Advertisement

Kozy-World
OWNER ' S OPERATION AND INSTALLATION MANUAL
FMK4023
FMK4024
FMK4025
FMK4026

Table of Contents

Safety Information Warnings......................................2
Product Identification...................................................3
Air for Combustion and Ventilation...........................4
Installation.....................................................................6
Operating heater.........................................................10
Trouble Shooting.........................................................11
Specifications..............................................................13
Replacement Parts.....................................................14
Parts List.......................................................................15
Installing the Heater....................................................19
W ARNING: If the information in this
manual is not followed exactly,a f i re or
ex pl o si on m a y re sul t causing property
damage,personalinjury, or loss of life.
W ARNING: T his is an unvented gas-fired
fireplace.It uses air (oxygen) f r o m t h e r o o m
i n wh i c h i t i s installed. Prov isions for
adequate combustion and ventilation air must
be pr ov i d ed . R ef e r t o A i r F o r Combus-
tion and Ventilation section on page 4 of this
World-Marketing of American,Inc.
P.O.Box 192,Rt.22 West
MillCreek,PA 17060
KOZY-WORLD PHONE NUMBER:(814)643-1775
http://www.worldmkting.com
R
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
l Do not try to light any appliance.
l Do not touch any electrical switch; do
not use any phone in your building.
l Immediately call your gas supplier from
a neighbor's phone. Follow the gas supplier's
instructions.
l
If
you
call the fire department. Installation and ser
vice must be performed by a q u al i fi ed
installer,service agency,or local gas supplier.
WARNING: Improper installation,
adjustment, alteration, service or mainte-
nance can cause injury or property damage.
Refer to this manual for correct installation
and operational procedures. For assistance
or additional information, consult a qualified
installer, service agency, or local gas supplier.
This appliance may be installed in an after-
market*, permanently located, manufactured
(mobile) home, where not prohibited by
local codes.
This appliance is only for use with the type of
gas indicated on
appliance is not convertible for use with other
gases.
WATER VAPOR: A BY-PRODUCT OF NOVENTED ROOM
HEATERS
Water vapor is a by-product of gas combustion.An unvented
room heater produces approxinately one(1) ounce (30ml)
of water for every 1,000 BTU's(3KW's) of gas input per
hour. Refer to page 3.
Consumer: Please retain these instructions for future
use.
Installer: Please leave these instructions with the
consumer.
*Aftermarket: Completion of sale, not for purpose of resale,
from the manufacturer.
FULL SIZE VENT-FREE
FIREPLACE
cannot reach your gas supplier,
the rating plate. This

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the FMK4023 and is the answer not in the manual?

Questions and answers

Summary of Contents for Kozy-World FMK4023

  • Page 1: Table Of Contents

    Consumer: Please retain these instructions for future use. World-Marketing of American,Inc. Installer: Please leave these instructions with the P.O.Box 192,Rt.22 West consumer. MillCreek,PA 17060 KOZY-WORLD PHONE NUMBER:(814)643-1775 *Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer. http://www.worldmkting.com...
  • Page 2: Safety Information Warnings

    SAFETY INFORMATION WARNINGS Do no t use t his f irep lac e as a I M P O R T A N T: R e a d t h i s WARNING: Do not use acces- wood-burning fireplace. Use only owner’s manual carefully and sories not approved for use with the logs provided with the fireplace.
  • Page 3: Product Identification

    LOCAL CODES UNPACKING SAFETY INFORMATION 1. Remove top inner pack. lnstall and use fireplace with care. Continued 2. Tilt carton so that fireplace is upright. Fol low all local codes. In the 3. Remove protective side packaging. absence of local codes, use the 15.
  • Page 4: Air For Combustion And Ventilation

    AIR FOR COMBUSTION AND VENTILATION Unusually Tight Construction Confined and Unconfined Space WARNING: This fireplace The air that leaks around doors shall not be installed in a confined The National Fuel Gas Code, ANS and windows may provide enough space or unusually tight construc- Z223.1 defines a confined space as f resh air for combustion and tion unless provisions are provided...
  • Page 5 3. Add the Btu/Hr of all fuel burning appliances in the space. Vent-free heater Btu/Hr Example: Gas water heater* Btu/Hr Gas water heater 30,000 Btu/Hr Gas furnace Btu/Hr Vent-free heater 26,000 Btu/Hr Vented gas heater Btu/Hr Total 56,000 Btu/Hr Gas heater logs Btu/Hr Other gas appliances* + Btu/Hr...
  • Page 6: Installation

    INSTALLATION fireplace NOTICE: This intended for use as supplemental fireplace fireplace . Use this along with your primary heating system. fireplace Do not install this as your primary heat source. If you have a central heating system, you may run the system's circulating blower fireplace while using the .
  • Page 7 INSTALLATION Continued CONNECTING TO GAS SUPPLY The installer must supply an external IMPORTANT: Install equipment shutoff regulator. The external regulator will re- valve in an accessible location. The WARNING: A qualified service per- duce incoming gas pressure. You must equipment shutoff valve is for turning on son must connect fireplace to gas reduce incoming gas pressure to be- or shutting off the gas to the appliance.
  • Page 8 INSTALLATION Continued CHECKING GAS CONNECTIONS WARNING: Never use an open WARNING: Test all gas piping CAUTION: Make sure external and connections for leaks after install- flame to check for a leak. Apply a regulator has been installed be- mixture of liquid soap and water to ing or servicing.
  • Page 9: Installing Logs

    INSTALLATION Continued INSTALLING LOGS C. Use only your hand to push in or turn Note: If pilot does not stay lit, the gas control knob. Never use tools. c o n t a c t a q u a l i f i e d s e r vi c e WARNING: Failure to position If the knob will not push in or turn by p e r s o n o r g a s s u p p l i e r f o r...
  • Page 10: Operating Heater

    OPERATING FIREPLACE Continued THERMOSTAT CONTROL INSPECTING BURNERS CLEANING AND MAINTENANCE OPERATION C h e c k p i l o t f l a m e p a t t e r n a n d WARNING: Turn off fireplace and burner flame patterns often.
  • Page 11: Trouble Shooting

    CLEAN AND MAINTENANCE Continued MAIN BURNER CABINET C lean t h e p ilo t assem b ly also . A Periodically inspect all burner flame y e l l o w t i p o n t h e p i l o t f l a m e Air Passageways holes with the fireplace running.
  • Page 12: Troubleshooting

    TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY 1. Control knob not fully pressed in ODS/pilot lights but flame goes out Press in control knob fully when control knob is released 2. Control knob not pressed in long enough Af t er OD S /p ilo t lig h t s, k eep...
  • Page 13: Specifications

    48”X42 5/16” X 14 1/2” Carton 46 “X 46 1/2” X 17 1/2” 46 “X 46 1/2” X 17 1/2” Weight, Lb Stove 145(143**) 145(143**) Shipping 165(162**) 165(162**) * For purposes of input adjustment. ** The weight of FMK4023 FMK4024...
  • Page 14: Replacement Parts

    C o n t a c t a u t h o ri zed d ea ler s o f t h is pro duct. If th ey can't supply original replacement part(s) call KOZY-W ORLD’s Technical Service Department at (814)643- 1775 for referral information. When calling KOZY-WORLD or your dealer,have ready Your name Your address Model...
  • Page 15: Parts List

    PARTS LIST This list contains replaceable parts used in your fireplace. W hen ordering parts, follow the instructions listed under Re- placement Parts on page 14 of this manual. FMK4023 FMK4025 FMK4024 FMK4026...
  • Page 16 Parts list FMK4023 FMK4025 FMK4024 FMK4026...
  • Page 17 ILLUSTRATED PARTS BREAKDOWN FMK4025 FMK4026...
  • Page 18 ILLUSTRATED PARTS BREAKDOWN FMK4023 FMK4024...
  • Page 19: Installing The Heater

    1. Install base and flex tube. l Take out the base from the package l Line the holes on the upper surface of the left and right base with the corresponding holes on the lower surface of the heater,then fasten with self-tapping screws(Figure 4-1). l Place the mid base between the left and right base on proper position(Figure 4-2).
  • Page 20: Manual

    BLOWER ACCESSORY MODEL 20-6028 downleads respectively Accessory 20-6028 WARNING: ELECTRICAL remaining two black and white Tools required: Philips screwdriver GROUNDING INSTRUCTIONS this wires together same appliance is equipped with a means (see Figure 12-F). (Note: three-prong grounding plug for three wires must your protection against shock...
  • Page 21: Manual

    20-6028...

This manual is also suitable for:

Fmk4024Fmk4025Fmk4026

Table of Contents