Heatilator CD4236-MOD Owner's Manual
  1. Manuals
  2. Brands
  3. Heatilator Manuals
  4. Indoor Fireplace
  5. CD4236-MOD
  6. Owner's manual
Heatilator CD4236-MOD Owner's Manual

Heatilator CD4236-MOD Owner's Manual

Hide thumbs Also See for CD4236-MOD:
Table of Contents

Advertisement

Quick Links

See also: Installation Manual
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your dealer with questions regarding installation, operation or service.
NOTICE: DO NOT discard this manual!
Model(s):
This appliance may be installed as an OEM
installation in manufactured home (USA
only) or mobile home and must be installed
in accordance with the manufacturer's
instructions and the Manufactured Home
Construction and Safety Standard, Title 24
CFR, Part 3280 in the United States, or the
Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH Series, in Canada.
This appliance is only for use with the type(s)
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certifi ed kit is used.
In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas fi tter.
See appliance installation manual for additional
Commonwealth of Massachusetts requirements.
Owner's Manual

Care and Operation

Heatilator • CD4236-MOD, CD4842-MOD Owner's Manual • 2241-902 Rev. C • 11/15
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
• DO NOT store or use gasoline or other fl am-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas sup-
plier's instructions.
- If you cannot reach your gas supplier, call
the fi re department.
• Installation and service must be performed
by a qualifi ed installer, service agency, or the
gas supplier.
DANGER
DO NOT TOUCH GLASS
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of
burns from the hot viewing glass is provided
with this appliance and shall be installed for
the protection of children and other at-risk
individuals.
HOT GLASS WILL
CAUSE BURNS.
UNTIL COOLED.
TO TOUCH GLASS.
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the CD4236-MOD and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Heatilator CD4236-MOD

Summary of Contents for Heatilator CD4236-MOD

  • Page 1: Care And Operation

    In the Commonwealth of Massachusetts installation must be performed by a licensed plumber or gas fi tter. See appliance installation manual for additional Commonwealth of Massachusetts requirements. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 2: Welcome

    00,000 00,000 00,000 00,000 MIN. MIN. INPUT INPUT BTUH: BTUH: 00,000 00,000 00,000 00,000 Serial Serial ORIFICE ORIFICE SIZE: SIZE: #XXXXX #XXXXX #XXXXX #XXXXX XXXXXXXX XXXXXXXX (Serie): (Serie): Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 3: Table Of Contents

    C. Contact Information ......27  = Contains updated information. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 4: Limited Lifetime Warranty

    3 years Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645H 10/15 Page 1 of 2 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 5 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645H 10/15 Page 2 of 2 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 6: Product Specifi C Information

    Some local building codes require the use of tempered glass with permanent marking in such locations. Glass meeting this requirement is available from the factory. Please contact your dealer or distributor to order. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 7: Important Safety And Operating Information

    • Install a switch lock or a wall/remote control with child technician to service the appliance protection lockout feature. • Keep remote controls out of reach of children. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 8: General Operating Parts

    30 in. °F 24 in. 18 in. °F 12 in. 6 in. MEASUREMENTS FROM TOP EDGE OF THE OPENING APPLIANCE FRONT Figure 3.3. Maximum Wall Surface Temperatures Above Appliance Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 9 Sugges ons on how to further reduce TV temperatures: Increase “A” dimension. Increase “C” dimension, however, increasing “B” dimension beyond maximum recommended typically results in higher temperatures. Figure 3.4. Good Faith TV Guidelines Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 10: Before Lighting Appliance

    • Ensure that the glass is sealed and in the proper position and that the integral barrier is in place. WARNING! Risk of Fire or Asphyxiation! DO NOT op- erate fi replace with fi xed glass assembly removed. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 11: Lighting Instructions (Ipi)

    Keep burner and control compartment clean. See installation and operating instruc- Propane Installation code, CSA B149.1. tions accompanying appliance. For additional information on operating your 593-913i Hearth & Home Technologies fi replace, please refer to www.fi replaces.com. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 12: Appliance Break-In

    ON/OFF SWITCH Installation Manual. 3. Turn the appliance on according to the instructions below for the appropriate type of control: CONTROL CAVITY 3.5 ON/OFF Switch/ Control Cavity Location Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 13: Detailed Component Operating Instructions

    MODULE SELECTOR SWITCH FLAME HI/LOW STATUS NG/LP GAS-TYPE SWITCH INDICATOR LED SELECTOR SWITCH Figure 3.6 Control Module Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 14 If desired, a fan kit may be added. Contact your dealer to order the correct fan kit. Heat management for the fan is discussed in Section 3.G. Detailed instructions are in- cluded with the fan kit. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 15: Maintenance And Service

    Figure 4.1 Fixed Glass Assembly CAUTION! Risk of Burns! The fi replace shall be turned off and cooled before servicing. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 16: Maintenance Tasks - Qualifi Ed Service Technician

    Use caution when cleaning these areas. Screw tips that have penetrated the sheet metal are sharp and should be avoided. • Remove all foreign objects. • Verify unobstructed air circulation. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 17: Glass Refractory, Base Pan, Burner And Valve Assembly Removal

    • Verify that there is not a short in fl ame sense circuit by checking continuity between pilot hood and fl ame sensing rod. Replace pilot as necessary Figure 4.4 Glass Panel Removal Figure 4.2 IPI Pilot Flame Patterns Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 18: Burner Identifi Cation

    CD4236-MOD (NG) Figure 4.5 Base Pan Removal CD4236-MOD (LP) Figure 4.8 Valve Assembly Removal CD4842-MOD (NG) CD4842-MOD (LP) Figure 4.9 Valve Assembly Removal Figure 4.6 Burner Assembly Removal Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 19: Frequently Asked Questions And Troubleshooting

    It is normal for the glass rock media to change color slightly over the lifetime of the Glass rock media color change appliance. Contact your dealer for additional information regarding operation and troubleshooting. Visit www.heatilator.com to locate a dealer. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 20: Troubleshooting - Intellifire™ Plus Ignition System

    D. Pilot valve solenoid. Verify that 1.5 to 1.8 VDC is supplied to pilot solenoid from module. If below 1.5 volts, replace module. If 1.5 volts or greater, replace valve. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 21 ON position. If there is no spark at “I” terminal module must be replaced. If there is a spark at “I” terminal, module is fi ne. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 22: Reference Materials

    Contact your dealer or Hearth & Home Technologies if the barrier is not present or help is needed to properly install one. For more information refer to the instructions supplied with your decorative door or front. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 23: Service Parts

    Pilot Hood 2241-117 Pilot Shield Stainless 2241-116 2241-007 Burner Assembly 2241-008 Surround Assembly 2166-019 Glass Assembly GLA-6000G Junction box 4021-013 Additional service part numbers on following page. 11/15 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 24 Pilot Hood 2241-117 Pilot Shield Stainless 2241-116 2242-007 Burner Assembly 2242-008 Surround Assembly 2170-019 Glass Assembly GLA-950TR Junction box 4021-013 Additional service part numbers on following page. 11/15 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...
  • Page 25 Ori ce, NG (#40C) 582-840 CD4236-MOD Ori ce, LP (#55C) 582-855 Ori ce, NG (#35C) 582-835 CD4842-MOD Ori ce, LP (#54C) 582-854 Additional service part numbers on following page. Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 26: Service Parts

    Conversion Kit, LP LPKI-6CM Conversion Kit, NG CD4842-MOD Conversion Kit, LP LPKI-8CM Pilot Ori ce, NG 593-528 Pilot Ori ce, LP 593-527 Regulator, NG NGK-DXV-50 Regulator, LP LPK-DXV-50 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

  • Page 27: Contact Information

    5941237, 6006743, 6019099, 6053165, 6145502, 6374822, 6484712, 6601579, 6769426, 6863064, 7077122, 7098269, 7258116, 7470729, 8147240 or other U.S. and foreign patents pending. 2000-945C Printed in U.S.A. - Copyright 2015 Heatilator • CD4236-MOD, CD4842-MOD Owner’s Manual • 2241-902 Rev. C • 11/15...

This manual is also suitable for:

Cd4842-mod

Table of Contents