Pioneer DV-600AV-S Service Manual
  1. Manuals
  2. Brands
  3. Pioneer Manuals
  4. DVD Player
  5. DV-600AV-S
  6. Service manual

Pioneer DV-600AV-S Service Manual

Hide thumbs Also See for DV-600AV-S:
Table of Contents

Advertisement

Quick Links

DVD PLAYER

DV-600AV-S
DV-600AV-K
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
Type
DV-600AV-S
WYXZT5
DV-600AV-S
WVXZT5
DV-600AV-S
YXZTUR5
DV-600AV-K
WYXZT5
DV-600AV-K
YXZTUR5
For details, refer to "
PIONEER CORPORATION
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2007
Power Requirement
AC 220 V to 240 V
AC 220 V to 240 V
AC 220 V to 240 V
AC 220 V to 240 V
AC 220 V to 240 V
Important Check Points for Good Servicing
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
DV-600AV-S
Region No.
2
2
5
2
5
" .
T-ZZV MAY 2007 printed in Japan
ORDER NO.
RRV3611
Remarks

Advertisement

Table of Contents
loading

Related Manuals for Pioneer DV-600AV-S

Summary of Contents for Pioneer DV-600AV-S

  • Page 1: Dvd Player

    PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936...

  • Page 2: Safety Information

    2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. ∗ : See page 29. /C LO M EN M EN DV-600AV-S...
  • Page 3 To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DV-600AV-S...

  • Page 4: Table Of Contents

    11. PCB CONNECTION DIAGRAM ........................72 11.1 DVD MT PCB ASSY..........................73 11.2 OPERATION 1 PCB and OPERATION 2 PCB ASSYS................75 11.3 POWER PCB ASSY..........................76 11.4 USB PCB, LOADING MOTOR and SW ASSYS ..................78 12. PCB PARTS LIST ............................79 DV-600AV-S...

  • Page 5: Service Precautions

    • Soldering time: Within 3 seconds • Soldering combination: Sn-3.0Ag-0.5Cu • When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to prevent the Flux smoke from it. Short circuit using a soldering iron. Pick Up PCB Fig. 1 DV-600AV-S...

  • Page 6: Disc Removal Method

    • Place the unit on a workstation equipped to protect against static electricity, such as conductive mat. • Soldering iron with ground wire or ceramic type is used. • A worker needs to use a ground conductive wrist strap for body. DV-600AV-S...

  • Page 7: Specifications

    • Remote control ×1 • Power cable ×1 • Audio / Video cable(1.2m) ×1 (red/white/yellow) (07650NU020) (1206158802 : WYXZT5, WYXZTUR5) (06CPBA2006) (1206138802 : WVXZT5) • Warranty Card • Operating Instructions • Dry cell batteries ×2 PLAY MODE SURROUND ZOOM DISPLAY (AA/R6P) DV-600AV-S...

  • Page 8: Specifications

    Warranty card ....... 1 Operating instructions The specifications and design of this product are subject to change without notice, due to improvement. Published by Pioneer Corporation. Copyright © 2007 Pioneer Corporation. All rights reserved. DV-600AV-S...

  • Page 9: Disc/Content Format

    Super VCD also supports the widescreen size. * Edit points may not play exactly as edited; screen may go momentarily blank at edited points. • Unfinalized playback: No Super VCD • MP3/WMA/MPEG-4 AAC/JPEG or DivX video/WMV file playback on DVD-R/-RW: DV-600AV-S...

  • Page 10: Compressed Audio Compatibility

    CD-R/-RW/-ROM discs. Keeping the same terminology as DVD-Video, individual DivX video files are called ˝Titles˝. When naming files/titles on a CD-R/-RW disc prior to burning, keep in mind that by default they will be played in alphabetical order. DV-600AV-S...

  • Page 11: Panel Facilities

    Press to turn to USB MODE. Press once again to return to DVD mode. 16 USB port (Type A) Connect USB device Compatible This mark indicates compatibility with DVD-RW discs recorded on a DVD recorder in Video Recording mode. DV-600AV-S...
  • Page 12 Use to navigate on-screen displays and Press to display a DVD disc menu, or the Disc menus. Press ENTER to select an option or Navigator if a VR format DVD-RW, CD, Video CD , MP3, WMA or JPEG disc is loaded. execute a command. DV-600AV-S...
  • Page 13 Press to jump to the next chapter or track. Press to stop the disc (you can resume playback by pressing (play)). 23 DISPLAY Press to display information about the disc playing. 24 ZOOM Press to change the zoom level. DV-600AV-S...

  • Page 14: Basic Items For Service

    Items to be checked regarding video Item to be checked regarding audio Block noise Distortion Horizontal noise Noise Dot noise Volume too low Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Too bright Sound interrupted Mottled color DV-600AV-S...

  • Page 15: Pcb Locations

    ( * ) 1..OPERATION 2 PCB ASSY A2K401A280 1..OPERATION 3 PCB ASSY A2K401ADF0 > 1..POWER PCB ASSSY A2K503A240 1..USB PCB ASSY A2K401ADD0 1..DVD MECHA ASSY A2K001A650 ( * ) A2K501A270 and A2K504A270 have same service parts. But they are NOT COMPATIBLE. DV-600AV-S...

  • Page 16: Jigs List

    • Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Position to be cleaned Cleaning tools Cleaning tools Remark Remark Pickup leneses Cleaning liquid : GEM1004 Cleaning paper : GED-008 DV-600AV-S...
  • Page 17 DV-600AV-S...

  • Page 18: Block Diagram

    FL DC- FL DC- FL DC+ FL DC+ -28V -28V POWER PCB PCB240 DPF015 USB PCB ASSY (A2K401ADD0) USB PCB PCBDD0 DEF133 NOTE : THE TIMETHIS INTERCONNECTION DIAGRAM IS THE LATEST AT OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...

  • Page 19: Loading Motor Pcb

    : LES PIECES REPAREES PAR UN > ETANT CAUTION : SINCE THESE PARTS MARKED BY > ARE DANGEREUSES AN POINT DE VUE SECURITE N’UTILISER QUE CELLS DECRITES CRITICAL FOR SAFETY,USE ONES DANS LA NOMENCLATURE DES PIECES. DESCRIBED IN PARTS LIST ONLY DV-600AV-S...

  • Page 20: Overall Block Diagram

    4.2 OVERALL BLOCK DIAGRAM DV-600AV-S...

  • Page 21: Dvd Loader Block Diagram

    4.3 DVD LOADER BLOCK DIAGRAM DV-600AV-S...

  • Page 22: Power Block Diagram

    4.4 POWER BLOCK DIAGRAM DV-600AV-S...

  • Page 23: Diagnosis

    DECK DOES NOT ACCEPT OPEN/CLOSE Is the voltage at Check P.CON 6V line of pin 8,19 and 28 of IC2301 POWER BLOCK. about DC6V ? Check CD2302 Is the lose connection connection to DECK. at CD2302 to DECK ? Change DVD LOADER. DV-600AV-S...
  • Page 24 Replace V651 or IC651. NO PLAYBACK PICTURE OF AV JACK Is there Check IC4002 and a signal at pin 187 of peripheral circuit. IC4002 ? Is there Check J7302 and peripheral video signal at pin 33 circuit. of IC7301 ? Change IC7301. DV-600AV-S...
  • Page 25 AUDIO signal at pins 7 and 8 circuit. of IC8003 ? Is there Is there Check AT +5V. voltage at pin 6 of IC8003 waveform at pins 1,2 about 5V ? and 3 0f IC8003 ? Change IC8003. Change IC4002. DV-600AV-S...
  • Page 26 When 21 pin output is RGB, Is there voltage at pin 16 of connection. 21pin about 4.5V (No load)? Is the Check Q8104, Q8105 and voltage at pin 188 of IC4002 peripheral circuit. about 3.3Vp-p ? Check IC4002 and peripheral circuit. DV-600AV-S...
  • Page 27 Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be (DVD MT PCB Assy : IC4002) generated, because the DVD processing is performed by a single chip. 64M SDRAM No power. (DVD MT PCB Assy : IC4005) Block noise is generated during playback. DV-600AV-S...

  • Page 28: Method For Diagnosing Degradation Of The Lds On The Pickup Assy

    Assy. If the voltage is 0.4 V or higher, the 780-nm LD is degraded. DVD MT PCB ASSY R4044 W822 R4051 Q4004 DMF090A Q4002 R4058 R4003 W816 W864 R4064 R4065 R4026 R2327 R7304 R7317 W807 Q7302 R8004 R8086 W822 Q8025 R4058 R8084 W809 R8066 Q8021 W808 R8065 R8061 R8028 SIDE B DV-600AV-S...

  • Page 29: Service Mode

    • After going into service mode, if you play back the disc, "DISC-NON" is displayed. • The video signal and the audio signal are outputted during the servicemode. • The SKIP key and the SCAN key are effective during the service mode. SERVICE MODE: OFF POWER GGF1381 Service mode remote control unit DV-600AV-S...

  • Page 30: Service Mode In

    3 LD ON DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650n). : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780n). DV-600AV-S...

  • Page 31: Display Specification Of The Service Mode

    : [NTSC] PAL system : [PAL] Automatic setting : [AUTO] Scart terminal output [SK – ∗ ∗] (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] S-VIDEO : [01] : [02] DV-600AV-S...

  • Page 32: Functional Specification Of The Shortcut Key

    • Region confirmation mode (ESC + A.MON [Service mode remote control unit] + "1"-"8" [Service mode remote control unit] keys) After you press the A.MON key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. DV-600AV-S...

  • Page 33: Functional Specification Of The Service Mode

    %%e -2 : NG 7.0e -4 : NG 3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors) Note: ∗ Error of AV1 is not supported in this player. Indication plan contents Character in bold : Item name : Information display DV-600AV-S...

  • Page 34: Disassembly

    Short circuit using a soldering iron. 1. Disconnect the following connectors: (CP6601 and CP6602). 2. Remove the 2 screws 1. 3. Remove the USB PCB in the direction of arrow. DVD Deck Pick Up PCB USB PCB Fig. 1-4 Fig. 1-2 DV-600AV-S...
  • Page 35 PCB and DVD MT PCB connector. 1-5: DVD MT PCB (Refer to Fig. 1-5) 1. Remove the 4 screws 1. 2. Remove the 4 screws 2. 3. Remove the DVD MT PCB in the direction of arrow. DVD MT PCB Fig. 1-5 DV-600AV-S...

  • Page 36: Dvd Deck Section

    Loader Sub Ass'y Gear Pulley Loading Motor Insulator (R) Loading Motor PCB Ass’y Traverse Ass'y • Screw Torque: 2.5 ± 0.3kgf•cm (Screw 1) • Screw Torque: 1.0 ± 0.3kgf•cm (Screw 2) Fig. 2-3-A • Screw Torque: 2.0 ± 0.3kgf•cm Fig. 2-2-A DV-600AV-S...
  • Page 37 3 supports 1. between A and B. Fig. 2-3-D 2. Remove the Plate Clamper, Magnet Clamper and Clamper. Check Hook Check Hook Plate Clamper Magnet Clamper Main Frame Loading Motor PCB Ass’y Check Hook Clamper Fig. 2-3-E Fig. 2-5-A DV-600AV-S...
  • Page 38 6. Remove the Switch PCB Ass'y. 7. Remove the screw 4. Feed Motor 8. Remove the Gear Feed. 9. Remove the 2 screws 5. 10. Remove the Feed Motor. Safety surface for pressing 11. Remove the Gear Motor. of the insert. Fig. 2-7-C DV-600AV-S...
  • Page 39 Fig. 2-8. NOTE 1. Do not make the folding lines except the specified positions for the FFC. [ 24 pin FFC ] Fold Printing Surface 79 ± 1 mm Reinforcement Plate To Pick Up PCB Fig. 2-8 DV-600AV-S...

  • Page 40: Each Setting And Adjustment

    While the screen shown at left is being displayed, updating is in progress. DO NOT TURN OFF THE POWER DURING UPDATING. 4 Updating of the firmware is completed. When the screen with the Pioneer logo is displayed, updating is completed. The time required for updating is about 2 minutes. DV-600AV-S...
  • Page 41 2 If updating of the firmware using the disc for updating failed • Was the disc for updating recognized properly? Check if the volume label of the disc is PIONEER. • Is playback of a disc other than the disc for updating possible? If playback of a test CD is also impossible, a reading section, such as PU, may be defective.

  • Page 42: Exploded Views And Parts List

    For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION YXZTUR5 Only Except WVXZT5 WVXZT5 Only YXZTUR5 Only YXZTUR5 Only YXZTUR5 Only DV-600AV-S...
  • Page 43 See Contrast table (2) Operating Instructions (S/D) See Contrast table (2) Operating Instructions (R) See Contrast table (2) (2) CONTRAST TABLE DV-600AV-S/WYXZT5, /WVXZT5, /YXZTUR5, DV-600AV-K/WYXZT5 and YXZTUR5 types are constructed the same except for the following : DV-600AV-S/ DV-600AV-S/ DV-600AV-S/ DV-600AV-K/ DV-600AV-K/ Mark No.

  • Page 44: Exterior Section

    9.2 EXTERIOR SECTION NON-CONTACT SIDE CONTACT SIDE DV-600AV-S...
  • Page 45 Spring Earth 753WUAA012 Screw,Tap Tite(B) (3x6.0) See Contrast table (2) Screw,Tap Tite(B)Pan (3x6) 810913060U (2) CONTRAST TABLE DV-600AV-S/WYXZT5, /WVXZT5, /YXZTUR5, DV-600AV-K/WYXZT5 and /YXZTUR5 types are constructed the same except for the following : DV-600AV-S/ DV-600AV-S/ DV-600AV-S/ DV-600AV-K/ DV-600AV-K/ Mark No.

  • Page 46: Dvd Mecha Section

    Note : (SW PCB ASS'Y) CD2301 NOTE: Applying positions AA, AB and AC for the CLASS PART NO. MARK grease are displayed for this section. GREASE GEM1018 Check if the correct grease is applied for each GYA1001 position. GEM1036 DV-600AV-S...
  • Page 47 814011723U Rack,Loading 92P100121A Gear,Motor 92P100088A Feed Rack Assy 92AAA0017A Screw,T-Tite(B) (M1.7x5.0 P3) 813381750U Screw,Gear Feed 92P700007A Cord Jumper (CD2301) 122H061605 Switch (SW1) 0515S32003 Push Switch (SW2) 0500101036 Screw,Tap Tite(P) (2.6x8) 811022680U Sems.Tap Tite(P) (2x8) 816112080U Screw (Bind 2x8) 811022080U DV-600AV-S...

  • Page 48: Schematic Diagram

    MMZ1608R102CT TP4103 PWR# PCE# PRD# NOTE : THE DC VOLTAGE EACH PART WAS MEASURED NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER DURING PLAYBACK. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...
  • Page 49 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 DO(F to M) R4007 TP4099 C4104 V+3E V+3E 0.01 B DGND DGND FLDC+ TP4100 FLDC+ -28V TP4101 -28V FLDC- TP4102 FLDC- R4084 C4091 4.7K 0.1 B W846 CAUTION : DIGITAL TRANSISTOR R4051 RESET TP4110 PCB130 DMF090 DV-600AV-S...

  • Page 50: Dvd Mt Pcb Assy(2/7)

    C4040 DCAS# DRAS# DBA1 DBA0 NC (WP#/ACC) SDCLK DCS# RY/BY# PRD# PCE# PRD# PCE# PWR# FROM POWER PORT (V+3D) D_GND NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...
  • Page 51 LDQM DQM1 DWE# UDQM SDCLK DCAS# CAS# SDCKE DRAS# RAS# DCS# MA11 DBA0 BA0/A13 DBA1 BA1/A12 MA10 A10/AP C4123 0.1 B TP4050 PCB130 DMF090 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-600AV-S...

  • Page 52: Dvd Mt Pcb Assy(3/7)

    : SINCE THESE PARTS MARKED BY > ARE : LES PIECES REPAREES PAR UN > ETANT DANGEREUSES CRITICAL FOR SAFETY, USE ONES DESCRIBED AN POINT DE VUE SECURITE N’UTILISER QUE CELLS DECRITES IN PARTS LIST ONLY. DANS LA NOMENCLATURE DES PIECES. DV-600AV-S...
  • Page 53 2.63 VOTK+ VOFC+ PCB130 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DMF090 THE DIGITAL TESTER DURING PLAYBACK. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...

  • Page 54: Dvd Mt Pcb Assy(4/7)

    : SINCE THESE PARTS MARKED BY > ARE POINT DE VUE SECURITE N’UTILISER QUE CELLS DECRITES CRITICAL FOR SAFETY, USE ONES NOTE : THE DC VOLTAGE EAC DANS LA NOMENCLATURE DES PIECES. DESCRIBED IN PARTS LIST ONLY. WITH THE DIGITAL TE DV-600AV-S...
  • Page 55 CAUTION: DIGITAL TRANSISTOR PCB130 DMF090 TE : THE DC VOLTAGE EACH PART WAS MEASURED NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER DURING PLAYBACK. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...

  • Page 56: Dvd Mt Pcb Assy(5/7)

    FROM POWER PORT W889 V+3F TP7303 D_GND V+6A NOTE : THEDURING PLAYBACK.MEASURED WITH THE NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DIGITAL TESTER DC VOLTAGE EACH PART WAS. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...
  • Page 57 VIDEO/AUDIO for 21PIN CP7301 IMSA-9604S-12C 21PIN-G/D-Y 21PIN-B/D-U 21PIN-R/D-V P-H/I-L_RGB-H RGB-H ASP/FS CVBS AUDIO L AUDIO R TP7301 CVBS 4CH BUS SW IC IC7302 SN74CBT3257PWR CVBS/Y/U/V S-VIDEO OUT for HE J7302 J7304 RCA-405A-08 DIN-409A PCB130 CAUTION : DIGITAL TRANSISTOR DMF090 DV-600AV-S...

  • Page 58: Dvd Mt Pcb Assy(6/7)

    DVD MT PCB ASSY (6/7) (A2K501A130) FROM POWER PORT V+5H D_GND FROM/TO MPEG/MICON/DSP TX2+ TX2- TX1+ TX1- TX0+ TX0- TXC+ TXC- HDMI_SCL HDMI_SDA W855 A_GND W856 W861 A_GND NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-600AV-S...
  • Page 59 TXC+ TXC+ CLK+ L5904 CLK-S EXC24CG900U TXC- TXC- CLK- HDMI_SCL HDMI_SDA W840 POWER HOTPLUG V+5H W851 W858 W864 PCB130 NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DMF090 OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...

  • Page 60: Dvd Mt Pcb Assy(7/7)

    : LES PIECES REPAREES PAR UN > ETANT CAUTION : SINCE THESE PARTS MARKED BY > ARE DANGEREUSES AN POINT DE VUE SECURITE NOTE CRITICAL FOR SAFETY,USE ONES N’UTILISER QUE CELLS DECRITES DESCRIBED IN PARTS LIST ONLY. DANS LA NOMENCLATURE DES PIECES. DV-600AV-S...
  • Page 61 FRROM/TO MEMORY D_GND NOTE : THE DC VOLTAGE EACH PART WAS PCB130 DMF090 MEASURED WITH THE DIGITAL TESTER NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DURING PLAYBACK. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DV-600AV-S...

  • Page 62: Operation 1 And Operation 2 Pcb Assys

    Vout R666 1/4W OS651 ROM-V340TAO NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DURING PLAYBACK. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DV-600AV-S...
  • Page 63 CP601 (CP4002) 00_6232_011_102_800+ FP_SCK FP_DI DI (M to F) FFC(1.0mm pitch) FP_DO DO (F to M) CD601 V+3E 2H0B1003 V+3E V+3E C604 DGND C605 33P CH DGND TP663 1/4W FLDC+ 0.001 B FLDC+ -28V -28V FLDC- FLDC- PCB270 DEF126 DV-600AV-S...

  • Page 64: Power Pcb Assy (1/2)

    : LES PIECES REPAREES PAR UN > ETANT NOTE : THE RESISTOR MARKED F IS FUSE RESISTOR. DANGEREUSES AN POINT DE VUE SECURITE THE ALUMI ELECTROLYTIC CAPACITOR MARKED NP N’UTILISER QUE CELLS DECRITES IS NON POLAR ONE. DANS LA NOMENCLATURE DES PIECES DV-600AV-S...
  • Page 65 CAUTION: DIGITAL TRANSISTOR PCB240 NOTE : THE DC VOLTAGE EACH PART WAS DPF015 NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE. DURING PLAYBACK. DV-600AV-S...

  • Page 66: Power Pcb Assy (2/2)

    11.4 12.1 R8101 4.7K 1/4W NOTE : THE DC VOLTAGE EACH PART WAS NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DURING PLAYBACK. DV-600AV-S...
  • Page 67 C8115 R8113 CVBS_VIDEO_OUT 6.3V 1000 YK_P 75 +-1% DVD_RGB_H_OUT Q8105 KRA102SRTK R8109 DVD_RGB_H_OUT Q8104 68 +-1% KRC104SRTK * The parts except mark cannot be changed. On that occasion, replace whole Assy. CAUTION: DIGITAL TRANSISTOR CAUTION: DIGITAL TRANSISTOR PCB240 DPF015 DV-600AV-S...

  • Page 68: Usb Pcb Assy

    HIGH SIDE SW IC (60 OHM 2.5A) IC6601 RT9702-PB (SCHOTTKY 3.0A) 2H063401 B6601 D6601 VOUT HCB2012K-600T25 RB051L-40 TO POWER PCB CP6602 A2001WR2-4P P.CON+5V /FLG P.CON+5V CORD CONNECTOR CD6602 E8241203 NOTE:THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DV-600AV-S...
  • Page 69 600T25 RB051L-40 CP6603 USB-A1D05F-4B4N W809 USB_DN W810 USB_DP C6610 W801 100P CH NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. PCBDD0 DEF133 DV-600AV-S...

  • Page 70: Wave Forms

    V:1.0V/div. H:500µsec/div. V:200mV/div. H:10µsec/div. IC4002-pin215 (ASPDIF) J8002-pin3 (SL) J7302-pin5 (Y_Out) V:1.0V/div. H:20nsec/div. V:1.0V/div. H:500µsec/div. V:500mV/div. H:10µsec/div. IC4002-pin231 (ACLK) J8002-pin2 (SR) J7302-pin3 (U_Out) V:1.0V/div. H:20ns/div. V:1.0V/div. H:500µsec/div. V:500mV/div. H:20µsec/div. CP4002-pin1 (FP_SCK) J8002-pin6 (CENTER) J7302-pin2 (V_Out) V:1.0V/div. H:20µsec/div. V:1.0V/div. H:500µsec/div. V:500mV/div. H:20µsec/div. DV-600AV-S...

  • Page 71: Power Pcb Assy

    V:500mV/div. H:20µsec/div. V:1.0V/div. H:200µsec/div. J8101-pin1 (21PIN_R_Out) J7304-pin4 (S_C) V:1.0V/div. H:200µsec/div. V:500mV/div. H:10µsec/div. J8101-pin3 (21PIN_L_Out) V:1.0V/div. H:200µsec/div. POWER PCB ASSY J8101-pin11 (G/Y_Video_Out) V:500mV/div. H:20µsec/div. J8102-pin2 (COAXIAL) V:500mV/div. H:200ns/div. J8101-pin7 (B/U_Video_Out) V:500mV/div. H:20µsec/div. OS8101-pin1 (OPTICAL) V:1.0V/div. H:200ns/div. J8101-pin15 (R/V_Video Out)) V:500mV/div. H:20µsec/div. DV-600AV-S...

  • Page 72: Pcb Connection Diagram

    Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator DV-600AV-S...

  • Page 73: Dvd Mt Pcb Assy

    Q8011 R8001 C8017 R4012 R8081 C8067 R8041 C4099 C8036 C8040 C8013 R4011 CP2303 R8090 W843 C4098 Q2304 Q2302 Q2306 Q2307 R8091 C8041 IC8008 C8058 C4112 C4093 IC8003 C2301 C8016 C8038 R8043 DMF090A CP2301 C8069 C8050 CP4003 Q8012 R8023 R8038 DV-600AV-S...
  • Page 74 R4051 Q4004 DMF090A Q4002 R4003 W816 W864 D7310 R4064 R4065 R4026 R2327 R7304 R7317 W807 Q7302 W819 Q8017 W822 R8069 R8053 Q8020 R4058 R8050 R8017 Q8010 W878 Q8008 Q8009 R8002 Q8015 R8066 R8025 Q8019 Q8021 B8001 R8065 R8061 R8028 DV-600AV-S...

  • Page 75: Operation 1 Pcb And Operation 2 Pcb Assys

    W011 W012 W013 R653 W010 R652 C611_1 R651 C676 C610_1 R656 R655 OPERATION 2 OPERATION 2 R657 R658 PCB ASSY PCB ASSY SW666 D665 C651 R666 SW663 SW665 SW660 OPERATION 3 OPERATION 3 PCB ASSY PCB ASSY SW662 SW664 DV-600AV-S...

  • Page 76: Power Pcb Assy

    B502 W022 C8115 R534 C526 R8120 C521 W025 C522 C517 R8101 DPF015A D528 C8112 W037 R539 L8101 C519 D525 W004 W019 CP504 D531 W018 C520 D523 Q502 Q504 C8113 R529 R528 CP502 W035 D535 C528 W016 D536 D533 C8114 DV-600AV-S...
  • Page 77 SIDE A SIDE A POWER PCB ASSY (CHIPMOUNTED PARTS) R 5 3 8 R 8 1 1 5 DV-600AV-S...

  • Page 78: Usb Pcb, Loading Motor And Sw Assys

    W809 B6602 C6608 C6610 W801 R6613 W810 C6604 W802 C6607 B6601 C6602 DEF133A LOADING MOTOR (CHIP MOUNTED PARTS) SOLDER SIDE DED021A M2603 CD2302 USB (INSERTED PARTS) SOLDER SIDE CP6603 SOLDER SIDE C6606 C6605 C6603 DEF133A CP6601 DED020A M2602 M2601 DV-600AV-S...

  • Page 79: Pcb Parts List

    I4UF097020 IC8002, IC8007, IC8008 IC RC4580IDR I04J045800 OTHERS OTHERS CP6603 CONNECTOR PCB SIDE 06G5AA1001 J7302 RCA JACK 060R451010 J7304 JACK DIN-409A 063R700013 J8001 RCA JACK 060R451009 J8002 RCA JACK 060R451011 CP5901 CONNECTOR PCB SIDE 0694YJ3018 X4001 CRYSTAL (27MHz) 100GT02720 DV-600AV-S...

This manual is also suitable for:

Dv-600av-k

Table of Contents