Transporting Machine; Storing Machine; Recommended Stock Items - Tennant 3540 Operator And Parts Manual

OPERATION
4. Keep the battery tops clean to prevent battery
corrosion.
To clean batteries:
FOR SAFETY: When servicing machine, wear
protective gloves and eye protection when
handling batteries and battery cables. Avoid
contact with battery acid.
a. Mix a strong solution of baking soda and water
(Figure 25).
b. Brush the solution sparingly over the battery
tops and cable connectors.
NOTE: Do not allow baking soda solution to enter
battery cells.
c. Use a wire brush to clean the battery terminals
and cable connectors.
d. After cleaning, apply a coating of clear battery
post protectant to the terminals and cable
connectors.
5. Check for loose or worn cables. Replace if worn.

TRANSPORTING MACHINE

When transporting machine by use of trailer or truck,
be certain to follow tie--down procedures below:
FOR SAFETY: When using machine, go slow on
inclines and slippery surfaces.
1. Load the machine using a recommended loading
ramp.
2. Position the front of machine up against the front
of the trailer or truck.
14
FIG. 25
Home Find... Go To..
3. Place a block behind each rear wheel to prevent
machine from rolling.
4. Place tie--down straps over top of machine to
prevent it from tipping. It may be necessary to install
tie--down brackets to the floor of your trailer or truck.
FOR SAFETY: When transporting machine, use a
recommended ramp when loading/unloading
on/off truck or trailer, use tie- -down straps to
secure machine to truck or trailer.

STORING MACHINE

Before storing the machine perform the following
instructions below:
1. Empty and rinse out recovery tank and accessory
tools.
2. Empty or replace vacuum bag.
3. Raise or remove squeegee assembly.
4. Store machine in a dry area in the upright position.
5. Disconnect battery cables if storing for a lengthy
period.
ATTENTION: Do Not Expose Machine To Rain.
Store Indoors.
ATTENTION: If storing machine in freezing
temperatures, be certain to drain machine of all
water. Damage due to freezing is not covered by
warranty.

RECOMMENDED STOCK ITEMS

Refer to the Parts List section in this manual for
recommended stock items. Stock Items are clearly
identified with a bullet preceding the parts description.
See example below:
Tennant 3540 (12- -04)