Three- Way Catalytic Converters - Toyota 2006 Hilux Mk6 Owner's Manual

Three- way catalytic converters

20h009
The three- way catalytic converters are
emission control devices installed in
the exhaust system.
The purpose is to reduce pollutants in the
exhaust gas.
CAUTION
D
Keep people and combustible mate-
rials away from the exhaust pipe
while the engine is running. The
exhaust gas is very hot.
D
Do not idle or park your vehicle
over anything that might burn easi-
ly such as grass, leaves, paper or
rags.
NOTICE
A large amount of unburned gases
flowing into the three- way catalytic
converter may cause it to overheat
and create a fire hazard. To prevent
this and other damage, observe the
following precautions:
z Use only unleaded gasoline.
z Do not drive with an extremely low
fuel level; running out of fuel could
cause the engine to misfire, creat-
ing an excessive load on the three-
way catalytic converter.
z Do not allow the engine to run at
idle speed for more than 20 min-
utes.
z Avoid racing the engine.
z Do not push- start or pull- start your
vehicle.
z Do not turn off the ignition while
the vehicle is moving.
z Keep your engine in good running
order. Malfunctions in the engine
electrical system, electronic ignition
system or fuel system could cause
an extremely high three- way cata-
lytic converter temperature.
z If the engine becomes difficult to
start or stalls frequently, take your
vehicle in for a check- up as soon
as possible. Remember, your Toyota
dealer knows your vehicle and its
three- way catalytic converter sys-
tem best.
z To ensure that the three- way cata-
lytic converter and the entire emis-
sion control system operate proper-
ly, your vehicle must receive the
periodic inspections required by the
Toyota Maintenance Schedule. (See
page 144.)
99