Download
Share
Print this page
Alpine HDA-5460 Service Manual
  1. Manuals
  2. Brands
  3. Alpine Manuals
  4. Car Receiver
  5. HDA-5460
  6. Service manual
Alpine HDA-5460 Service Manual

Alpine HDA-5460 Service Manual

Hdd player
Hide thumbs Also See for HDA-5460:

Advertisement

Quick Links

Download this manual See also: Owner's Manual
SERVICE MANUAL
PWR
HDA-5460
HDD PLAYER
HDD
ACCESS
7 / 03-A
68E35662S01

Advertisement

loading

Related Manuals for Alpine HDA-5460

Summary of Contents for Alpine HDA-5460

  • Page 1 SERVICE MANUAL HDD PLAYER ACCESS 7 / 03-A 68E35662S01 HDA-5460...
  • Page 2 <Cautions for Safe Repair Work> The following cautions will prevent accidents in the workplace and will ensure safe products. *The symbols indicate caution is needed to prevent injuries and damage to property. The symbols and their meanings follow. If you ignore this symbol and handle the product incorrectly or unsafely, Warning serious injury or death may result.

  • Page 3: Packing Assembly Parts List

    Packing Assembly Parts List HDA-5460 Symbol Description Symbol Description Part No. Part No. 101-1 03S72235F13 SCR,MCH M5X8 FLAT 01T65697Y01 ASSY,WIRE COAX 101-2 59T35625Y03 MAGNET,TFC-16816 01T15832W01 ASSY,RCA-RCA 600(NEW $1 101-3 36A11113W01 CAP,RUBBER(A) 01T65652Y01 ASSY,NSJ-H03 $1 101-4 03A11112W01 BOLT,HEX.M5(A) 99T75204Y01 CD ROM DISC 5460V1.0...

  • Page 4: Specifications

    HDA-5460 Specifications <HDD SECTION> Channel Balance (1kHz) ........................... 0±3dB Distortion (1kHz) ..............................0.3% Frequency Response (Ref. 1kHz) ......................20Hz : 0±3dB 100Hz : 0±2dB 10kHz : 0±2dB 20kHz : 0±4dB S/N Ratio ................................75dB Separation (1kHz) ............................... 75dB <GENERAL> Power Supply ..............................DC14.4V Output Level (Ref.

  • Page 5: Extension Cable

    HDA-5460 Extension Cable Front ASSY,MAIN PWB CB3001 Rear Expansion HDD EXT. Cable 20P (01V35647S01) ASSY,HDD UNIT CB304 It fixes to a chassis using the wire binder of attachment on a cable.

  • Page 6: Block Diagram

    HDA-5460 Block Diagram ACC- BATT- AUDIO MD-SERVO-DCDC DIG-DCDC MAIN P.W.Board DCDC-ON PWR-ON ET202 AI-NET AI-NET RESET- BATT MONITOR AUDIO-SW MUTE DIN202 ISO-AMP AI-NET CHG/MD+MS MAIN u-COM MUTE-ON/OFF ANALOG SLAVE/STANDALONE switching signal JK202 ISO-AMP TC4W53F BUFFER- HDD P.W.Board HDD HOST 16GBYTE...
  • Page 7 Q520 R573 2SB710A Q521 UN2212 IC501 R509 4 7k MB88385CPF L502 R505 R510 4 7k 160 1/4 R511 4 7k 0 47uH R512 4 7k R507 R538 160 1/4 R513 4 7k R537 L503 4 7k 0 47uH R508 160 1/4 R506 160 1/4 R514...
  • Page 8 R272 L201 R271 C205 3900p C207 IC250 R270 UDA1351TS R209 L204 R201 R205 R207 E201 1 2k 1 2k R213 R215 E203 ET202 47 1 4 10 1/4 C236 2 2 35 (B P) ASSY WIRE AI TA5460 L202 0 1 B CB202 C235 2 2/35 (B P)
  • Page 9 L802 Q806 L813 Q854 2SB1261 D806 220uH L814 L801 2SB1261 220uH DSM3MA4 220uH Q862 220uH 2SC2983 IC809 R821 NJM2360AM IC810 R869 1 5k 1 4 Q863 XN1A312 R813 R847 Q802 R822 1 1k 1/4 2SC2983 1 8k 1/4 IC801 NJM4580V Q805 R895 XN1A312...
  • Page 10 2 2k 1/4 R327 22k 1/4 R382 Q308 UN2212 UN2212 Q305 IC353 LM2596SX R387 2 2k 1/4 D310 S1G 6904 TP345 TP344 L301 R316 100uH R317 R318 JK301 JAC HEC3150 012110 R319 R306 R331 C308 TP305 R445 0 1/4 R301 CB302 R360 WTB 54819 012 05...
  • Page 11 R429 R469 R457 100k R484 SD305 R467 R458 100k R485 SB05 05CP R466 R470 100k R486 R302 R471 R487 100k R465 0 1/10 R472 100k R488 R473 100k R489 R464 R474 R490 100k R475 R491 100k R476 100k R492 R462 R477 R493 100k...
  • Page 12 C944 C953 C948 C949 C945 IC906 S 81233SGUP IC903 C904 HY23C16202M HY23C16202M R983 R990 RA936 470x4 R967 Z906 R993 NFR21GD470680 C936 R909 RA939 IC902 TP905 TP907 470x4 M66710FP TP908 R907 R951 R936 TP906 C924 C912 RA945 470x4 C911 R934 Z905 NFA31GD470101 R920 100k...
  • Page 13 Q908 2SA1036K Q910 UN2211 Q911 UN2213 Q909 UN221L CH901 R996 BTB,TMD V15P A1 1k 1/8 R994 Z902 1k 1/8 NFE31PT222Z1E R999 1k 1/8 R916 R995 1k 1/8 R917 R997 1k 1/8 R998 1k 1/8 R1000 2 2k R922 Z907 NFA31GD470101 RA982 1kx4 R946...
  • Page 14 C3001 1000p TP3001 R3005 R3010 R3014 R3015 R3016 R3017 CB3002 R3018 IMSA9220B 20Z R3019 CB3001 BTFW20P 3SSTA...
  • Page 15 CH305 IMSA9705S 43Z...

  • Page 16: Terminal Voltage Of Ic/Tr

    HDA-5460 Terminal Voltage of IC/TR IC203 IC204 HDD Rch output CHG Rch output HDD Rch NF input CHG Rch NF input HDD Rch input CHG Rch input HDD Lch input CHG Lch input HDD Lch NF input CHG Lch NF input...
  • Page 17 HDA-5460 IC250 AUDIO Lch out AUDIO Rch out DAI-IN *DAI=Digital audio interface=IEC958=SPDIF IC302 IC304 IC305 mode mode mode IC307-1(HDD mode) transmission speed is 12MbPS (FS mode). *DAI=Digital audio interface=IEC958=SPDIF...
  • Page 18 HDA-5460 IC307-1(HDD mode) HDD access PS/0 PS/0 / HDD stop PS/0 PS/0 PS/0 PS/0 HDD access PS/0 / HDD stop PS/0 PS/0 PS/0 PS/0 PS/3.3 HDD access / HDD stop PS/3.3 PS/3.3 HDD access PS/3.3 / HDD stop PS/3.3 PS/3.3 HDD spinde moter "on"...
  • Page 19 HDA-5460 IC353 HDD spinde moter "on" /HDD stop 5/0.7 HDD mode 5/0.7 HDD spinde moter "on" /HDD stop 0/6.8 IC354 IC355 HDD mode HDD mode IC501 STAND STAND NOTE NOTE ALONE ALONE PS(AI-NET interface communication) PS(AI-NET interface communication) PS(AI-NET interface...
  • Page 20 HDA-5460 IC550 Usually/ ACC-off or FRONT unit remove Usually/Hot temperature environment or test mode Power on/Power off Usually/ 0/PS Usually/ACC-off or When a buzzer sounds power-off or FRONT unit remove ACC-ON and Usually/ACC-off or power off FRONT unit an attachment...
  • Page 21 HDA-5460 IC801 IC803 IC804 MODE NOTE 40kHz 1.25 mode 14.4 14.4 IC805 14.4 IC807 IC808 1.25 OELD OELD PS(100kHz) lighting lighting IC809 1.25 14.4 PS(100kHz) mode 14.4 mode IC811 OELD lighting...
  • Page 22 HDA-5460 IC901 20MHz 20MHz 20MHz Key A/D state in Rotary encoder state Rotary encoder state Self return encoder in / It is set to 0V at the time of lower position. HDD mode/other mode PS/0 No dimmer state/dimmer IC902 20MHz...
  • Page 23 HDA-5460 IC903 IC904 IC905 IC906 NOTE Ref.No. Q203 0/9.5 0/9.5 Usually/Mode change Q301 NOTE Ref.No. Q202 8.7/0 0/8.7 4.8/0 0/4.8 HDD/CHG Usually/Mode change Q502 0/14.4 14.4 0/3.2 Q801 14.4 14.4 HDD mode Q805 14.4 14.4 Q807 ACC(14.4V) Q808 Q815 14.4 14.4...
  • Page 24 HDA-5460 NOTE Ref.No. Q305 0/6.8 3.3/0 Q306 4.5/2.6 4.5/4.1 *HDD spinde moter "on" state/HDD stop Q308 0/6.8 *HDD mode Q309 4.5/4.1 HDD mode Q310 Q501 H/U reset Usually/Mode change Q504 0/3.2 Q520 Q521 Q802 14.4 HDD mode Q806 14.4 Q817 14.4...
  • Page 25 HDA-5460 PP5002 : IC307 Symbol Terminal Description A. TXD Transmit data output terminal to MAIN u-COM. No connect terminal. A. RXD Receive data input terminal from MAIN u-COM. No connect terminal. Power supply terminal. (3.3V) GND connect terminal. XM2_ MD00...
  • Page 26 HDA-5460 Symbol Terminal Description NC(PULL-DOWN) Pull-down connect terminal. /STBY STANBY signal input terminal from MAIN u-COM GND connect terminal. VCC1 Power supply terminal. (1.8V) XM2_ MA15 Address output terminal. (SDRAM, ROM) XM2_ MA16 XM2_ MA17 Address output terminal. (ROM) XM2_ MA18...
  • Page 27 HDA-5460 Symbol Terminal Description RTCK(NC) No connect terminal. XM2_ CKE CKE signal output terminal. (SDRAM) GND connect terminal. VCC2 Power supply terminal. (1.8V) RESET Reset input teminal. NC(PULL-DOWN) Pull-down connect terminal. No connect terminal. NC(PULL-DOWN) Pull-down connect terminal. SPDIF_ CLK Clock signal input terminal.
  • Page 28 HDA-5460 Symbol Terminal Description CLK_ SYS. OUT Clock output terminal. (SDRAM) GND connect terminal. AT3_ HD00 AT3_ HD01 AT3_ HD02 AT3_ HD03 AT3_ HD04 AT3_ HD05 AT3_ HD06 AT3_ HD07 I/O Data input/output terminal. (HDD) AT3_ HD08 AT3_ HD09 AT3_ HD10...
  • Page 29 HDA-5460 Symbol Terminal Description F-START Communication start control signal output terminal to FRONT u-COM. F-RESET RESET control signal output terminal to FRONT u-COM. F-SI Data input terminal from FRONT u-COM. F-SO Data output terminal to FRONT u-COM. F-CLK Clock input terminal from FRONT u-COM.
  • Page 30 HDA-5460 Symbol Terminal Description VHH-ON Power control signal output terminal for OELD. HDD+B Power control signal output terminal for HDD. MS+B Power control signal output terminal for MS. DC-DC-ON DC-DC power control signal output terminal. A-MUTE AUDIO MUTE control signal output terminal.
  • Page 31 HDA-5460 D70F3033BGC : IC901 Symbol Terminal Description No connect terminal. VHH-CONT2 Power control signal output terminal for OELD. FRONT-SO Data input terminal from MAIN u-COM. FRONT-SI Data output terminal to MAIN u-COM. FRONT-CLK Colck output terminal to MAIN u-COM. Power supply terminal.
  • Page 32 HDA-5460 Symbol Terminal Description I/O Data treminal for Outer graphic ROM. BVDD Power supply terminal. BVSS GND connect terminal. AD10 AD11 Data treminal for Outer graphic ROM. AD12 AD13 AD14 AD15 Address treminal for Outer graphic ROM. AVDD Power supply terminal of A/D converter.
  • Page 33 HDA-5460 Exploded View (Cabinet) ET801 ET202 7 X2 18 X2 CB302 JK301 JK002 DIN202 M804 CB501 SW901 SW902 CH901 OELD902...
  • Page 34 HDA-5460 Cabinet Assembly Parts List 55 07D00749K02 BKT,SIDE R 56 03S44205G41 SCR,T-TITEM2.6X4 BLK Note : The part that has not PART NUMBER will not be supplied. 01V66330Y65 ASSY,NOSE UNIT 5460A - - - - - - - - - - -...

  • Page 35: Electrical Parts List

    HDA-5460 Q864 48T92368F04 TR,2SD1760 R - E5 Electrical Parts List =======Diodes *******MAIN P.W.Board D201 48T25651W01 DIO,CP MA152WA =======IC's D202 48T68828F11 DIO,1SS133 -RH IC203 51T25576W07 NJM4580V-TE2 -SE2 D204 48T25593Y01 DIO,S1G-6904 IC204 51T25576W07 NJM4580V-TE2 -SE2 D501 48T63462F01 DIO,CP.DAN202K -96 IC205 51T25576W07 NJM4580V-TE2 -SE2...
  • Page 36 HDA-5460 C510 08S45677W12 CAP,CER.10RD-CH1H- CP C511 08S45677W21 CAP,CER 24RJ- CH1H-CP =======Thermistors C512 08S45677W20 CAP,CER.22RJ- CH1H-CP TH502 48T25250Y10 TMT,ERTJ1VV104G -CP C513 08S35350Y04 CAP,CER 105K-B1C -CP TH801 48T25250Y06 TMT,ERTJ1VR223G -CP C514 08S45676W85 CAP,CER 104K-B1C -CP =======Buzzer C515 08S45676W85 CAP,CER 104K-B1C -CP BZ801...
  • Page 37 HDA-5460 E218 23S45639Y08 CAP,ELY 22R-1C -R2 R205 06S55365Y67 RES,RK 122J 1/10 -CP E220 23S45639Y08 CAP,ELY 22R-1C -R2 R206 06S55365Y67 RES,RK 122J 1/10 -CP E222 23S45639Y10 CAP,ELY 101-1C -R2 R207 06S55365Y67 RES,RK 122J 1/10 -CP E223 23S45639Y07 CAP,ELY 10R-1C -R2 R208...
  • Page 38 HDA-5460 R292 06S55365Y65 RES,RK 102J 1/10 -CP R574 06S55365Y65 RES,RK 102J 1/10 -CP R293 06S55365Y89 RES,RK 103J 1/10 -CP R575 06S55365Y65 RES,RK 102J 1/10 -CP R294 06S55365Y89 RES,RK 103J 1/10 -CP R580 06S55365Y97 RES,RK 223J 1/10 -CP R501 06S55365Y69 RES,RK 152J 1/10 -CP...
  • Page 39 HDA-5460 R858 06S55366Y06 RES,RK 473J 1/10 -CP IC354 51T65263Y03 TA48018F-TE16L1 -NE5 R859 06S55361Y73 RES,RK 222J 1/4 -CP IC355 51T45703Y01 TA48M033F-TE16L -NE5 R860 06S55366Y06 RES,RK 473J 1/10 -CP =======Transistors R861 06S55361Y52 RES,RK 301J 1/4 -CP Q301 48T65318Y01 FET,HN1K02FU-85L -CP R862 06S55361Y77 RES,RK 332J 1/4 -CP...
  • Page 40 HDA-5460 C321 08S45232Y17 CAP,CER 104K-B0J -CP R310 06S15616Y23 RES,RK JUMPER1/16-CP C322 08S45232Y17 CAP,CER 104K-B0J -CP R311 06S15615Y49 RES,RK 102J 1/16 -CP C324 08S45232Y17 CAP,CER 104K-B0J -CP R313 06S55366Y39 RES,RK JUMPER1/10-CP C325 08S45232Y17 CAP,CER 104K-B0J -CP R314 06S15615Y73 RES,RK 103J 1/16 -CP...
  • Page 41 HDA-5460 R383 06S15615Y73 RES,RK 103J 1/16 -CP RA318 06S15771Y10 RES,ARYEXB28V56RJ-CP R384 06S15615Y73 RES,RK 103J 1/16 -CP RA319 06S15771Y10 RES,ARYEXB28V56RJ-CP R385 06S15594Y14 RES,RK 474F 1/10 -CP RA320 06S15771Y10 RES,ARYEXB28V56RJ-CP R386 06S55361Y57 RES,RK 471J 1/4 -CP RA321 06S15771Y05 RES,ARYEXB28V22RJ-CP R387 06S55361Y73 RES,RK 222J 1/4 -CP...
  • Page 42 HDA-5460 R914 06S55365Y41 RES,RK 101J 1/10 -CP R915 06S55361Y76 RES,RK 302J 1/4 -CP =======Switches R916 06S55365Y97 RES,RK 223J 1/10 -CP SW,TACT SKRPACE010E2 SW903 40T65353Y01 (DISP) R917 06S55365Y97 RES,RK 223J 1/10 -CP SW,TACT SKRPACE010E2 R918 06S55365Y65 RES,RK 102J 1/10 -CP SW904...
  • Page 43 HDA-5460 R992 06S55365Y41 RES,RK 101J 1/10 -CP =======Connectors R993 06S55365Y53 RES,RK 331J 1/10 -CP CB3001 09T75237Y20 BTB,BTFW20P-3SSTA-EJ R994 06S55363Y65 RES,RK 102J 1/8 -CP CB3002 09T45223Y20 PIN,IMSA9220B-20Z-DB R995 06S55363Y65 RES,RK 102J 1/8 -CP R996 06S55363Y65 RES,RK 102J 1/8 -CP *******FPC,F2Y090 P.W.Board...