Table of Contents
Advertisement
IMPORTANT: users MuST read all instructions in the manual. All manuals MuST be kept for future reference.
SAFETy SECTION
�
!
FIRE OR EXPLOSION HAZARD
If the information in this manual is not followed
exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
- Do NOT store or use gasoline or other
flammable vapors and liquids or combustible
materials in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch;
do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier,
call the fire department.
- DO NOT RELY ON SMELL ALONE TO DETECT
LEAKS. DUE TO VARIOUS FACTORS, YOU MAY
NOT BE ABLE TO SMELL FUEL GASES.
• U.L. recognized fuel gas and CO detectors are
recommended in all applications, and their
installation should be in accordance with the
manufacturer's recommendations and/or local
laws, rules, regulations, or customs.
- Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
Safety signal words are used to designate a degree
or level of seriousness associated with a particular
hazard.
The signal words for safety markings are
WARNING and CAUTION.
a. WARNING indicates a potentially hazardous situa-
tion which, if not avoided, could result in death or
serious injury.
b. CAuTION indicates a potentially hazardous situa-
tion which, if not avoided, may result in minor or
moderate injury. It is also used to alert against
unsafe practices and hazards involving only prop-
Condensing Gas Furnaces
Fan Assisted Combustion System
upflow/ Horizontal and Downflow/ Horizontal
Available in French Canadian (FC)
Contents
Safety Section
Warranty
▲
!
DO NOT uSE THIS uNIT IF ANy PART HAS bEEN uN-
DER WATER. A FLOOD DAMAGED uNIT IS EXTREME-
Ly DANGEROuS. ATTEMPTS TO uSE THE FuRNACE
CAN RESuLT IN FIRE OR EXPLOSION. A quALIFIED
SERvICE AGENCy SHOuLD bE CONTACTED TO IN-
SPECT THE FuRNACE AND TO REPLACE ALL GAS
CONTROLS, CONTROL SySTEM PARTS, ELECTRICAL
PARTS THAT HAvE bEEN WET OR THE FuRNACE IF
DEEMED NECESSARy.
IN PROPERTy DAMAGE, PERSONAL INjuRy OR
WARNING
▲
!
EXPLOSION HAZARD
DEATH.
WARNING
▲
!
CARbON MONOXIDE POISONING HAZARD
FAILuRE TO FOLLOW THE INSTALLATION AND OPER-
ATION INSTRuCTIONS FOR THE vENTING SySTEM'S
OPERATION COuLD RESuLT IN CARbON MONOXIDE
POISONING OR DEATH.
32- 5035- 13
1
3
4
6
8
9
11
Advertisement
Table of Contents
Related Manuals for Trane UD-R9V
Summary of Contents for Trane UD-R9V
-
Page 1: Table Of Contents
32- 5035- 13 Available in French Canadian (FC) user’s Information Guide Condensing Gas Furnaces Fan Assisted Combustion System upflow/ Horizontal and Downflow/ Horizontal IMPORTANT: users MuST read all instructions in the manual. All manuals MuST be kept for future reference. Contents SAFETy SECTION WARNING... -
Page 2: Warning
When the furnace vent is blocked, a pressure stalling or servicing. Personal injury may result. switch will shut off the furnace. Call a qualified ser- vicer. 32-5035-13 © 2009 Trane... -
Page 3: General Information
User’s Information General Information WARNING ▲ IMPORTANT FACTS ELECTRIC SHOCK HAZARD The flow of combustion and ventilating air must not THESE SERvICING INSTRuCTIONS ARE FOR uSE by quALIFIED PERSONNEL ONLy. TO REDuCE THE be obstructed from reaching the furnace. Air openings RISK OF ELECTRIC SHOCK, DO NOT PERFORM ANy provided in the casing of the furnace must be kept free SERvICING OTHER THAN THAT CONTAINED IN THESE... -
Page 4: To Start The Furnace
User’s Information To Start the Furnace Lighting instructions. 5. Turn the external main gas shutoff valve and the Your furnace does not use a continuously burning pilot toggle switch located on the main gas valve inside flame. Therefore, manually lighting your furnace is not the unit to the “ON”... - Page 5 User’s Information NOTE THE LOCATION OF THE MANuAL MAIN GAS SHuTOFF vALvE FOR yOuR FuRNACE. Have your installer or servicer show you the location if you have any questions. uPFLOW FuRNACE Manual Main Gas Shut-off valve May be Located on the Left or Right Side HORIZONTAL FuRNACE Manual Main Gas Shut-off valve May be Located on the Top or bottom Side MAIN MANUAL SHUTOFF...
-
Page 6: Proper Maintenance
User’s Information Proper Maintenance AIR FILTERS How to remove your filter. Clean the filter once a month for optimum perfor- WARNING ▲ mance. A monthly visual inspection of the furnace is also recommended. See General Inspection ELECTRIC SHOCK HAZARD on page 9, number 1. DISCONNECT POWER TO uNIT bEFORE REMOvING bLOWER DOOR. - Page 7 User’s Information Air filters may also be located outside of the furnace using a remote filter grille. The filter grille could be in a hallway, wall, or in the ceiling. Check with your deal- er for the exact location of your filter and the method of changing the filters.
-
Page 8: The Problem Solver
User’s Information DOWNFLOW (vertical) FILTER TAbLE REquIRED FILTERS - DOWNFLOW CAbINET WIDTH FILTER quANTITy & SIZE 17-1/2" 2 - 14" X 20" X 1" 21" 2 - 16" X 20" X 1" 24-1/2" 2 - 16" X 20" X 1" DOWNFLOW/HORIZONTAL FILTER The Problem Solver Other than performing the simple maintenance rec-... -
Page 9: Regular Dealer Maintenance
User’s Information Regular Dealer Maintenance To ensure proper operation of your furnace, the rec- CAuTION ▲ ommended dealer inspection is once a year, before the heating season. Regular maintenance must be Do NOT touch igniter. It is extremely hot. performed by a qualified service professional. WARNING ▲... - Page 10 User’s Information 7. OPERATION – Your warm air furnace should not be operated in a corrosive atmosphere. Paint sol- vents, cleaning chemicals, spray propellants, and FLAME bleaches should not be used in the vicinity of the furnace during normal operation. 8.
- Page 11 User’s Information Base Limited Warranty Gas Furnace UD-R9V, DD-R9V, UD-AFV, DD-ACV, UD-ACV, UX-AFV, UH2, DH2, UH3, DH3, UHM, DHM, UH1, DH1 First letter may be preceded by an "A" or "T" (Parts Only) Models Less Than 20 Tons for Residential Use* This limited warranty is provided by the manufacturer to the original purchaser and to any succeeding owner of the real property to which the gas furnace is originally affixed, and applies to products purchased and retained for use within the U.S.A.
-
Page 12: Limited Warranty
* This warranty is for commercial usage of said equipment and not applicable when the equipment is used for a residential application. Com- mercial use is any application where the end purchaser uses the product for other than personal, family or household purposes. As an eNeRGY STAR Partner, Trane has determined that this product meets the eNeRGY STAR guidelines for energy efficiency. - Page 13 User’s Information Important Product Information Registering your products helps provide you with one of the strongest manufacturer limited warranties avail- able. To register, go to the manufacturer’s website or contact your dealer. You will need the serial number, model number, and installation date for each product being registered. Your dealer may have included these on your invoice or can provide a list for you to use.
- Page 14 As an eNeRGY STAR Partner, Trane has determined that this product meets the eNeRGY STAR guidelines for energy efficiency. File name 32-5035-13 Supersedes 32-5035-12 Date 10/09 Trane 10/09 6200 Troup Highway Tyler, TX 75707 Since the manufacturer has a policy of continuous product and product data improvement, it reserves the For more information contact right to change design and specifications without notice.
Need help?
Do you have a question about the UD-R9V and is the answer not in the manual?
Questions and answers