Rolair JC10 Owner's Manual

Rolair JC10 Owner's Manual

Portable air compressor
Hide thumbs Also See for JC10:

Advertisement

PORTABLE AIR COMPRESSOR
OWNER'S MANUAL
MODEL: JC10 & JC13
SERIAL NUMBER: __________________
606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com
- 1 -

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the JC10 and is the answer not in the manual?

Questions and answers

Summary of Contents for Rolair JC10

  • Page 1 PORTABLE AIR COMPRESSOR OWNER’S MANUAL MODEL: JC10 & JC13 SERIAL NUMBER: __________________ 606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com - 1 -...
  • Page 2 COMPRESSOR DISCHARGE AIR MAY CONTAIN HYDROCARBONS AND OTHER CONTAMINANTS! DO NOT USE DISCHARGE AIR FOR BREATHING PARTS Genuine ROLAIR replacement parts are sold nationwide through a network of authorized dealers and ® service centers. Please contact the dealership where your air compressor was purchased or our...
  • Page 3: Table Of Contents

    Associate Engineering Corporation has earned a reputation for providing a product unsurpassed in quality and reliability. We are committed to continuing this tradition by analyzing and adapting to the changing needs and rigorous demands of your industry. You can depend on ROLAIR because they are built to last.
  • Page 4: Safety Warnings - Risk Of Asphyxiation, Bursting, Electrocution

    WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. SAFETY WARNINGS READ AND UNDERSTAND ALL SAFETY WARNINGS BEFORE USING AIR COMPRESSOR Hazard Level Potential of Hazard How to Avoid Hazard Serious injury or death may occur from Never inhale compressed air directly from the pump,...
  • Page 5 SAFETY WARNINGS (con’t) Hazard Level Potential of Hazard How to Avoid Hazard Serious injury may occur from moving parts Never operate the air compressor without protective belt such as belts, pulleys, flywheels or fans if they guards installed. Replace damaged protective covers or come in contact with you or your clothing.
  • Page 6 SYSTEM CONTROLS 1. SAFETY-RELIEF VALVE Every ROLAIR air compressor is equipped with a safety-relief valve which is ® designed to discharge tank pressure at a predetermined setting when a systems failure occurs. Check the safety valve periodically by pulling on the ring only after the tank pressure has been completely drained. The spring loaded valve should move freely within the safety valve body.
  • Page 7: Pre-Start Checklist

    If the compressor has a mysterious leak after stopping that cannot be traced elsewhere, the check valve may require servicing/replacing. Always drain tank pressure completely before attempting to remove or service any component. 9. VIBRATION DAMPENER(S) The rubber pads installed beneath every portable ROLAIR tank assembly are ®...
  • Page 8: Specifications

    Up to 25 ft. 14 Ga. 12 Ga. 25 – 50 ft. 12 Ga. 10 Ga. 50 – 100 ft. 10 Ga. 8 Ga. SPECIFICATIONS JC13 JC10 JC13 JC10 Horsepower Tank Capacity 2.3 Gallon Voltage 115 V Pump-Up Time (0-125 PSI) 1:32 Hertz...
  • Page 9: Operation

    OPERATION WARNING – Your safety and the wellbeing of others during the operation of every ROLAIR compressor is ® our main concern. Do not operate or permit anyone else to operate your air compressor until the information contained in this manual is read and completely understood. Please contact your distributor or our customer service department if you have any questions on the proper use of your air compressor.
  • Page 10: Troubleshooting

    MAINTENANCE SCHEDULE Recommendation Daily Weekly Monthly Quarterly Drain Moisture from Tank(s) Inspect Air Filter(s) Check for Unusual Noise or Vibration Check for Air Leaks Clean Exterior of Air Compressor Check Condition of Vibration Pads Tighten/Retorque Bolts Check Operation of Safety Valve Clean/Change Air Filter Perform Pump Up Time Test Check Operation of System Controls...
  • Page 11: Guarantee

    Our line covers the complete needs of today’s varied air requirements. Rely on ROLAIR for all the newest ® and finest features that are available for the modern compressor. 606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com - 11 -...
  • Page 12 - 12 -...
  • Page 13 Drain Valve JC800-59BV Bolt JC800-29 Cord with Plug JC800-60 Washer JC800-30 Brass Elbow/Tee JC800-61 Stator JC800-31 Cold-Start Valve JC800-62 606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com - 13 -...
  • Page 14: Jc13

    - 14 -...
  • Page 15 Air Filter Assembly JC800-38 Washer JC800-76 Vibration Dampener JC800-39 Eccentric JC800-77 JC800-40 Cylinder JC800-78 Coupler JC800-41 Connecting Tube JC800-79 606 South Lake Street > P.O. Box 346 > Hustisford, WI 53034-0346 > 920.349.3281 > fax 920.349.3691 > www.rolair.com - 15 -...

This manual is also suitable for:

Jc13

Table of Contents

Save PDF