CLP-150/CLP-150M/CLP-150C IMPORTANT NOTICE This manual has been provided for the use of authorized Yamaha Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically Yamaha Products, are already known and understood by the users, and have therefore not been restated.
Page 6
CLP-150/CLP-150M/CLP-150C DISASSEMBLE PROCEDURE Music Rest Assembly Back Board Assembly (Time required : About 3 minutes) (Time required : About 3 minutes) Remove the four (4) screws marked [51]. The music rest Remove the two (2) screws marked [B] and the four (4) assembly can then be removed.
Page 7
CLP-150/CLP-150M/CLP-150C Circuit Boards & Assemblies Inside of Main Unit (Time required : About 10 minutes each) Remove the top board assembly. (See procedure 2) Each circuit board and assembly can be removed by removing its fixing screws as listed below.
Page 8
CLP-150/CLP-150M/CLP-150C MA120 Circuit Board FU120L Circuit Board (Time required : About 15 minutes) (Time required : About 15 minutes) Remove the top board assembly. (See procedure 2) Remove the top board assembly. (See procedure 2) Remove the MA120 assembly. (See procedure 4) Disconnect the AC cord.
Page 9
CLP-150/CLP-150M/CLP-150C Key Cover Assembly Speaker (Tweeter) (Time required : About 10 minutes) (Time required : About 10 minutes) Close the key cover. 10-1 Remove the top board assembly. (See procedure 2) Remove the top board assembly. (See procedure 2) 10-2 Remove the key cover assembly.
Page 10
CLP-150/CLP-150M/CLP-150C Rack Assembly (Time required : About 15 minutes) 12-1 Remove the top board assembly. (See procedure 2) 12-2 Remove the key cover assembly. (See procedure 9) 12-3 Remove the speaker box assembly. (See procedure 11) 12-4 Remove the four (4) screws marked [6C] and the screw marked [80B].
CLP-150/CLP-150M/CLP-150C Circuit Boards & Assemblies of Panel Assembly (Time required : About 25 minutes) 14-1 Remove the top board assembly. (See procedure 2) 14-2 Remove the key cover assembly. (See procedure 9) 14-3 Remove the panel assembly. (See procedure 13)
Page 12
CLP-150/CLP-150M/CLP-150C End Block Assembly [69] End block assembly L (Time required : About 25 minutes) 15-1 Remove the top board assembly. (See procedure 2) 15-2 Remove the key cover assembly. (See procedure 9) 15-3 Remove the panel assembly. (See procedure 13) 15-4 Remove the screw marked [69].
Page 13
CLP-150/CLP-150M/CLP-150C Headphones Jack Assembly, HP Circuit PL Circuit Board Board (Time required : About 30 minutes) (Time required : About 30 minutes) 19-1 Remove the top board assembly. (See procedure 2) 18-1 Remove the top board assembly. (See procedure 2) 19-2 Remove the key cover assembly.
Page 14
CLP-150/CLP-150M/CLP-150C Main Unit Back Top Board Assembly (Time required : About 40 minutes) 21-1 Remove the top board assembly. (See procedure 2) 21-2 Remove the key cover assembly. (See procedure 9) 21-3 Remove the speaker box assembly L and R.
Page 15
CLP-150/CLP-150M/CLP-150C Side Board Assembly Pedal Box Assembly, Pedal Assembly (Time required : About 15 minutes) (Time required : About 15 minutes) 24-1 Remove the back board assembly. (See procedure 3) 25-1 Disconnect the PK-LF cable. 24-2 Remove the main unit. (See procedure 22)
Page 16
CLP-150/CLP-150M/CLP-150C Disassembling the Keyboard 26-4 White key Insert a thin plate between the white keys, near the (Time required : About 15 minutes) triangle mark around the fulcrum of the key, and press After inserting a round stick (Rod: TX000670) between the frame and the keys, remove the circuit boards.
Page 17
CLP-150/CLP-150M/CLP-150C Assembling the Keyboard Hammer, white key (Time required : About 15 minutes) 27-1 Hammer, White Key (Hammer, Black Key) Stopper (L88_W) Place the keyboard assembly upside-down, insert a hammer assembly into the frame, and put the stopper (L88_W) on. (Fig. 32) There are four (4) kinds of hammers that differ in weight.
CLP-150/CLP-150M/CLP-150C LSI PIN DESCRIPTION HD6417709SHF200 (X2687A00) CPU (SH3) ......... . . 19 M66291GP (X2156A00) USB Controller .
Page 19
CLP-150/CLP-150M/CLP-150C HD6417709SHF200 (X2687A00) CPU (SH3) DM: IC014 NAME FUNCTION NAME FUNCTION CKE/PTK5 CK enable / Port K Mode control RAS3L/PTJ0 RAS address bus / Port J Vcc(RTC) Power supply +1.8 V PTJ1 Port J XTAL2 CASL/PTJ2 CAS address bus / Port J...
Page 20
CLP-150/CLP-150M/CLP-150C T8F02TB-0102 (X0060A00) SWP50 (Tone Generator) DM: IC012 OUTER OUTER NAME FUNCTION NAME FUNCTION VSS2 Ground VSS2 Ground VDDC Power supply +1.5 V VDDC Power supply +1.5 V CD15 HMA15 CD13 HMA16 Wave memory address bus CD14 HMA22 HMA25 VDDS...
Page 21
CLP-150/CLP-150M/CLP-150C OUTER OUTER NAME FUNCTION NAME FUNCTION AB22 VSS2 Ground VSS2 Ground AC23 VDDC Power supply +1.5 V VDDC Power supply +1.5 V AD24 DMAL1 Address bus (DIMM, SDRAM) MELI6 MEL wave data input AE25 DCSL2 MELI7 AF26 DRAS0 ADLR...
Page 22
CLP-150/CLP-150M/CLP-150C M66291GP (X2156A00) USB Controller DM: IC002 NAME FUNCTION NAME FUNCTION Core Vcc Core power supply Ground USB data (-) USB data (+) Vbus V bus input Data bus Tr ON Tr ON output TEST TEST input D8/P0 /Dack1 DMA reception signal 1...
Page 25
CLP-150/CLP-150M/CLP-150C AJK Circuit Board Component side Pattern side...
Page 26
CLP-150/CLP-150M/CLP-150C DM Circuit Board (XZ592H0) to DJK-CN8 to AJK-CN500 Component side to DJK-CN5 to PNL-CN101, to DJK-CN6 GHD EBUS L-CN1 2NA-V755310...
Page 27
CLP-150/CLP-150M/CLP-150C DM Circuit Board (XZ592H0) Pattern side 2NA-V755310...
Page 28
CLP-150/CLP-150M/CLP-150C DJK Circuit Board to DM-CN8 to DM-CN5 to MA120-CN4 to DM-CN3 to DM-CN7 Component side Pattern side PEDAL (DJK) Circuit Board Component side Pattern side to PEDAL (SW)-CN1 DJK: 2NA-V849640 2 PEDAL (DJK): 2NA-V849640 2...
Page 29
CLP-150/CLP-150M/CLP-150C MA120 Circuit Board NET1 Circuit Board to Woofer and Tweeter Speakers to DJK-CN10, N.C. Component side AJK-CN540 CN002 XT123 CAUTION: REPLACE WITH SAME TYPE 5A 125V FUSE. ATTENTION: UTILISER UN FUSIBLE DE RECHANGE DE MÉME TYPE DE 5A 125V.
Page 30
CLP-150/CLP-150M/CLP-150C PNL Circuit Board to DM-CN4 to PNR-CN81 to PNR-CN71 Component side 2NA-V845480...
Page 31
CLP-150/CLP-150M/CLP-150C PNL Circuit Board Pattern side 2NA-V845480...
Page 32
CLP-150/CLP-150M/CLP-150C PNR Circuit Board to DM-CN1 to DM-CN2 MV2 Circuit Board HP Circuit Board PHONES Component side to PL-CN1 to AJK-CN530 Component side PL Circuit Board PNR: 2NA-V845520 1 MV2: 2NA-V845520 1 Component side 2NA-V004770 4 POWER to HP-CN2 2NA-VN63740...
Page 33
CLP-150/CLP-150M/CLP-150C to PNL-CN80 to PNL-CN70 Component side FU120L Circuit Board to Power Transformer (Primary) to POWER SW Component side VOLTAGE SELECTOR AC INLET PNR: 2NA-V845520 1 FU120L: 2NA-VV65070 2...
Page 34
CLP-150/CLP-150M/CLP-150C PEDAL (SW) Circuit Board Left Pedal Sostenuto Pedal Damper Pedal Component side MK SUB Circuit Board Pattern side Component side to GHD EBUS L-CN5 to GHD EBUS L-CN4 PEDAL (SW): 2NA-V767550 MK SUB:...
Page 35
CLP-150/CLP-150M/CLP-150C GHD EBUS L Circuit Board...
Page 36
CLP-150/CLP-150M/CLP-150C GHD M Circuit Board 2NAK8-V852140...
Page 37
CLP-150/CLP-150M/CLP-150C GHD H Circuit Board 2NAK8-V852150...
CLP-150/CLP-150M/CLP-150C TEST PROGRAM Preparation 1) Measuring instruments: Frequency counter, level meter (with JIS-C filter) Note) [PHONES] jack: 33Ω load, [AUX OUT] jack: 10kΩ load 2) Jigs: Foot volume (FC-7), MIDI cable How to enter the Test Program While pressing the [C#2], [F2] and [G#2] keys, turn on the [POWER] switch.
Page 39
CLP-150/CLP-150M/CLP-150C Function and judgment criteria 011: Output R Checks the R channel output. Connect the level meter (with a JIS-C filter) to each output terminal. Set the [MASTER VOLUME] at the MAX. position and check the output level of the R channel.
Page 40
CLP-150/CLP-150M/CLP-150C Function and judgment criteria 027: Song Balance Chk Checks the song balance. When the [SONG BALANCE] control is set to the “SONG” position, the C3 note is output and “SONG BAL MIN” is displayed on the LCD display, when it is set to the “KEYBOARD” position, the G3 note is output and “SONG BAL MAX”...
Page 41
CLP-150/CLP-150M/CLP-150C Table 1 Order Switch Name Note Order Switch Name Note DEMO VIBRAPHONE SONG SELECT T GUITAR SONG SELECT Y CHURCH ORGAN SONG TRACK 1 JAZZ ORGAN SONG TRACK 2 STRINGS SONG EXTRA TRACKS CHOIR SONG TOP SYNTH. PAD SONG START/STOP...
Page 43
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI Many MIDI messages listed in the MIDI Data Format are expressed in decimal numbers, binary numbers and hexadecimal numbers. Hexadeci- mal numbers may include the letter “H” as a suffix. Also, “n”...
Page 44
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI CHANNEL MESSAGE (1) : available MIDI Transmission Status byte 1st Data byte 2nd Data byte MIDI Reception (respond/ignore) PLAY (generated data) Main MIDI Events Panel Recorded Layer...
Page 45
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI CHANNEL MESSAGE (2) Parameters controlled by NRPN (Non-Registered Parameter Numbers) MIDI Transmission NRPN Data Entry MIDI Reception (respond/ignore) PLAY (generated data) Main Parameter Data Range Panel Layer Recorded...
Page 46
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Parameter Change table (SYSTEM INFORMATION) MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data Main Parameter Description Panel Recorded Layer...
Page 47
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data XG Default Main Parameter Description Recorded Layer Panel (main gener- Song Keyboard Song...
Page 48
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Parameter Change table (EFFECT2) MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data Main Parameter Description Panel Recorded Layer Song...
Page 49
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Parameter Change table (MULTI PART) MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data XG Default Main Parameter Description Recorded...
Page 50
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data XG Default Main Parameter Description Recorded Layer Panel (main gener- Song Keyboard Song...
Page 51
MIDI Data Format / MIDI-Datenformat / Format des données MIDI / Formato de datos MIDI MIDI Parameter Change table (DRUM SETUP) MIDI Reception MIDI Transmission PLAY (effective or not for each part) (generated data) Address Size Data XG Default Main Parameter Description Recorded...
Page 52
(main genera- Song Midi Left tion method) Left-Layer 11 0n 02 dd F7 11110000 = Exclusive status 01000011 = YAMAHA ID 01110011 = Clavinova ID 00000001 = Model ID (Clavinova common ID) String Reso- × × 01010000 = SubID nance Depth...
CLP-150/CLP-150M/ CLP-150C PARTS LIST CONTENTS OVERALL ASSEMBLY ......2 DM ASSEMBLY ........19 MAIN UNIT ..........4 MA120 ASSEMBLY ......20 TOP BOARD ASSEMBLY ...... 9 FU120LB ASSEMBLY ......21 PANEL ASSEMBLY ......10 SIDE BOARD UNIT ......22 MUSIC REST ASSEMBLY ....13 PEDAL BOX ASSEMBLY .....
CLP-150/CLP-150M/CLP-150C OVERALL ASSEMBLY Main Unit (See page 4.) Side Board Unit L (See page 22.) Side Board Unit R (See page 22.) Pedal Box Assembly (See page 24.)
Page 55
CLP-150/CLP-150M/CLP-150C PART NO. DESCRIPTION REMARKS REF NO. RANK OVERALL ASSEMBLY CLP-150/150M/150C Main Unit CLP-150 (V828100) Main Unit CLP-150M (V854370) Main Unit CLP-150C (V854410) Main Unit CLP-150 (V828110) Main Unit CLP-150M (V854380) Main Unit CLP-150C (V854420) Main Unit CLP-150 (V828120) Main Unit...
Page 56
CLP-150/CLP-150M/CLP-150C MAIN UNIT FU120LB Assembly Jack Assembly • Bottom view (See page 21.) (See page 18.) Jack Assembly MA120 Assembly FU120LB Assembly • Top view (See page 18.) (See page 20.) (See page 21.) DM Assembly (See page 19.) 81 82...
Page 57
CLP-150/CLP-150M/CLP-150C • Rear view U only U only • Top view U only U only U only U only U only Panel Assembly (See page 10.) End Block Assembly R End Block Assembly L (See page 16.) (See page 16.) Music Rest Assembly (See page 13.)
Page 58
CLP-150/CLP-150M/CLP-150C PART NO. DESCRIPTION REMARKS REF NO. RANK MAIN UNIT CLP-150/150M/150C Main Unit CLP-150 (V828100) Main Unit CLP-150M (V854370) Main Unit CLP-150C (V854410) Main Unit CLP-150 (V828110) Main Unit CLP-150M (V854380) Main Unit CLP-150C (V854420) Main Unit CLP-150 (V828120) Main Unit...
Page 59
CLP-150/CLP-150M/CLP-150C PART NO. DESCRIPTION REMARKS REF NO. RANK V 8 4 3 2 8 0 0 Back Top Panel Assembly CLP-150 V 8 5 4 7 5 0 0 Back Top Panel Assembly CLP-150M V 8 5 4 7 7 0 0...
Page 65
CLP-150/CLP-150M/CLP-150C MUSIC REST ASSEMBLY • Rear view • Side view PART NO. DESCRIPTION REMARKS REF NO. RANK MUSIC REST ASSEMBLY CLP-150/150M/150C V 8 3 8 8 0 0 0 Music Rest Assembly CLP-150 V 8 5 5 8 2 0 0...
Page 66
CLP-150/CLP-150M/CLP-150C ARM ASSEMBLY 3 3a Arm Assembly L PART NO. DESCRIPTION REMARKS REF NO. RANK ARM ASSEMBLY L LEFT CLP-150/150M/150C V 8 2 8 1 9 0 0 Arm Assembly L LEFT CLP-150 V 8 5 4 5 1 0 0...
Page 67
CLP-150/CLP-150M/CLP-150C FRONT RAIL ASSEMBLY • Side view • Bottom view • Top view PART NO. DESCRIPTION REMARKS REF NO. RANK FRONT RAIL ASSEMBLY CLP-150/150M/150C Front Rail Assembly CLP-150 (V821910) Front Rail Assembly CLP-150M (V854950) Front Rail Assembly CLP-150C (V854990) Front Rail Assembly...
Page 68
Holder, Power Switch (V522000) Angle H 1.2 L (V533550) VF663400 Knob Black CLP-150/150M POWER V 6 2 5 0 7 0 0 Knob Brown CLP-150C POWER V 8 7 6 8 9 0 0 Power Switch Assembly VC843500 Push Switch SDDLB1216A J.U.C.S...
Page 70
CLP-150/CLP-150M/CLP-150C JACK ASSEMBLY • Front view • Top view • Side view PART NO. DESCRIPTION REMARKS REF NO. RANK JACK ASSEMBLY CLP-150/150M/150C Jack Assembly (V964290) Jack Assembly B,E,N,K (V862710) Angle, Jack (V862720) V 8 4 9 6 5 0 0...
Page 71
CLP-150/CLP-150M/CLP-150C HEADPHONES JACK ASSEMBLY PART NO. DESCRIPTION REMARKS REF NO. RANK HEADPHONES JACK ASSEMBLY CLP-150/150M/150C Headphones Jack Assembly (V878160) Circuit Board V 8 7 8 1 9 0 0 VN631800 Angle, Headphone VB508600 Hexagonal Nut 12.0 14X2 MFZN2BL : New Parts...
Page 73
CLP-150/CLP-150M/CLP-150C FU120LB ASSEMBLY N only N only N only PART NO. DESCRIPTION REMARKS REF NO. RANK FU120LB ASSEMBLY CLP-150/150M/150C V 8 7 8 0 3 0 0 FU120BL Assembly V 7 6 3 1 6 0 0 FU120LB Assembly B,E,K...
Page 74
CLP-150/CLP-150M/CLP-150C SIDE BOARD UNIT • Top view • Front view • Rear view • Side view • Bottom view...
Page 75
CLP-150/CLP-150M/CLP-150C Side Board Unit L PART NO. DESCRIPTION REMARKS REF NO. RANK SIDE BOARD UNIT L LEFT CLP-150/150M/150C V 8 4 3 3 4 0 0 Side Board Unit L LEFT CLP-150 Side Board Unit L LEFT CLP-150M V 8 5 5 2 0 0 0...
Page 97
CLP-150/CLP-150M/CLP-150C PART NO. DESCRIPTION REMARKS REF NO. RANK SW038 VV439800 Tact Switch SKQNAJ CHURCH ORGAN TR091 I C 1 7 4 0 2 0 Transistor 2SC1740S R,S TR092 Transistor 2SC1740S R,S I C 1 7 4 0 2 0 TR093...
Page 98
CLP-150/CLP-150M/CLP-150C CLP-150/CLP-150M/CLP-150C OVERALL CIRCUIT BOARD 1/4 (DM) REGULATOR +2.0V REGULATOR +1.5V (+VCC-ADJ) RESET to PNR-CN91 to PNR-CN92 FLASH ROM SDRAM 64M MASK ROM BUFFER to DJK-CN5 to DJK-CN1 to PEDAL (DJK)-CN11 FLASH ROM SDRAM 64M to PNL-CN101, GHD EBUS L-CN1...
Page 99
CLP-150/CLP-150M/CLP-150C CLP-150/CLP-150M/CLP-150C OVERALL CIRCUIT BOARD 2/4 (GHD EBUS L, MK SUB, GHD M, GHD H, WML, WMH) GHD EBUS L to DM-CN4 MK SUB Not installed Not installed 28CC1-8819224 28CC1-8819027 to DM-CN14 (WML) to DM-CN15 (WMH) WML, WMH GHD M...
Page 100
CLP-150/CLP-150M/CLP-150C CLP-150/CLP-150M/CLP-150C OVERALL CIRCUIT BOARD 3/4 (PNL, PNR, MV2, DJK, PEDAL(DJK), PEDAL(SW), AJK, HP, PL) EQUALIZER AUX IN L/L+R GRAND GRAND E.PIANO E.PIANO HARPSI- E.CLAVI- VIBRA- GUITAR VOICE SPLIT REVERB CHORUS PIANO 1 PIANO 2 CHORD CHORD PHONE SETTING AUX IN...
Page 101
CLP-150/CLP-150M/CLP-150C CLP-150/CLP-150M/CLP-150C OVERALL CIRCUIT BOARD 4/4 (FU120L, MA120, NET1) CLP-150/CLP-150M/CLP-150C CIRCUIT BOARD LAYOUT REGULATOR +5V NET1 MA120 FU120L CN510 CN500 CN530 CN540 CN520 to DM-CN9 M O D E L E, B, N, K AC CORD POWER TRANSFORMER Stick on the side of SP-BOX.