Fluids Information; Engine Service - Seat Leon Cup Racer Technical Manual

TECHNICAL MANUAL LEON CUP RACER
5.4

Fluids information

Fluids From
Engine
Gear box VW-Audi
Electronic Slip
VW
Differential
Drive shaft VW-Audi
Coolant
VW
Brake fluid
PANTA
Fuel
(Eurocup SEAT)
Windscreen
Free
cleaner
Notes:

SEAT Leon Cup Racer: Use only the fuel distributed on the race track.

It is forbidden any product addition on the fuel.

Fuel: standard fuel 98 Ron from petrol stations to 102 Ron.

Is recommended not to mixt fuels, could contaminate one from the other.

Gearbox and Slip differential are supplied with the right level. It is not necessary any level control
if there are not leakages.
5.5

Engine service

Control routine before start to run:

Check the oil level: With the oil temperature up to 70°C, stop the engine and wait 2 minutes, then
you can check the oil dipstick. The oil level must be at the top of the marked zone on the dipstick.

Check the water level before start.

With the engine running, check there is not any oil, water or fuel leakage.

Check the fan functionality. Operating range 92°C to 87°C.
Maintenance routine:

Change the engine oil and oil filter at the indicated mileage.

Engine spare parts must be from VW group or SEAT Sport original parts, detailed on the Leon
Cup Racer parts catalogue.

Use always fluids detailed on the Leon Cup Racer parts catalogue.

Clean and check the air filter in each event. At the urban circuits it is recommended to clean or
replace more frequently. It is also recommended to have two or three air filters and replace during
the weekend. Changing it is strongly recommended in case of rain.

Check that the alternator belt is clean and that there are not small stones inside the Poly-V.

Clean the radiator and intercooler panel often.

If any doubt, contact to the SEAT Sport service.

Check the SEAT Sport seals are in good conditions.
Parts subject to frequent service:
Engine
Oil drain plug
Oil filter plastic cover
Oil filter
Spark plug
References
CASTROL EDGE 5W-30
VN0000053000
_G052182A2
_G060175A2
VN0000040401
VN0000060400
_G013A8JM1
CASTROL SRF
VN0000062400
NS 102 Ron
Torque Remarks
By hand Change the plastic cap
50 Nm
Moisten the "O" ring
<<
2,8 Nm Use original VW parts
Quantity
Substitution with filter change
5,7 l
Substitution 5,2 l
Mechatronic 3 – 4 l
Unit 0,7 l
Substitution 0,5 l
100 gr
5 l
37 de 44