Advertisement
Table of Contents
- 1 Table of Contents
- 1 1 General Information
- 2 2 Safety Precautions
- 3 3 Mechanical / Electrical Specifications
- 4 4 Unpacking and Storage
- 5 5 Module Installation
- 6 6 Mounting Instructions
- 7 7 Maintenance
- 8 Amended Editions and Dates
- 9 Annex A: Mechanical and Electrical Ratings
- 10 Annex B: Double Glass Module
- Download this manual
Advertisement
Table of Contents
Related Manuals for Canadian Solar Dymond CS6K-245P-FG
Summary of Contents for Canadian Solar Dymond CS6K-245P-FG
- Page 1 INSTALLATION MANUAL OF DYMOND MODULE For professional use only...
- Page 2 EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc.
-
Page 3: Table Of Contents
GENERAL INFORMATION INSTALLATION MANUAL DISCLAIMER LIMITATION OF LIABILITY SAFETY PRECAUTIONS MECHANICAL / ELECTRICAL SPECIFICATIONS UNPACKING AND STORAGE MODULE INSTALLATION MODULE WIRING MODULE GROUNDING MOUNTING INSTRUCTIONS MAINTENANCE | 10 AMENDED EDITIONS AND DATES | 10 ANNEX A: MECHANICAL AND ELECTRICAL RATINGS | 12 ANNEX B: DOUBLE GLASS MODULE INSTALLATION MANUEL SUPPLEMENT... -
Page 4: General Information
The information contained in this manual is subject to change by Canadian Solar Inc. without prior notice. Canadian Solar Inc. gives no warranty of any GENERAL SAFETY kind whatsoever, either explicitly or implicitly, with respect to the information contained herein. -
Page 5: Mechanical / Electrical Specifications
25°C. Detailed electrical and mecha- · place excessive loads on the module or nical characteristics of Canadian Solar Inc. crystalline twist the module frame. silicon PV modules can be found in Annex A (Mecha- nical And Electrical Ratings). Main electrical charac- ·... -
Page 6: Module Installation
· Please consult the Canadian Solar Inc. technical support department for more information on the DO NOT STAND OR STEP on the use of modules in special climates. Please note modules under any circumstances. EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc. -
Page 7: Module Wiring
· Failure to comply with these instructions will void Canadian Solar Inc. warranty. OPTIMUM ORIENTATION AND TILT · To maximize your annual yield, find out the optimum INSTALLATION REQUIREMENTS orientation and tilt for PV modules in your region. -
Page 8: Module Grounding
CONNECTOR PROTECTION · Each module must be securely fastened at a · Protect exposed connectors from weathering minimum of 4 points on two opposite sides. EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc. -
Page 9: Maintenance
UL1703 when mounted as specified in the inst- ructions in ANNEX B. Any module without a frame · Canadian Solar Inc. warranty may be void in cases (laminate) shall not be considered to comply with where improper clamps or unsuitable installation the requirements of UL 1703 unless the module is methods are found. -
Page 10: Amended Editions And Dates
30.5 8.35 37.7 8.87 0.23 in) CS6K-260M-FG 30.7 8.48 37.8 8.99 without CS6K-265M-FG 30.9 8.61 37.9 9.11 junction-box CS6K-270M-FG 31.1 8.67 38.2 9.19 and corner protector CS6K-275M-FG 31.3 8.80 38.3 9.31 EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc. - Page 11 | 11 Maximum Operating Operating Open Circuit Short Circuit Max. Series Overall Weight Module Type Power voltage current Voltage Current Fuse Dimension <kg> Pmax <W> Vmp <V> Imp <A> Voc <V> Isc <A> Rating <A> <mm> CS6K-280M-FG 31.5 8.89 38.5 9.43 CS6K-285M-FG 31.7...
-
Page 12: Annex B: Double Glass Module
Mounting rails must run perpendicularly to the module long side. module long side. The following clamps in table 2 have been approved as compatible with Canadian Solar double glass module CS6K-P-FG, CS6K-M-FG and CS6K-MS-FG. EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc. - Page 13 | 13 Table 2: CS6K-P-FG, CS6K-M-FG and CS6K-MS-FG compatible clamps Mounting Clamp Quantity Certification Supplier Clamp Image Clamp Type & length Load (Pa) Method & Location Body four clamps, Downforce load≤2400 Pa 2-A-1 A=380±20 mm, VDE / CSA Uplift load ≤2400 Pa see illustration A SA-TOK-UA (End clamp) NISSEI METALS...
- Page 14 B=579±20 mm, Uplift load ≤2400 Pa clamp length=100 mm see illustration B The following clamps in table 3 have been approved as compatible with Canadian Solar double glass module CS6X-P-FG and CS6X-M-FG. EN-Rev IM-FDM-EN/1.6 Copyright © March 2017. Canadian Solar Inc.
- Page 15 | 15 Table 3: CS6X-P-FG and CS6X-M-FG compatible clamps Mounting Clamp Quantity Certification Supplier Clamp Image Clamp Type & length Load (Pa) Method & Location Body SA-TOK-UA (End clamp) six clamps, NISSEI METALS / SA-KOK-UA (Middle A=300±20mm, Downforce load≤2400 Pa 3-A-1 CO.,LTD.
- Page 16 For detailed information, please follow local structural code or contact professional structural engineer. (*) Connector protector is not included in the above illustration. CANADIAN SOLAR INC. 545 Speedvale Avenue West, Guelph, Ontario, Canada N1K 1E6 www.canadiansolar.com...