Page 1
Less than 44.6 µW* Laser output power Wired remote (RM-X87) * This output is the value measured at a distance of /Wireless remote (RM-X89) (CDX-530RF/535RF) 200 mm from the objective lens surface on the Dimensions Wired remote: Optical Pick-up Block.
OPERATION. REPLACE THESE COMPONENTS WITH DE FONCTIONNEMENT. NE REMPLACER CES COM- SONY PARTS WHOSE PART NUMBERS APPEAR AS POSANTS QUE PAR DES PIÈCES SONY DONT LES SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- NUMÉROS SONT DONNÉS DANS CE MANUEL OU LISHED BY SONY.
http://www.xiaoyu163.com Ver 1.1 2000. 08 SECTION 1 SERVICING NOTES 3 7 63 1515 0 Flexible Circuit Board Repairing NOTES ON HANDLING THE OPTICAL PICK- • Keep the temperature of the soldering iron around 270 ˚C dur- UP BLOCK OR BASE UNIT ing repairing.
http://www.xiaoyu163.com SECTION 2 This section is extracted from instruction manual. GENERAL 3 7 63 1515 0 Location and function of controls (CDX-434RF) Nomenclature (CDX-434RF) Wired remote (RM-X88)/Télécommande à fil (RM-X88) 1 DISC (disc select) buttons 7 MHz (frequency) indication 1 Touches DISC (sélection de disques) 7 Indication MHz (fréquence) 2 AMS (Automatic Music Sensor/manual 8 u (play/pause) button...
Page 5
Installing the battery Installation de la pile (CDX-530RF/535RF) (CDX-530RF/535RF) Replace the battery with a Sony CR2025 or Remplacez la pile par une pile au lithium CR2025 Duracell DL-2025 lithium battery. Use of another Sony ou DL-2025 Duracell. L’utilisation d’une battery may present a risk of fire or explosion.
Page 6
Face imprimée vers le haut Avec le côté portant la flèche orienté • To listen to an 8 cm (3 in.) CD, use the optional Sony CD adaptor vers le haut CSA-8. Be sure to always use the specified adaptor, as failing to do so may cause a malfunction of the unit.
Page 7
http://www.xiaoyu163.com 3 7 63 1515 0 Operation (CDX-434RF) Fonctionnement (CDX-434RF) Precautions Précautions •This unit cannot be used with a car audio without an FM tuner. •Cet appareil ne peut être utilisé avec un autoradio sans syntoniseur FM. •If your car was parked in direct sunlight resulting in a considerable rise in temperature inside the car, •Si votre voiture est parquée en plein soleil, provoquant ainsi une augmentation considérable de la allow the unit to cool off before operating it.
Page 8
3 7 63 1515 0 Operation (CDX-530RF/535RF) Fonctionnement (CDX-530RF/535RF) Precautions Précautions • This unit cannot be used with a car audio without FM tuner. • Cet appareil ne peut être utilisé avec un autoradio sans syntoniseur FM. • If your car was parked in direct sunlight resulting in a considerable rise in temperature inside the car, allow the unit to •...
Page 9
http://www.xiaoyu163.com 3 7 63 1515 0 Appuyez plusieurs fois sur pour Press repeatedly to select the Press (SHUF/REP) for two seconds. Appuyez sur (SHUF/REP) pendant deux secondes. sélectionner la fréquence. frequency. Press (SHUF/REP) momentarily. Appuyez brièvement sur (SHUF/REP). Chaque fois que vous appuyez sur Each time you press , the frequency change as follows:...
http://www.xiaoyu163.com 3 7 63 1515 0 Installation Installation How to install the CD changer Installation du changeur de CD •When you install the CD changer, be careful not to damage wiring or equipment on the other side of the •Quand vous installez le changeur de CD, veillez à ne pas endommager les câbles ou les instruments qui mounting surface.
Installing the wireless remote (CDX-530RF/535RF) Installation de la télécommande sans fil (CDX-530RF/535RF) Use the supplied velcro tapes 5, and mount the wireless remote in a suitable location where it will not Utilisez les bandes velcro fournies 5 pour installer la télécommande sans fil dans un endroit qui ne risque interfere with your driving.
Page 12
3 7 63 1515 0 Wired remote (RM-X87)/Télécommande à fil (RM-X87) Wired remote (RM-X88)/Télécommande à fil (RM-X88) (CDX-530RF/535RF) (CDX-434RF) DISC +/– DISC +/– SHUF/REP Note Remarque The supplied wireless remote (RM-X89) can be La télécommande sans fil fournie (RM-X89) se SHUF/REP operated almost like the wired remote (RM-X87).
http://www.xiaoyu163.com SECTION 3 DISASSEMBLY 3 7 63 1515 0 Note: Follow the disassembly procedure in the numerical order given. COVER (UPPER T), FRONT PANEL ASS’Y 1 screw (PTT2.6 × 6) 1 screw (PTT2.6 × 6) 3 lever (FLT) 2 cover (upper T) 1 screw (PTT2.6 ×...
Page 14
http://www.xiaoyu163.com 3 7 63 1515 0 FM BOARD 4 cover (FM) 2 screw (PCB FM) 1 screw (BVTT2.6 × 6) 5 FM board 3 cover (FM connector.T) L 13942296513 MAIN BOARD, SLIDE VARIABLE RESISTOR (ELEVATOR HEIGHT SENSOR ) (RV202) 1 main flexible board (CNJ101) 5 two screws (FP) 6 screw...
Page 15
http://www.xiaoyu163.com 3 7 63 1515 0 ELJ MOTOR ASS’Y (ELEVATOR) (M104) 1 screw (PTT2 × 4) 2 bracket (EVM.S) 3 ELJ motor ass’y (elevator) (M104) L 13942296513 ESCUTCHEON (T) 3 two claws 2 Remove the claw in the direction of the arrow A. 4 Remove the ditch in the direction of the arrow B.
Page 16
http://www.xiaoyu163.com 3 7 63 1515 0 CHASSIS (U.S) SUB ASS’Y 3 Remove the edge in the direction 1 three screws of the arrow A. (PTT2 × 4) 1 two screws (PTT2 × 4) 4 Remove the chassis (U.S) sub ass’y in the direction of the arrow B.
Page 17
http://www.xiaoyu163.com 3 7 63 1515 0 RF BOARD 3 two screws (PS2 × 4) 4 RF board 3 two screws (PS2 × 4) 2 Remove four solders of the LSW board leads and spindle motor leads (M102). 2 Remove two solders L 13942296513 of the sled motor leads 1 OP flexible board (CN102).
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 LSW BOARD, SPINDLE MOTOR (S) SUB ASS’Y (M102) 8 two precision screws (P1.7 × 2.2) 3 spring (chucking) 6 retainer (disc) 1 precision screw (P2 × 2.5) 4 precision screw (P2 × 2.2) 5 bracket (CP) 2 LSW board 9 Remove the spindle motor (S) sub ass’y (M102) in the direction of the arrow.
http://www.xiaoyu163.com SECTION 4 MECHANISM DECK ASSEMBLY 3 7 63 1515 0 Note: Follow the assembly procedure in the numerical order given. OPTICAL PICK-UP COMPLETE ASS’Y 1 Move the lever (LOCK 3A) in the direction of the arrow A, and return it a little in the direction of the arrow B from the position where the chuck plate is moved chuck plate down to the lower limit.
Page 20
http://www.xiaoyu163.com 3 7 63 1515 0 OPERATION CHECK 1 Confirm that the slider moves in the direction of the arrow C to move down the chuck plate if the gear (LOAD 1) is rotated in the direction of the arrow A or the chuck plate moves up and the slider moves in the direc- tion of the arrow D if the gear is rotated in the direction of the arrow B .
A and B. 6. Further, place the set horizontally and make same adjustment wired remote commander (RM-X87: CDX-530RF/535R) as mentioned above. (RM-X88: CDX-434R) 7. After adjustment at addresses 5 to 6 is finished, check all op-...
http://www.xiaoyu163.com CDX-434RF/530RF/535RF 7-5. SCHEMATIC DIAGRAM – RF Section – • See page 36 for Waveforms. • See page 37 for IC Block Diagrams. 3 7 6 3 1 5 1 5 0 (Page 30) 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 The components identified by mark 0 or dotted...
http://www.xiaoyu163.com 3 7 6 3 1 5 1 5 0 7-12. IC PIN FUNCTION DESCRIPTION • MAIN BOARD IC201 CXP740056-004R (SYSTEM CONTROLLER) Pin No. Pin Name Function Pin No. Pin Name Function 1 to 3 — Not used (open) MAGSW Magazine in/out detect switch input Not used (open) AMUTE Audio line muting on/off control signal output terminal “H”: muting on...
http://www.xiaoyu163.com SECTION 8 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • Items marked “*” are not stocked since they • -XX and -X mean standardized parts, so they The components identified by mark 0 or dotted line with mark may have some difference from the original are seldom required for routine service.
Page 45
http://www.xiaoyu163.com 3 7 63 1515 0 (5) MECHANISM DECK SECTION-4 (MG-251A-137) not supplied L 13942296513 M102 not supplied M101 The components identified by Les composants identifiés par une mark 0 or dotted line with marque 0 sont critiques pour la mark 0 are critical for safety.
http://www.xiaoyu163.com SECTION 9 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • Items marked “*” are not stocked since they The components identified by mark 0 or dotted line with mark parts list may be different from the parts speci- are seldom required for routine service.
Page 52
CDX-434RF/530RF/535RF 3 7 63 1515 0 L 13942296513 u163 Sony Corporation 9-870-049-11 2000A0574-1 Mobile Electronics Division Company Printed in Japan C 2000. 1 Published by General Engineering Dept. http://www.xiaoyu163.com...