Wagan ProLine 2007-2 User Manual
Hide thumbs
Also See for ProLine 2007-2:
- User manual (23 pages) ,
- User manual (20 pages) ,
- User manual (9 pages)
Related Manuals for Wagan ProLine 2007-2
Summary of Contents for Wagan ProLine 2007-2
- Page 1 ProLine ™ Item No. #2007-2 (12V) #2007-4 (24V) #2007-8 (48V) 3,000 Watt AC Inverter ProLine 3,000 Watt ™ DC to AC Power Inverter User’s Manual...
-
Page 2: About The Inverter
ProLine 3,000W Power Inverter by Wagan Tech ™ ® Thank you for purchasing the ProLine 3,000W Power Inverter by Wagan Tech . With ™ ® minimal care and proper treatment it will provide years of reliable service. Carefully read, understand and comply with all instructions before use. Keep this manual for future reference. -
Page 3: Front Panel
The inverter is equipped with a digital display to monitor input DC volts, DC amps, AC output watts and error codes. A Display Selector button allows the user to advance the display ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation. - Page 4 ProLine 3,000W Power Inverter by Wagan Tech ™ ® readout to the next readout. The lit/unlit status of two green LEDs show which function is being shown on the Digital Display The display and button are used to help diagnose problems if they occur.
- Page 5 AC voltmeters are calibrated to read “average” voltage and assume that the AC waveform will be a pure sine wave. These meters will not correctly read MSW voltage, and will display ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation.
-
Page 6: Rear Panel
ProLine 3,000W Power Inverter by Wagan Tech ™ ® about 20 to 30 volts too low. Any multi-meter identified as “TRUE RMS” will accurately read MSW correctly. Modified Sine Wave (MSW) Pure Sine Wave REAR PANEL High-Speed Cooling Fans Negative (−) DC... -
Page 7: Planning The Inverter System
(The following calculations are specific to 12V systems. For 24V or 48V systems, a different calculation is required but the same principles should apply) 1. List the maximum continuous wattage that the inverter has to supply. ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation. -
Page 8: Derating The Battery Bank
ProLine 3,000W Power Inverter by Wagan Tech ™ ® 2. Estimate the number of hours the appliances will be in use between battery recharges. This will vary depending on appliances. For example, a typical home use coffeemaker draws 500 watts during its brew time of 5 minutes. It maintains the temperature of the pot, requiring 100 watts. - Page 9 These batteries are “flooded” type; they freely vent hydrogen and oxygen while under charging and heavy discharge. They must be vented to outside air to prevent accumulation of explosive gases. ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation.
- Page 10 ProLine 3,000W Power Inverter by Wagan Tech ™ ® BATTERY BANK DIAGRAM The diagrams below show inverter connections to a battery bank with recommended fuse protection. #2007-2 12V DC Input Fuse INVERTER 220Ah 220Ah 220Ah – – – – Safety Ground...
-
Page 11: Fusing Requirements
CAUTION: Reverse polarity connection will blow the fuses in the inverter and can permanently damage the inverter. Damage caused by reversed polarity will void the warranty. ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation. - Page 12 ProLine 3,000W Power Inverter by Wagan Tech ™ ® Procedure 1. Connect the Negative (−) cable ring terminal to the Negative (−) Battery Terminal. 2. Install the ANL fuse in the Fuse holder Positive (+) cable. 3. Make sure the ON/OFF switch located on the front panel of the inverter is in the OFF position.
-
Page 13: Charging The Battery Bank
Follow all recommendations for use that are contained in the battery charger manual. ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation. -
Page 14: Aboard A Vessel Or Vehicle
ProLine 3,000W Power Inverter by Wagan Tech ™ ® WARNING THERE IS DANGER OF AN EXPLOSION. DO NOT CONNECT OR DISCONNECT CHARGER CABLES DIRECTLY AFTER BATTERY DISCHARGE OR RECHARGE— MAKE SURE THAT THE BATTERY BANK AREA IS WELL VENTED BEFORE ATTACHING OR REMOVING CABLES. -
Page 15: Specifications
Input #2007-2 — 12V DC Input #2007-4 — 24V DC Input #2007-8 — 48V DC Input Output 120V AC ± 10% Frequency 60 Hz ©2013 Wagan Corporation. All Rights Reserved. Wagan Tech and wagan.com are trademarks used by Wagan Corporation. -
Page 16: Disposal Of Inverter
ProLine 3,000W Power Inverter by Wagan Tech ™ ® Name Description Output Waveform Modified Sine Waveform TrueRated Power 3,000 watts continuous ™ Surge Power 6,000 watts Efficiency Approximately 90% No load Switch ON <3.0A DC Switch OFF <0.2mA DC Low Battery Alarm #2007-2 —... - Page 17 Product is warranted to the original purchaser for a period of one (1) year from the original purchase date, to be free of defects in material and workmanship. WAGAN Corporation disclaims any liability for consequential damages. In no event will WAGAN Corporation be responsible for any amount of damages beyond the amount paid for the product at retail.
- Page 20 31088 San Clemente Street Hayward, CA 94544, U.S.A. Tel: + 1.510.471.9221 U.S. & Canada Toll Free: 1.800.231.5806 customerservice@wagan.com www.wagan.com ©2013 Wagan Corporation. All Rights Reserved Wagan Tech and wagan.com are trademarks used by Wagan Corporation REV20130805-E...