This service manual (B51-8956-00) has been revised due to the modification of the Final Transistor and issues it as a supplemental manual. This service manual applies to products with A8B00001 or subsequent serial numbers. Refer to the TK-6110 service manual for any information which has not been covered in this manual.
Kenwood reserves the right to make changes to any tronic, mechanical, photocopying, recording, or otherwise, products herein at any time for improvement purposes.
TK-6110 PARTS LIST New Parts. indicates safety critical components. L : Scandinavia K : USA P : Canada Parts without Parts No. are not supplied. Y : PX (Far East, Hawaii) T : England E : Europe Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Page 4
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description nation parts parts nation C101 C90-4139-05 ELECTRO 470UF 25WV CC73GCH1H150J CHIP C 15PF C102 CK73GB1H472K CHIP C 4700PF CC73GCH1H270J CHIP C...
Page 5
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C233 CK73GB1H471K CHIP C 470PF C400 CK73GB1H103K CHIP C 0.010UF K C235 CK73GB1H471K CHIP C 470PF...
Page 6
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description nation parts parts nation C550 CC73GCH1H060B CHIP C 6.0PF C716 CK73GB1H471K CHIP C 470PF C550 CC73GCH1H080B CHIP C 8.0PF C720...
Page 7
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation L41-4705-33 SMALL FIXED INDUCTOR(47UH) C820 CC73GCH1H151J CHIP C 150PF L41-2785-33 SMALL FIXED INDUCTOR(0.27UH) C821 CC73GCH1H090D CHIP C 9.0PF...
Page 8
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description nation parts parts nation L504-510 L92-0138-05 CHIP FERRITE R23 ,24 RS14DB3F101J FL-PROOF RS 100 J 3W L511 L40-1285-92 SMALL FIXED INDUCTOR(120NH)
Page 9
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R135 RK73GB2A103J CHIP R J 1/10W R401 RK73GB2A104J CHIP R 100K J 1/10W R136 RK73GB2A394J CHIP R...
Page 10
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description nation parts parts nation R527 RK73GB2A000J CHIP R J 1/10W R637,638 RK73GB2A000J CHIP R J 1/10W R528 RK73GB2A154J CHIP R...
Page 11
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation D102 ZSA5A27 ZENER DIODE R779 RK73GB2A000J CHIP R J 1/10W D103 02DZ15F-X,Y ZENER DIODE R780 RK73GB2A104J...
Page 12
TK-6110 PARTS LIST TX-RX UNIT (X57-6100-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description nation parts parts nation 2SK1824-A KTA1298-P(Y) TRANSISTOR 2SK1824-A RT1N140U-T111 TRANSISTOR 2SB1132(Q,R) TRANSISTOR 2SK1824-A 2SD1757K TRANSISTOR Q101 RT1P141U-T111 TRANSISTOR Q102 RT1P144U-T111...
TK-6110 EXPLODED VIEW The FFC (Flexible Flat Cable) could be inserted to the connector at an angle. Make sure that the cable is inserted into the connector firmly to the end. A M2.6 x 6 (OC) BL : N33-2606-43 C M2.6 x 6 (Br-Tap)
TK-6110 PACKING 65 Microphone (T91-0621-35) 17 Lead wire with 11 Instruction manual connector (B62-1216-10) (E31-3228-05) 16 DC cord 702 Warranty card 50 Holder (E30-3339-15) (J19-1584-15) Pamphlet 27 Fuse (20A) (F51-0080-05) Protection sheet 54 Bracket (H21-0768-04) (J29-0726-03) 62 Screw set (N99-2048-05)
Page 15
TK-6110 ADJUSTMENT ■ Test frequency channel (MHz) : Default setting Key Functions in Panel Test Mode and Panel Tune Mode Knob/Key Test mode Tune mode 1 (Center) 33.300 33.400 42.500 42.600 Test mode/Tune mode changeover 2 (Low) 29.700 29.800 35.000 35.100...
Page 16
TK-6110 ADJUSTMENT Adjustment Points Disassembly for Repair (Speaker) To install the speaker and to style wiring from the speaker, follow the instructions given in the diagram below. L202 CN201 L207 L206 L203 CN202 TC202 TC204 CN204 L237 L222 VR701 L225 L224...
Page 17
TK-6110 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 3. BPF 1) CH-SIG : 2-1 Spectru TX-RX CN201 TX-RX L202 Adjust the coils in Adjust it so it is almost Select _ _L analyzer (A/3)
Page 18
TK-6110 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 7. RF power 1) RF power Power meter Rear Front B key 70w ±1.0W _POW_XXX Ammeter panel panel C key 15A or less 15A or less Adjust the RF power.
Page 19
TK-6110 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment t i s i v i t i s i v i Adjust the sensitivity. All values in Low, Center and High AF VTVM EXT.SP TX-RX L237 frequencies changes one time.
Page 30
TK-6110 SCHEMATIC DIAGRAM TX-RX UNIT DISPLAY SECTION X57-6100-XX B/3 TX-RX UNIT MIC & VOL SECTION X57-6100-XX C/3 D917 MINISMDC020F D917,918 D918 AVRM16080MAAB SURGE PROTECTOR X57-610 (B/3) 1/2...
Page 31
TK-6110 SCHEMATIC DIAGRAM TX-RX UNIT(X57-6100-XX) • Note : The components marked with a dot ( ) are parts of layer 1. X57-610 (B/3) 2/2...
Page 32
Suite 2504, 25/F, Tower 2, Nina Tower, No. 8 Yeung Uk Road, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex Tsuen Wan, New Territories, Hong Kong 1 Ang Mo Kio Street 63, Singapore 569110 KENWOOD House, Dwight Road, Watford, Herts., WD18 9EB United Kingdom...
Page 33
TK-6110 TK-6110 PC BOARD PC BOARD TX-RX UNIT : TX-RX SECTION TX-RX UNIT : TX-RX SECTION D102 (X57-6100-XX)(A/3, C/3) (X57-6100-XX)(A/3, C/3) Component side view Component side view W2– C103 (J79-0225-09) (J79-0225-09) Q108 D108 D109 Ref. No. Address Ref. No. Address...
Page 34
TK-6110 TK-6110 PC BOARD PC BOARD TX-RX UNIT : TX-RX SECTION TX-RX UNIT : TX-RX SECTION (X57-6100-XX)(A/3, C/3) (X57-6100-XX)(A/3, C/3) Foil side view Foil side view C102 (J79-0225-09) (J79-0225-09) IC101 Ref. No. Address Ref. No. Address IC101 Q401 R103 Q101...
Page 35
TK-6110 TK-6110 PC BOARD PC BOARD TX-RX UNIT : DISPLAY SECTION (X57-6100-XX)(B/3) Component side view (J79-0225-09) TX-RX UNIT : DISPLAY SECTION (X57-6100-XX)(B/3) Component side view (J79-0225-09) D910 Ref. No. Address IC902 D901 D902 CH UP D903 D904 IC902 D905 D906...
Page 37
TK-6110 SCHEMATIC DIAGRAM Note : Components marked with a dot (·) are parts of patterun 1. TX-RX UNIT DISPLAY SECTION X57-6100-XX B/3 TX-RX UNIT MIC & VOL SECTION X57-6100-XX C/3 D917 MINISMDC020F D917,918 D918 AVRM16080MAAB SURGE PROTECTOR...