Page 1
HP TFT5110R Maintenance and Service Guide October 2002 (First Edition) Part Number 292490-001 HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 9:42 AM...
Page 2
“as is” without warranty of any kind and is subject to change without notice. The warranties for HP products are set forth in the express limited warranty statements accompanying such products. Nothing herein should be construed as constituting an additional warranty.
Removing the Cable Management Arm Assembly................3-15 Removing the Mounting Rails w/Slides.................... 3-16 SPS-CORD, AC PWR, 10’, BLK 255135-XXX..................3-17 Chapter 4 Specifications HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 9:42 AM...
Improper repairs can create conditions that are hazardous. Audience Assumptions This guide is for service technicians. HP assumes you are qualified in the servicing of computer equipment and trained in recognizing hazard in products with hazardous energy levels and are familiar with weight and stability precautions for rack installations.
For HP technical support: • In the United States and Canada, call 1-800-652-6672. • Outside the United States and Canada, refer to www.hp.com. HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 9:42 AM...
Introduction This chapter provides component identification and serial number location for the HP TFT5110R. Use the following information to locate and identify the components of the TFT5110R. Front Panel Components Figure 1-1: Front panel components Item Description Power on/off switch...
Serial Number Location for the TFT5110R You need to provide the serial number to HP when requesting information or ordering spare parts for the TFT5110R. The serial number for the TFT5110R is located on the bottom of the unit. Figure 1-2: Serial number location...
Illustrated Spare Parts List This chapter provides an illustrated parts breakdown and a spare parts list for the HP TFT5110R. Refer to Figure 2-1 for the names of referenced spare parts. HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/18/02 2:27 PM...
SPS-CORD, AC PWR, 10’, BLK-IT* 255135-061 SPS-CORD, AC PWR, 10’, BLK-SI* 255135-111 SPS-CORD, AC PWR, 10’, BLK-JP* 255135-291 * Not shown HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/18/02 2:27 PM...
Before beginning these procedures, be sure to turn off the power to the display and disconnect the power cable from the power source. IMPORTANT: As you disassemble the TFT5110R, be sure to place the screws in a safe place and separate them according to their groupings.
SPS-CORD, AC PWR, 10’, BLK 255135-XXX Tools Required • Phillips screwdriver • T-15 Torx driver • Cutting tool for tie wraps HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Removal and Replacement Procedures SPS-PLASTIC KIT, MISC, 5110R 300963-001 Figure 3-1: Rear cover HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
3. Slide the rear cover back (2) and rotate it out of position (3). Figure 3-2: Removing the rear cover To replace the rear cover, reverse the above procedure. HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Removal and Replacement Procedures SPS-MONITOR, TFT, 5110R, 1U 300962-001 Figure 3-3: Monitor HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Page 15
WARNING: Do not pull on the exposed wires. Pull only on the plastic shroud connectors attached to the wires. Figure 3-5: Disconnecting the cables HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Page 16
NOTE: The cables attached to the monitor are not shown in the figure below. Figure 3-6: Removing the screws securing the monitor To replace the monitor, reverse the above procedure. HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Removal and Replacement Procedures SPS-ADPTRAC 40W 4PRONG/MINIJCK 218319-001 Figure 3-7: AC brick HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
IMPORTANT: Be sure the AC brick is properly located on the Velcro pad so that the rear cover can be installed. To replace the AC brick, reverse the above procedure. HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Removal and Replacement Procedures SPS-TRAY, METAL, 5110R 300964-001 Figure 3-9: Metal tray and metal controller cover 3-10 HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Removal and Replacement Procedures SPS-BD, CNTRLR 229847-001 Figure 3-10: Controller board HP TFT5110R Maintenance and Service Guide 3-11 HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Figure 3-11: Removing screws from metal controller cover 6. Slide the metal controller cover (1) and lift it straight out (2). Figure 3-12: Removing metal controller cover 3-12 HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
Page 22
10. Remove the controller board from the metal controller cover. To replace the metal controller cover and controller board, reverse the above procedure. HP TFT5110R Maintenance and Service Guide 3-13 HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
SPS-RACKMOUNT KIT, 5110R 300965-001 Figure 3-14: Mounting rails w/slides and cable management arm assembly Item Description Mounting rails w/slides Cable management arm assembly 3-14 HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
4. Remove the screw (1) securing the cable management arm brace to the rail (on each side), and remove the brace assembly (2). Figure 3-16: Removing the cable management arm brace HP TFT5110R Maintenance and Service Guide 3-15 HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
To replace the cable management arm assembly, reverse the above procedure. Removing the Mounting Rails w/Slides IMPORTANT: You must remove the cable management arm assembly and the TFT5110R before removing the mounting rails w/slides. To remove the mounting rails w/slides: 1.
SPS-CORD, AC PWR, 10’, BLK 255135-061 SPS-CORD, AC PWR, 10’, BLK 255135-111 SPS-CORD, AC PWR, 10’, BLK 255135-291 SPS-CORD, AC PWR, 10’, BLK HP TFT5110R Maintenance and Service Guide 3-17 HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/23/02 10:13 AM...
4.8 kg (10.6 lbs) (unpacked) Maximum Dimensions Height 3.02 cm (1.19 inches) Depth 40.05 cm (15.75 inches) Width 42.06 cm (16.56 inches) HP TFT5110R Maintenance and Service Guide HP CONFIDENTIAL Codename: Pug Part Number: 292490-001 Last Saved On: 10/18/02 11:48 AM...