1. Manuals
  2. Brands
  3. Axis Manuals
  4. Heater
  5. MTC-AXIS-GM-LP
  6. Owner's manual

Axis MTC--GM-LP Owner's Manual

Outdoor heater
Hide thumbs
Table of Contents

Advertisement

Quick Links

Advertisement

Table of Contents
loading

Summary of Contents for Axis MTC-AXIS-GM-LP

  • Page 2 Consumer: Please keep this manual for future reference. Read the instructions before use. Model# This appliance must be installed in MTC-AXIS-GM-LP accordance with such regulations as are in force. Owner’s Manual Questions, problems, missing / replacement parts? Before returning to your retailer, call our customer service department at 1-866-814-0585, 8 a.m.-8 p.m., EST,...

  • Page 3: Warnings And Cautions

    WARNINGS AND CAUTIONS DANGER CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as a camper, tent or home. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
  • Page 4 WARNINGS AND CAUTIONS NOTE:PLEASE READ THE FOLLOWING SAFETY RULES WARNING: The installation must conform with local codes Any guard or other protective device or, in the absence of local codes, with the removed for servicing the heater must be National Fuel Gas Code, ANSI Z223.1/NFPA 54, replaced prior to operating the heater.
  • Page 5 WARNINGS AND CAUTIONS NOTE:PLEASE READ THE FOLLOWING SAFETY RULES WARNING: Within a partial enclosure which includes an The pressure regulator and hose assembly sup- overhead cover and three side walls, as long as plied with the appliance must be used, replace- 30 percent or more of the horizontal periphery of ment pressure regulators and hose assemblies the enclosure is permanently open.
  • Page 6 WARNINGS AND CAUTIONS NOTE: PLEASE READ THE FOLLOWING SAFETY RULES: Perform a leak test with a soapy solution: 1. To check gas connections. 2. After connecting a new cylinder. 3. Upon re-assembly after disassembly. This heater is designed to operate with a standard 20 Ib propane cylinder with Approved Cylinder Connection.

  • Page 7: Parts Contents

    PARTS CONTENTS Please check the contents of the packaging as to whether anything is missing! Chimney cover Weather resistant heat reflector prevents water from entering the combustion zone and reflects heat down. Safety guard protects the full height of the heat exchanger tube. Heat exchange tube has a large heat-radiating surface.
  • Page 8 ASSEMBLY INSTRUCTIONS Warning:This appliance requires installation Step 1 by a competent person. Proper assembly is the responsibility of the installer. tep1: To assemble unit-partially open gas chamber door. Carefully lift heat reflector until entire heat exchange tube is exposed. Step 2: After heat exchange tube is fully extended, rotate Step 2 counter-clockwise until stopped.
  • Page 9 ASSEMBLY INSTRUCTIONS Warning:This appliance requires installation by a competentperson. Proper assembly is the responsibility of the installer. Step 3 Step3: Insert M6x35 thumb screw into hole A, and M6x12 thumb screw into hole B. Lock the screws. CAUTION! After raising and pivoting heat exchange tube, tighten two thumb screws to lock into place.
  • Page 10 ASSEMBLY INSTRUCTIONS Warning:This appliance requires installation Step 5 by a competent person. Proper assembly is the responsibility of the installer. Step5: Place battery in compartment below control panel. Step6: Place the gas cylinder (not included) into the base Step 6 assembly , and fix it with fixing chain.

  • Page 11: Safety Check

    SAFETY CHECK WARNING : ONLY AN AUTHORIZED GAS TECHNICIAN SHOULD INSTALL THIS PRODUCT. Check for leaks All connections on the patio heater have been checked for leakage at the factory. In transportation and handling some connections may have loosened. Follow these steps to check the gas hose/regulator/cylinder connections: 1) Make leakage solution by mixing 1 part liquid dish soap and 3 parts water.

  • Page 12: Operation

    OPERATION WARNING: DO NOT ATTEMPT TO OPERATE HEATER UNTIL YOU HAVE READ AND UNDERSTAND ALL PRECAUTIONS. FAILURE TO DO SO CAN RESULT IN SERIOUS PERSONAL INJURY, DEATH, OR PROPERTY DAMAGE. Before turning gas supply ON WARNING FOR YOUR SAFETY: If at any time you are unable to Your heater was designed and approved for OUTDOOR light burner and smell gas, wait 5 USE ONLY.
  • Page 13 OPERATION 4) When the pilot is lit keep knob pressed for up to 20 seconds to heat the thermocouple flame sensor, then release it (first ignition generally takes more time, because the gas circuit is full of air). 5) If the pilot does not stay lit, repeat steps 3 and 4. 6) Turn knob to “LOW “...
  • Page 14 OPERATION CAUTION : AVOID INHALING FUMES EMITTED FROM THE HEATER'S FIRST USE. SMOKE AND ODOR FROM THE BURNING OF OILS USED IN MANUFACTURING WILL APPEAR. BOTH SMOKE AND ODOR WILL DISSIPATE AFTER APPROXIMATELY 30 MINUTES. THE HEATER SHOULD NOT PRODUCE THICK BLACK SMOKE. NOTE: The burner may be noisy when initially turned on.

  • Page 15: Locating Heater For Use

    LOCATING HEATER FOR USE CAUTION: WHEN CERTAIN MATERIALS OR ITEMS ARE LEFT, ABOVE, BESIDE OR UNDER THIS HEATER WHILE IN USE, THEY WILL BE SUBJECT TO RADIANT HEAT AND COULD BE SERIOUSLY DAMAGED. This heater is primarily used for the heating of outdoor patios, decks, spas, pools and open working areas.

  • Page 16: Maintenance & Storage

    MAINTENANCE/STORAGE CLEANING AND MAINTENANCE : To enjoy years of outstanding performance from your WARNING: heater make sure you perform the following maintenance FOR YOUR SAFETY ; activities on a regular basis: DO NOT touch or move heater for at least 45 minutes after use. Allow Keep exterior surfaces clean.
  • Page 17 MAINTENANCE/STORAGE Spiders and insects can nest in burner or orifices. This dangerous condition can damage heater and render it NOTE: unsafe for use. Clean burner holes by using a heavy-duty wait until heater is cool before pipe cleaner. Compressed air may help clear away covering.

  • Page 18: Troubleshooting

    TROUBLESHOOTING PROBLEM PROBABLE CAUSE SOLUTION Pilot will not light Gas valve may be OFF Turn the gas valve ON Fuel tank empty Refill LP gas tank Purge air from lines Air in supply system Loose connection Check all fittings Pilot will not stay on Debris around pilot Clean dirty area Loose connection...
  • Page 19 one 1 OUTDOOR ORDER LLC. 1-866-814-0585 cs@outdoororder.com...
  • Page 20 Dear Valued Customer, Thank you for your recent purchase from Outdoor Order. We pride ourselves in providing the most innovative, reliable and stylish outdoor comfort products in the industry. Our mission is simple, bring order to the outdoors.  Our collection meets the highest manufacturing standards and is backed by an unmatched industry warranty.

Table of Contents