERVICE MANUAL L 13942296513 STEREO CAR CD RECEIVER BASIC CD MECHANISM : CDC02AW1 • This Service Manual is the "Revision Publishing" and replaces "Simple Manual" CDC-X707M/X7070M (YU, YL), (S/M Code No. 09-002-424-3T1). u163 S/M Code No.
http://www.xiaoyu163.com PROTECTION OF EYES FROM LASER BEAM DURING SERVICING 3 7 63 1515 0 CAUTION This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing. Use of controls or adjustments or performance of proce- dures other than those specified herin may result in WARNING!! hazardous radiation exposure.
Page 15
http://www.xiaoyu163.com SCHEMATIC DIAGRAM – 3 (CD MAIN / SENSOR) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 – 15 – http://www.xiaoyu163.com...
Page 16
http://www.xiaoyu163.com LCD DISPLAY LCD,AKC-2/8(2 COLOR) 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 – 16 – http://www.xiaoyu163.com...
Page 17
http://www.xiaoyu163.com IC DESCRIPTION IC, µPD178016AGC-562-3B9/µPD178006AGC-540-3B9 3 7 63 1515 0 Pin No. Pin Name Description FM/AM S-M RDS AF signal input and FM/AM S meter signal input. LEVEL-M Voltage input for level indicator. Pulled down when not used. A-VOL CONT Detects microphone input for auto volume operation.
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description CDS RESET Reset signal output. CDS SLEEP SLEEP signal output. CDS STOP STOP signal input. CDS IN DISC status detection input. TEST MODE CD test port. Not connected (open). Not connected (open).
Page 19
http://www.xiaoyu163.com IC, LC75854W 3 7 63 1515 0 Pin No. Pin Name Description 1 ~ 39 S1~S39 LCD segments output. COM1 LCD common driver outputs. COM2 LCD common driver outputs. COM3 LCD common driver outputs. COM4 LCD common driver outputs. –...
Page 20
http://www.xiaoyu163.com IC, CXD2587Q 3 7 63 1515 0 Pin No. Pin Name Description SQSO Sub-Q 80-bit and PCM peak/level data output. CD TEXT data output. SQCK Clock input for reading SQSO. XRST System reset. Reset at "L". SYSM Muting input. Muted at "H". DATA Serial data input from CPU.
Page 21
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description Sled error signal input. Tracking error signal input. Neutral servo analog input. RFDC RF signal input. ADIO For test. Do not connect. AVSS0 — Ground of analog circuits. IGEN Constant current input for OP amp.
Page 23
http://www.xiaoyu163.com IC, µPD78012FGC656-AB8 3 7 63 1515 0 Pin No. Pin Name Description TE-BAL — Not connected. LO-REV Loading motor reverse drive output. LO-FWD Loading motor forward drive output. LIMT-SW Inner edge limit switch. RF-SW CD/CD-RW switching output. Outputs "H" when power is turned on. (When power is supplied, this pin outputs "H" SV-CONT after DSP is initialized.) 7, 8...
Page 24
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description DATA-DSP DSP serial data output. CD-MUTE Muting output. CD-RST CD reset output. AVDD — Power supply. AVREF — A/D converter reference voltage input. SQ-IN Sub-Q/PCM peak/level data input. — Not connected.
http://www.xiaoyu163.com TEST MODE 3 7 63 1515 0 1. How to activate CD test mode 1) Remove D937 (1SS133) from the main circuit board, and connect the terminal No.45 of a microcomputer and GND line with a wire. (Fig. 1) 2) Connect +12V to ACC/BACK UP and –...
Page 30
http://www.xiaoyu163.com 3 7 63 1515 0 3. CD test mode functions Mode Operation Key LCD Display Operation Contents Start Mode All LCD light up Activate test mode • All servo off Load / Unload All LCD light up Chucking • Laser on •...
Page 31
http://www.xiaoyu163.com MECHANICAL EXPLODED VIEW 1 / 1 3 7 6 3 1 5 1 5 0 CDC02AW1 P.C.B P.C.B P.C.B 1 3 9 4 2 2 9 6 5 1 3 PANEL, HT-SINK AC P.C.B P.C.B P.C.B SH,PWB w w w u 1 6 3 CDC-X707M,X7070M(YUSTF) (FileName:EXP.EPS)
http://www.xiaoyu163.com CD MECHANISM EXPLODED VIEW 1 / 1 3 7 63 1515 0 TABLE,DISC PICK BASE ASSY SENSOR, P.C.B MOTOR SPINDLE RF-400CA CORD 3P LEAD MOTOR A L 13942296513 LEAD MOTOR B u163 LEAD 2P – 33 – http://www.xiaoyu163.com...
http://www.xiaoyu163.com CD MECHANISM PARTS LIST 1 / 1 3 7 63 1515 0 REF. NO. PART NO. KANRI DESCRIPTION REF. NO. PART NO. KANRI DESCRIPTION 1 S1-100-510-130 COVER TOP 36 S1-100-520-170 LEVER,R 2 S1-100-510-090 LEVER RELEASE 37 S1-100-520-140 GEAR H CAM 3 S1-100-510-180 ARM START SET 38 S1-100-540-080...