Related Manuals for lakeair LA-1000FM
Summary of Contents for lakeair LA-1000FM
- Page 1 Operating and Service Instructions Model LA-1000FM (LAFC) & LA-800H (HEPA LAFC) Manufactured by: Distributed by Pure n Natural Systems, Inc. 1-800-237-9199 www.purennatural.com...
-
Page 2: Table Of Contents
Component Ch ecks Check Fan Motor and Power Source Check the Electronic Cell Check for Short Circuits Check Transformer and Voltage Doubler Troubleshooting Flowchart Electrical Connections Electrical Schematic LakeAir Electronic Air Cleaners 7 Year Limited Warranty User’s Responsibility Model LAFC Parts Schematic... -
Page 3: Introduction
Recirculated Air for Comfort and Savings customers will breathe air which is relatively free of those With the use of your LakeAir brand Air Cleaner, you will pollutants. Today the emphasis is on health and well being, find that bothersome smoke and other small particles which... -
Page 4: Components Of The Lafc And Hepa Lafc
(Electronic Only) The patented LakeAir power supply has been above for a safe and secure installation HEPA LAFC units. used in thousands of LakeAir EAC’s of all sizes. It is the only Intake Grille power supply in the in-dustry which is guaranteed for seven A fixed position intake grille allows for even distribution of the years. -
Page 5: How Your Lafc Model Works
In business establishments or public buildings, millions of airborne particles are continually being circulated in the air you breathe. Your LakeAir Model LAFC Self Contained Flush Mounted Electronic Air Cleaner removes the smoke, dust, dirt, pollen, and other pollutants from the air with an electrostatic process which works this way: 1. -
Page 6: Installation Instructions
INSTALLATION INSTRUCTIONS IT IS IMPORTANT TO READ THE FOLLOWING INSTRUCTIONS CAREFULLY. DAMAGE TO THE PRODUCT OR TO INSTALLER AND PROPERTY COULD RE-SULT IF INSTRUCTIONS ARE NOT FOLLOWED. Important Safety Precautions 1. Do not connect the power source until after the unit is mounted. Shock and/or damage could result. 2. -
Page 7: Installation Of The Electric Wiring
Installation of the Electrical Wiring Caution: This procedure should only be attempted by persons qualified to install electrical wiring. All wiring must comply with applicable codes and ordinances. 1. Locate a 120V AC, 60 Hz (alternative power sources would be used in the case of the LAFC 230V units) power circuit with a junction box near the air cleaner location. -
Page 8: General Information
The LAFC is capable of 400-1000 cfm. This multiplied by 60 minutes per hour yields the 60,000 figure above. It should be noted that this is an optimum figure and the other considerations above should be made before a final decision is reached. LakeAir can help you if necessary in making a good... -
Page 9: Maintenance
LakeAir dealer to purchase replacement filters. Service Should your LakeAir LAFC malfunction, there are several simple checks which you can use to check the performance before a service person need be called. 1. Check to see if the fuse on the unit is tripped which would indicate electrical interruption to the unit. Correct by replacing fuse. -
Page 10: Troubleshooting Guide And Chart
LakeAir MODEL LAFC TROUBLESHOOTING GUIDE AND CHART WARNING!!! The following instructions are intended for qualified service personnel only. Dangerous line voltage circuits are exposed during these procedures. Disconnect power at fuse before servicing the unit. Trouble shooting the LAFC can be accomplished with minimal tools and by following the directions given below in the two sections of Troubleshooting Guide. -
Page 11: Component Checks
Component Checks 1. Check Fan Motor and Power Source If the fan does not run when the switch is on either in the High or Low position, check the voltage supplied to the motor. 1. If the motor does not turn when the proper voltage is supplied to it, check to see that the shaft turns freely. -
Page 12: Troubleshooting Flowchart
TROUBLE SHOOTING FLOWCHART The following trouble shooting procedure has been designed to speed the serviceman’s work and insure that any malfunction in the electronic air cleaner is quickly and properly repaired. Refer first to flow chart below for an outline of the procedure, and then refer to the Troubleshooting Guide. -
Page 13: Electrical Connections
ELECTRICAL CONNECTIONS ENERGIZED CONDUCTOR 115V POWER WIRE BLUE OR BLACK WIRE FROM POWER SUPPLY IN LAFC NEUTRAL CONDUCTOR WIRE GREEN GREEN GROUND WIRE FROM POWER GROUND SUPPLY IN LAFC BROWN OR WHITE WIRE WIRE FROM POWER SUPPLY IN LAFC... -
Page 14: Electrical Schematic
ELECTRICAL SCHEMATIC MODEL LAFC, 120V, 230V LAFC ELECTRONIC 120V 230V SAFETY INTERLOCK MICRO SWITCH 497576 497567 497612 497612 ON/OFF SWITCH MOTOR/BLOWER 497602 497609 FUSE 497547 497547 INDICATOR LAMP 497570 497592 POWER SUPPLY 10079 10179... -
Page 15: Lakeair Electronic Air Cleaners 7 Year Limited Warranty
#499072 - #10107 - Electronic cell - or MODEL LAFC PARTS SCHEMATIC Carbon After Filter #499081 - HEPA Media Pad #30007 #490128 - Pre-Filter Screen #497602 or #20055 #497609 #10079 & #10179 #497567 #497612 #495169 #495172 PART# DESCRIPTION QTY. USED 10079 Complete Power Supply 120V (Electronic Only) (contains 497606 Transformer &... -
Page 16: User's Responsibility
In addition, LakeAir ity of the user of the LakeAir Electronic or International, Inc. warrants the power supply mod- HEPA Air Cleaner and are not covered by ule and transformer in the LakeAir Electronic Air the warranty.