Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Trotec TTK 1500
Summary of Contents for Trotec TTK 1500
- Page 1 TTK 1500 OPERATING MANUAL DEHUMIDIFIER...
-
Page 3: Table Of Contents
The product names used are registered and should be treated appropriately. The delivered product may vary from product images. This document was produced with all due care. We accept no liability whatsoever for mistakes or omissions. © Trotec Operating Manual – Dehumidifier TTK 1500... -
Page 4: Information About The Device
Scope of supply (standard) • TTK 1500 • air filter • condensation drain hose • operating manual Optional accessories • humidistat • condensation pump • energy cost gauge Operating Manual – Dehumidifier TTK 1500... -
Page 5: Technical Data
To determine the precise power consumption, a separate energy cost gauge can be set between the construction dryer and the power source. Contact Trotec customer service if you want this alternative version. Operating Manual – Dehumidifier TTK 1500... -
Page 6: Circuit Diagram
CONDENSER SERVICE SCHRADER INE-3-GA PHIAL SERVICE SUCTION SCHRADER ACCUMULATOR INSULATION Circuit diagram CONTROL FUSE HP SWITCH LP SWITCH BREAKS ON BREAKS ON (F1) PRESSURE RISING PRESSURE FALLING FAULT LAMP CONTINUOUS CYCLE FAN MODE SWITCH Operating Manual – Dehumidifier TTK 1500... -
Page 7: Safety
Intended use Safety Only use the device TTK 1500 as a mobile industrial dryer for drying and dehumidifying room air, while adhering to and Read this manual carefully before starting or using the following the technical data. device. Store the manual near the device or its site of use! Intended use encapsulates: •... -
Page 8: Transport
After transporting the device, proceed as follows: 1. Set the device in an upright position after transport. 2. Ensure that the device sits flat on the floor. The wheels are then raised and the device cannot roll away. Operating Manual – Dehumidifier TTK 1500... -
Page 9: Operation
"Automatic defrost" indicator light: Lights when the automatic defrost is active. using several devices at one generator). Control on/off Operating hours counter Mains switch: "ON": Device is switched on. "OFF": Device is switched off. Operating Manual – Dehumidifier TTK 1500... - Page 10 Check the fill level of the container regularly. – Position the end of the condensation drain hose above a water drain. For larger distances, a longer hose of the same type can also be used. Operating Manual – Dehumidifier TTK 1500...
- Page 11 – The device can also be operated with a condensation pump. "Humidistat" operation mode (optional) Contact Trotec customer service if you want this alternative The device can also be operated with a humidistat. version. The humidistat switches the device on or off depending on the humidity.
-
Page 12: Errors And Faults
• If you operate the device with a humidistat, check the desired humidity. The humidity in the room must be above the selected range. Reduce that the selected humidity. • Check the air filter is not dirty. If necessary, clean or replace the air filter. Operating Manual – Dehumidifier TTK 1500... -
Page 13: Maintenance
6. Date: 7. Date: 8. Date: Signature: Signature: Signature: Signature: 9. Date: 10. Date: 11. Date: 12. Date: Signature: Signature: Signature: Signature: 13. Date: 14. Date: 15. Date: 16. Date: Signature: Signature: Signature: Signature: Operating Manual – Dehumidifier TTK 1500... - Page 14 4. If you find dirt, use a high pressure cleaner to clean the device according to "Cleaning the air inlets and the air filter". 5. Put the air filter back in. 50 cm 50 cm 90° Operating Manual – Dehumidifier TTK 1500...
- Page 15 Read the chapter "Maintenance intervals" and replace the air filter punctually! Cleaning the inside with compressed air Caution! When cleaning the inside, take care not to bend the fins of the condenser and evaporator. Do not damage the insulation. Operating Manual – Dehumidifier TTK 1500...
- Page 16 M20 plastic gland back nut 7130000912 float switch (62-00-554) 7310000349 tube insert (62-00-094) 7170000191 peristaltic pump 11 litre per hr. SD062350 humidistat SD294650 bulkhead connector SD041450 control knob 7310000348 locking collet SD293050 damper plate Operating Manual – Dehumidifier TTK 1500...
- Page 17 8 μF SD072650 terminal block 6 way SA582601 loom assembly 7140000928 defrost stat/timer SD035353 fuse 1/4 x 1 1/4, 1 A SD035350 fuse 3 A SD035352 fuse 1/4 x 1 1/4, 7 A Operating Manual – Dehumidifier TTK 1500...
- Page 18 MAINS FAULT DEFROST M/C ON Item number Spare part 7310001153 console moulding 7141000891 pilot light red rectangular 250 V 7141000889 pilot light amber rectangular 7141000890 pilot light white rectangular 7130000892 rocker switch illuminated red Operating Manual – Dehumidifier TTK 1500...
-
Page 19: Disposal
Directive 2002/ compatibility. 96/EC of the European Parliament and Council of 27th Herewith, we declare that the dehumidifier TTK 1500 was January 2003 concerning old electrical and electronic equipment. developed, constructed and produced in compliance with the At the end of its life, please dispose of this instrument in a manner named EC directives. - Page 20 Trotec GmbH & Co. KG Grebbener Str. 7 D-52525 Heinsberg +49 2452 962-400 +49 2452 962-200 info @ trotec.com www.trotec.com...