Bayliner 300 CRUISER Owner's Manual Supplement
  1. Manuals
  2. Brands
  3. Bayliner Manuals
  4. Boat
  5. 300 CRUISER
  6. Owner's manual supplement

Bayliner 300 CRUISER Owner's Manual Supplement

Hide thumbs
Table of Contents

Advertisement

Quick Links

Advertisement

Table of Contents
loading

Related Manuals for Bayliner 300 CRUISER

Summary of Contents for Bayliner 300 CRUISER

  • Page 3: Engine Serial Number

    This document discloses subject matter in which Bayliner has proprietary rights. The information and design disclosed herein were originated by and are the property of Bayliner. Neither receipt nor possession thereof confers or transfers any right to reproduce, copy, alter or disclose the document or any part thereof, any information contained therein, or to construct boats or any item from it, except by written permission from or written agreement with Bayliner.

  • Page 4: Table Of Contents

    CONTENTS Chapter 1: Welcome Aboard! Chapter 3: Propulsion & Related Systems Dimensions & Tank Capacities 1 Engines 34 Dealer Service 1 Engine Cooling Systems (If Equipped) 35 Gas Engine Cooling System Warranty Information 1 Diesel Engine Cooling System Boating Experience 2 Bilge Blower System 36 Qualified Maintenance 2 Fuel System 37...
  • Page 5 Chapter 6: Plumbing Chapter 9: Convertible Seats, Beds, & Tables Bilge Pumps 46 Dinette to Sleeping Berth Conversion 67 Bilge Pump Testing Cockpit Sunlounge Conversion 69 Autofloat Switches Helm Seat 71 Seawater Systems 49 To Slide Helm Seat: Seacocks To Swivel Helm Seat (If Equipped): Seawater Strainers Chapter 10: Lights Freshwater System 50...
  • Page 6 Hazard Boxes & Symbols The hazard boxes and symbols shown below are used throughout this supplement to call attention to potentially dan- gerous situations which could lead to either personal injury or product damage. Read all warnings carefully and fol- low all safety instructions.

  • Page 7: Chapter 1: Welcome Aboard

    • Bayliner offers a Limited Warranty on each new Bayliner purchased through an authorized Bayliner dealer. • A copy of the Limited Warranty was included in your owner’s packet. • If you did not get a copy of the Limited Warranty, please contact your Bayliner dealer or call 360-435-8957 for a copy.

  • Page 8: Boating Experience

    Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement Boating Experience WARNING! CONTROL HAZARD! An experienced operator MUST be in control of your boat at ALL times. Do NOT operate your boat while under the influence of alcohol or drugs.

  • Page 9: Engine & Accessory Guidelines & Literature

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Engine & Accessory Guidelines & Literature NOTICE BEFORE starting or working on your engine(s), read the engine manual. NOTICE BEFORE using the accessories on your boat, read the accessory manuals.

  • Page 10: Special Care For Moored Boats

    Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement Special Care for Moored Boats NOTICE Boats Without Bottom Paint: • To help seal the hull bottom and reduce the chance of gel coat blistering while your boat is moored, apply an epoxy barrier coating.

  • Page 11: Boat Lifting

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Boat Lifting WARNING! PERSONAL INJURY and/or PRODUCT or PROPERTY DAMAGE HAZARD! • Lifting slings can slip on the hull, which could cause serious injury or death. • Reduce the risk of sling slippage by ALWAYS securing the lifting slings together BEFORE lifting.

  • Page 12: Safety Standards

    Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement Safety Standards DANGER! FALLING and ROTATING PROPELLER HAZARD! • NEVER allow anyone to ride on parts of your boat NOT designed for such use. • Sitting on seat-backs, lounging on the forward deck, bow riding, gun- wale riding or occupying the transom platform while underway is especially hazardous and WILL cause personal injury or death.

  • Page 13: Deck Safety

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Deck Safety NEVER OCCUPY TRANSOM PLATFORM WHILE BOAT SHADED AREAS ARE IS UNDERWAY AND/OR SAFE TO OCCUPY NEVER OCCUPY FOREDECK ENGINES ARE RUNNING WHILE UNDERWAY WHILE BOAT IS UNDERWAY WHILE UNDERWAY, ACCESS...

  • Page 14: Where & How Co Can Accumulate

    Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement Where & How CO Can Accumulate Stationary conditions that increase CO accumulations include: A. Using engine, generator, or other fuel burn- B. Mooring too close to another boat that is...

  • Page 15: Co Checklists

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! CO Checklists Trip Checklist Make sure you know where the exhaust outlets are located on your boat. Educate all passengers about the symptoms of CO poisoning and where CO may accumulate.

  • Page 16: More Information

    Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement More Information For more information about preventing carbon monoxide poisoning on recreational boats and other boating safety tips, contact: United States Coast Guard National Marine Manufacturers American Boat & Yacht Council, Inc.

  • Page 17: Warnings & Warning Labels

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Warnings & Warning Labels Warning Labels Carbon monoxide (CO) can cause brain damage or death. Engine and generator exhaust contains odorless and colorless carbon monoxide gas. Carbon monoxide will be around the back of the boat when engines or generators are running.
  • Page 18 Chapter 1: Welcome Aboard! 300 Cruiser • Owner’s Manual Supplement WARNING Carbon monoxide (CO) can cause brain damage or death. Engine and generator exhaust contains odorless and colorless carbon monoxide gas. Signs of carbon monoxide poisoning include nausea, headache, dizziness, drowsiness, and lack of consciousness.

  • Page 19: Sliding Entry Door Warning

    300 Cruiser • Owner’s Manual Supplement Chapter 1: Welcome Aboard! Sliding Entry Door Warning WARNING! PERSONAL INJURY and/or PRODUCT or PROPERTY DAMAGE HAZARD! Before getting underway, make sure the entry door is closed and securely latched. WARNING! PERSONAL INJURY and/or PRODUCT or PROPERTY DAMAGE HAZARD! When the entry door is open, lock the door in the open position with the door stop to prevent the door from closing and causing injury.

  • Page 20: Chapter 2: Locations

    300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Exterior Views Hull Views...

  • Page 21: Deck Views

    300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Deck Views...

  • Page 22: Helm

    Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Helm NOTE: TYPICAL HELM LAYOUT SHOWN. ACTUAL LAYOUT MAY VARY DEPENDING ON ENGINE AND ACCESSORY OPTIONS.

  • Page 23: Component Locations

    300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Component Locations 12-Volt DC Accessory Outlets (3 Total): • Two are located at the helm. • One is located on the for- ward end of the galley.
  • Page 24 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement 12-Volt DC Circuit Breakers: • The 12-volt DC push-to-reset circuit breakers are located at the helm. • The 12-volt DC main circuit breaker switch and standby-load push-to-reset circuit break- ers are located on the battery switch panel.
  • Page 25 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Air Conditioner (If Equipped): Access through the starboard aft wall cutout in the aft-berth. Air Conditioner Seawa- ter Intake Seacock (If Equipped): Located in the engine room. Batteries: Located on the port side of the...
  • Page 26 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Battery Charger: Located on the port side of the engine room, on the forward wall. Battery Switches: Located inside the transom storage hatch. Bilge Pumps (2 Total): • The aft bilge pump is located in the...
  • Page 27 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations • The forward bilge pump is located under the bottom entry step. Blower Switch: Located on the lower switch panel at the helm. CO Monitors (2 Total): • One is located on the ceiling...
  • Page 28 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement • One is located on the aft wall in the aft berth. Depth Finder Transducer: Access through the forward wall hatch in the aft berth. Electronic Fuel Shut-off Valves (Diesel Engines Only): Located on...
  • Page 29 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Engine Hatch Hydraulic Lift Pump & Fluid Reservoir (If Equipped): Located on the for- ward wall of the engine room. Fixed Fire Extinguisher (If Equipped): Located in the starboard forward corner...
  • Page 30 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Freshwater Fill Deck Fitting (marked WATER): Located on the aft deck. Freshwater Pump: Access through the for- ward wall hatch in the aft berth.
  • Page 31 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Freshwater Pump Switch: Located in the galley, just aft of the sink. Freshwater Tank: Access through the cutout underneath the aft berth mattress.
  • Page 32 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Fuel Tank: Access to the tank fittings is in the forward area of the engine room. Fuel Fill Deck Fitting (marked GAS or DIESEL): Located on the starboard aft corner of the deck.
  • Page 33 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Generator (If Equipped): Located in the engine room Generator Control Panel (If Equipped): Located just inside the aft berth. Generator Seawater Intake Seacock (If Equipped): Located in the engine room.
  • Page 34 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Holding Tank: Located on the starboard side of the engine room. Holding Tank Pump-out Deck Fitting (marked WASTE): Located on the starboard aft corner of the deck. Macerator Switches (If Equipped): Located on the side panel next to the helm.
  • Page 35 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Macerator Underwater Discharge Seacock (If Equipped): Located in the engine room. Marine Head (Electric) Seawater Intake Seacock (If Equipped): Located under the middle entry step.
  • Page 36 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Navigation Lights: Red and green lights at the bow. White all-round light on the radar wing. Shore Power Inlet(s): Located inside the transom storage hatch. Shower Drain Sump Box: Located under the middle...
  • Page 37 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Transom Shower: Located just aft of the transom door. Trim Tab Hydraulic Pump & Fluid Reservoir: Located in the engine room, on the aft wall. Trim Tab Switches: Located at the helm.
  • Page 38 Chapter 2: Locations 300 Cruiser • Owner’s Manual Supplement Trim & Tilt Pumps: Located on the port and starboard sides of the engine room. Water Heater: Access through the star- board forward wall cutout in the aft-berth. Windlass Circuit Breaker...
  • Page 39 300 Cruiser • Owner’s Manual Supplement Chapter 2: Locations Windlass Foot Controls (If Equipped): Located in on the forward deck.

  • Page 40: Chapter 3: Propulsion & Related Systems

    300 Cruiser • Owner’s Manual Supplement Chapter 3: Propulsion & Related Systems Engines NOTICE Read the engine manual BEFORE starting or working on your engines. While the topics listed below may be included in this Owner’s Manual Supplement and in the Cruiser & Yacht Owner’s Manual, always refer to the engine manual first for specific information on these important subjects:...

  • Page 41: Engine Cooling Systems (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 3: Propulsion & Related Systems Engine Cooling Systems (If Equipped) CAUTION SYSTEM DAMAGE HAZARD! • Open the engine cooling system’s seacock or ball valve BEFORE starting the engine. • Keep the engine cooling system’s seacock or ball valve Open while the engine is running.

  • Page 42: Bilge Blower System

    Chapter 3: Propulsion & Related Systems 300 Cruiser • Owner’s Manual Supplement Bilge Blower System WARNING! FIRE and EXPLOSION HAZARD! Fuel vapors can explode! BEFORE starting the engines: 1. Check the bilge areas for fuel vapors or leaking fuel. If you see leaking fuel or smell fuel vapors: a.

  • Page 43: Fuel System

    300 Cruiser • Owner’s Manual Supplement Chapter 3: Propulsion & Related Systems Fuel System WARNING! FIRE, EXPLOSION, and OPEN FLAME HAZARD! • It is very important that the fuel system be inspected thoroughly the first time it is filled and at each subsequent filling.

  • Page 44: Fuel Fill & Vent

    Chapter 3: Propulsion & Related Systems 300 Cruiser • Owner’s Manual Supplement Fuel Fill & Vent • Depending on engine type, the fuel fill deck fitting is marked either GAS or DIESEL. • If you have problems filling the fuel tank, see if the fuel fill hose or fuel tank vent hose is kinked or collapsed.

  • Page 45: Anti-Siphon Valves (Gas Engines Only)

    300 Cruiser • Owner’s Manual Supplement Chapter 3: Propulsion & Related Systems Anti-siphon Valves (Gas Engines Only) NOTICE • If an engine running problem is diagnosed as fuel starvation, check the anti-siphon valve. • If the valve is stuck or clogged, ONLY change or replace it while the engine is Off.

  • Page 46: Electronic Fuel Shut-Off Valves (Diesel Engines Only)

    Chapter 3: Propulsion & Related Systems 300 Cruiser • Owner’s Manual Supplement Electronic Fuel Shut-off Valves (Diesel Engines Only) • Your diesel engines are equipped with electronic fuel shut-off valves. • When you start your engines, the electronic fuel shut- off valves open to allow fuel to the engines.

  • Page 47: Engine Hatch Lift System (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 3: Propulsion & Related Systems Engine Hatch Lift System (If Equipped) NOTICE • Remove any items from the top of the engine hatch BEFORE Opening. • Close all entertainment center doors and hatches BEFORE Opening and/or Closing the engine hatch.

  • Page 48: Chapter 4: Controls & Gauges

    300 Cruiser • Owner’s Manual Supplement Chapter 4: Controls & Gauges Steering • Your boat features a power-assisted rack-and-pinion steering system. • For information about the power-assist fluid reservoir, refer to the engine operation and maintenance manual. • Boat steering is not self-centering.

  • Page 49: Gauges

    300 Cruiser • Owner’s Manual Supplement Chapter 4: Controls & Gauges Gauges Cleaning the Gauges CAUTION PRODUCT or PROPERTY DAMAGE HAZARD! • Use only mild soap and water to clean the gauge lenses and bezels. • Use of other cleaners, including common window cleaning solutions, may cause the lenses to crack.

  • Page 50: Chapter 5: Navigation

    300 Cruiser • Owner’s Manual Supplement Chapter 5: Navigation & Communication Equipment Read the manuals for all navigation & communication equipment before using these systems. Compass NOTICE • Compass accuracy can be affected by many factors. • Have a trained technician calibrate your compass.

  • Page 51: Vhf Radio (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 5: Navigation & Communication Equipment VHF Radio (If Equipped) • Your boat may include a VHF (Very High Frequency) radio. • As permitted by the FCC (Federal Communications Commission), the VHF radio can be used to access weather reports, summon assistance, or contact other vessels.

  • Page 52: Chapter 6: Plumbing

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Bilge Pumps NOTICE Discharge of oil, oil waste, or fuel into navigable waters is prohibited by law. Violators are sub- ject to legal action by the local authorities. • Your boat has two bilge pumps for pumping water out of the bilge.

  • Page 53: Bilge Pump Testing

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Bilge Pump Testing • The bilge pumps are vital to the safety of your boat. • Test the bilge pumps often. 1. One at a time, turn On each bilge pump switch at the helm.

  • Page 54: Autofloat Switches

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Autofloat Switches • The autofloat switches turn the bilge pumps On when water rises above a preset level. • Test each autofloat switch often. Autofloat switch testing: AUTOFLOAT SWITCH 1. Lift the autofloat switch test but- TESTING ton to turn On the bilge pump.

  • Page 55: Seawater Systems

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Seawater Systems Seacocks WARNING! FLOODING and SWAMPING HAZARD! • Close the seacock(s) when leaving your boat unattended for any length of time. • If a seacock is left open, a hose failure could flood the bilge, swamp the batteries and the engines, and even sink your boat.

  • Page 56: Freshwater System

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Freshwater System WARNING! • ONLY use safe drinking (potable) water in your boat’s freshwater system. • ONLY use FDA approved "drinking water safe" hoses when filling the freshwater tank. • NEVER use common garden hoses for drinking water.

  • Page 57: Transom Shower (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Transom Shower (If Equipped) • Read the manufacturer’s instructions before using the transom shower for the first time. • The freshwater pump switch must be turned On before using the transom shower.

  • Page 58: Water Heater

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Water Heater WARNING! SCALDING HAZARD! Water heated by the water heater can be hot enough to scald the skin. CAUTION WATER HEATER DAMAGE HAZARD! • Do NOT turn On the water heater circuit breaker on the 110-volt AC master panel until the water heater tank is COMPLETELY filled with water.
  • Page 59 300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Winterizing the Water Heater CAUTION WATER HEATER DAMAGE HAZARD! • NEVER turn On the water heater breaker on the 110-volt AC master panel while the water heater tank is empty. • Even brief water heater operation with a dry tank WILL damage the heating elements.

  • Page 60: Preparing The Water Heater For Use After Boat Storage

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Preparing the Water Heater for Use After Boat Storage CAUTION WATER HEATER DAMAGE HAZARD! • Fill the water heater tank BEFORE turning On the water heater breaker on the 110-volt AC master panel.

  • Page 61: Drain Systems

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Drain Systems Deck Drains • Water on the deck is drained overboard through the deck drains. • Keep the deck drains free of debris. Sink Drain The galley sink is above the waterline and is gravity drained overboard.

  • Page 62: Marine Head & Holding Tank

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Marine Head & Holding Tank NOTICE Check with local authorities about the legal use of marine head systems. Manual Flush Head (If Equipped) WARNING! FLOODING and SWAMPING HAZARD! • Close the seawater intake seacock when leaving your boat unattended for any length of time.

  • Page 63: Electric Flush Head (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Electric Flush Head (If Equipped) WARNING! FLOODING and SWAMPING HAZARD! • Close the seawater intake seacock when leaving your boat unattended for any length of time. • If the seacock is left open, a hose failure could flood the bilge, swamp the batteries and the engines, and even sink your boat.

  • Page 64: Macerator (If Equipped)

    Chapter 6: Plumbing 300 Cruiser • Owner’s Manual Supplement Macerator (If Equipped) To use the macerator to pump waste directly overboard (where laws permit): 1. Open the underwater dis- charge seacock. 2. Press both macerator switches at the same time to run the pump.

  • Page 65: Air Conditioner (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 6: Plumbing Air Conditioner (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! • Dangerous carbon monoxide gas (CO) can be brought into your boat through the air conditioning system. • Read the Carbon Monoxide (CO) section in Chapter 1 of this supplement.

  • Page 66: Chapter 7: Deck Equipment

    300 Cruiser • Owner’s Manual Supplement Chapter 7: Deck Equipment Cleats & Bow/Stern Eyes WARNING! PERSONAL INJURY and/or PRODUCT or PROPERTY DAMAGE HAZARD! NEVER lift your boat using the bow/stern eyes or the cleats. Read the section on towing in the Cruiser & Yacht Owner’s Manual before: •...

  • Page 67: Canvas

    300 Cruiser • Owner’s Manual Supplement Chapter 7: Deck Equipment Canvas Canvas & Vinyl Tops & Enclosures CAUTION PRODUCT or PROPERTY DAMAGE HAZARD! Take down and securely stow ALL canvas & vinyl BEFORE your boat is transported by road. NOTICE BEFORE cleaning and/or stowing your canvas or vinyl, read the sections later in this chapter, Canvas Care and Clear Vinyl Care.

  • Page 68: Aft Bimini Top

    Chapter 7: Deck Equipment 300 Cruiser • Owner’s Manual Supplement Aft Bimini Top 1. Insert the end eyes of the main bow (A) into the hinges on the radar arch and secure them with the pins. 2. Pull the secondary bows (B) for- ward and snap the forward edge canvas snaps to the radar arch.

  • Page 69: Canvas Care

    300 Cruiser • Owner’s Manual Supplement Chapter 7: Deck Equipment Canvas Care (see also ‘Clear Vinyl Care’ on next page) • After each use, especially in saltwater, rinse the canvas with cold freshwater. • Before stowing, let the canvas air-dry completely.

  • Page 70: Clear Vinyl Care

    Chapter 7: Deck Equipment 300 Cruiser • Owner’s Manual Supplement Clear Vinyl Care CAUTION • NEVER store the clear vinyl pieces wet, as this will cause a milky film to develop. • NEVER fold or crease the clear vinyl pieces as cracking will occur.

  • Page 71: Chapter 8: Appliances

    300 Cruiser • Owner’s Manual Supplement Chapter 8: Appliances & Entertainment Systems NOTICE ALWAYS keep an approved ABC-type fire extinguisher in galley area. • The separate instruction sheets or manuals for all appliances and entertainment systems contain detailed informa- tion and important safeguards.

  • Page 72: Alcohol/110-Volt Electric Stove

    Chapter 8: Appliances & Entertainment Systems 300 Cruiser • Owner’s Manual Supplement Alcohol/110-Volt Electric Stove DANGER! CARBON MONOXIDE POISONING HAZARD! • The alcohol stove is a source of dangerous carbon monoxide gas (CO). • BEFORE using the alcohol stove, Open doors and windows to make sure there is enough fresh air for ventilation.

  • Page 73: Chapter 9: Convertible Seats, Beds, & Tables

    300 Cruiser • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Dinette to Sleeping Berth Conversion 1. Remove the table (A) and the table leg (B). 2. Securely store the table leg (B) under the v-berth mattress. 3. Place the shorter table leg (C) into the floor base.
  • Page 74 Chapter 9: Convertible Seats, Beds, & Tables 300 Cruiser • Owner’s Manual Supplement 4. Place the table (A) so that if fits securely on the short table leg, and on the edge lips at the front of the dinette seats..

  • Page 75: Cockpit Sunlounge Conversion

    300 Cruiser • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Cockpit Sunlounge Conversion 1. Remove the table (A) and the table leg (B). 2. Securely store the table leg (B) on the underside of the engine room hatch.
  • Page 76 Chapter 9: Convertible Seats, Beds, & Tables 300 Cruiser • Owner’s Manual Supplement 4. Place the table (A) so that it fits securely on the table supports and the table leg. 5. Place the filler cushion (E) on top of the table.

  • Page 77: Helm Seat

    300 Cruiser • Owner’s Manual Supplement Chapter 9: Convertible Seats, Beds, & Tables Helm Seat NOTICE To rotate the helm seat, it MUST be in the forward or center position. To Slide Helm Seat: 1. Pull the curved lever (A) towards the side panel.

  • Page 78: Chapter 10: Lights

    300 Cruiser • Owner’s Manual Supplement Chapter 10: Lights Care & Maintenance All of the lights installed on your boat are of top quality, but you should be aware that failure may periodically occur for a variety of reasons: 1. There may be a blown fuse - replace the fuse.

  • Page 79: Chapter 11: Electrical System

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System DANGER! EXTREME FIRE, SHOCK and EXPLOSION HAZARD! • NEVER install non-ignition protected switches or other arcing devices in the fuel compartment. • NEVER substitute automotive parts for marine parts. Marine electrical, ignition, and fuel system parts were designed and manufactured to comply with rules and laws that minimize the risks of fire and explosion.

  • Page 80: 12-Volt Dc System

    Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement 12-Volt DC System Batteries • The batteries supply electricity for lights, 12-volt accessories, engine starting and, if equipped, generator starting. • The Electrical section in Chapter 8 of the Cruiser & Yacht Owner’s Manual provides battery care and maintenance instructions.

  • Page 81: 12-Volt Dc Accessory Outlets

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System 12-Volt DC Accessory Outlets CAUTION Do NOT use the 12-volt DC accessory outlet with a cigarette or cigar lighter. High tempera- tures may melt the outlet. • The outlets can be used with any 12-volt device which draws 15-amps or less.

  • Page 82: 110-Volt Ac System

    Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement 110-Volt AC System WARNING! FIRE and ELECTRICAL SYSTEM DAMAGE HAZARD! If equipped with a generator, NEVER bypass the power source lockouts. Using both shore power and generator power at the same time WILL cause major electrical system damage and could start a fire! •...

  • Page 83: Shore Power

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System Shore Power DANGER! FIRE, EXPLOSION and SHOCK HAZARD! • Use ONLY compatible shore power connectors and NEVER alter the connectors. • Turn Off ALL breakers and switches on the 110-volt AC master panel BEFORE plugging in or unplugging the shore power cord.

  • Page 84: Connecting To Shore Power

    Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement • Single shore power 110-volt/60-hertz AC systems feature one 110-volt/30-amp shore power inlet. • If your boat has an air conditioning system, a second (dual) 110-volt/30-amp inlet has been installed.

  • Page 85: Generator (If Equipped)

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System Generator (If Equipped) DANGER! CARBON MONOXIDE POISONING HAZARD! • Generators are a source of dangerous carbon monoxide gas (CO). Check the generator exhaust system for leaks BEFORE each use. • Read the Carbon Monoxide (CO) section in Chapter 1 of this supplement.
  • Page 86 Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement • When your boat is not connected to shore power, the generator can supply 110-volt/60-hertz power. • Before using the generator, read the generator operation manual for pre-start checks and break-in procedures.

  • Page 87: Electrical Routings

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System Electrical Routings 12-Volt DC Hull Harness...

  • Page 88: 12-Volt Dc Deck Harnesses

    Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement 12-Volt DC Deck Harnesses...

  • Page 89: 12-Volt Dc Radar Arch Harness

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System 12-Volt DC Radar Arch Harness...

  • Page 90: Battery Cable Routings

    Chapter 11: Electrical System 300 Cruiser • Owner’s Manual Supplement Battery Cable Routings NOTES: NEGATIVE POSITIVE BATTERY CABLES ARE RED POSITIVE NEGATIVE BATTERY CABLES ARE YELLOW...

  • Page 91: 110-Volt Ac Hull Harnesses

    300 Cruiser • Owner’s Manual Supplement Chapter 11: Electrical System 110-Volt AC Hull Harnesses...

  • Page 92: Important Records

    300 Cruiser • Owner’s Manual Supplement Important Records Selling Dealer Key Numbers Name Of Dealership Ignition Other Address Electronics Phone/FAX/E-mail Manufacturer Model Name/Number Sales Manager Serial Number Service Manager Manufacturer Model Name/Number Engine Serial Number Manufacturer Model Name/Number Engine Serial Number...

  • Page 93: Float Plan

    300 Cruiser • Owner’s Manual Supplement Float Plan Before going boating, fill out a copy of this float plan (or similar) and leave it with a reliable person whom you can depend on to contact the Coast Guard or other rescue organization, if you do not return as scheduled.
  • Page 94 Float Plan 300 Cruiser • Owner’s Manual Supplement Survival Equipment Trip Expectations Marine Radio (Yes/No) Type Frequencies Departing From Number of PFDs Flares (Yes/No) Mirror (Yes/No) Departure Date Departure Time Smoke Signals (Yes/No) Flashlight (Yes/No) Food (Yes/No) Stopover 1 Water (Yes/No)
  • Page 96 Part Number 1896392 Bayliner • P.O. Box 9029 • Everett, WA 98206 • 360-435-5571...

Table of Contents