U-Line U-1075WCS-00 Service Manual
Hide thumbs
Also See for U-1075WCS-00:
- Installation manual (16 pages) ,
- Use and care manual (19 pages) ,
- Install manual (14 pages)
Table of Contents
Advertisement
SERVICE MANUAL
1000 SERIES & ADA MANUAL CONTROL MODELS
®
WINE CAPTAIN
MODELS
U-1075WCS-00
U-1075WCS-02
U-1075WCS-13
U-1075WCS-15
The Built-In Undercounter Leader Since 1962
Models Covered
BEVERAGE CENTER
U-1075BEVS-00
U-1075BEVS-02
U-1075BEVS-13
U-1075BEVS-15
REFRIGERATOR
ULN-29RB-00
ULN-29RB-02
ULN-29RB-06
ULN-29RB-09
ULN-29RB-13
ULN-29RB-15
ULN-29RWH-00
ULN-29RWH-02
ULN-29RWH-06
ULN-29RWH-09
ULN-29RWH-13
ULN-29RWH-15
ULN-29RWH-23
ULN-29RWH-25
®
FREEZER
ULN-75FB-00
ULN-75FB-13
ULN-75FWH-00
ULN-75FWH-13
U-LINE.COM
Advertisement
Table of Contents
Troubleshooting
Related Manuals for U-Line U-1075WCS-00
Summary of Contents for U-Line U-1075WCS-00
- Page 1 SERVICE MANUAL ® 1000 SERIES & ADA MANUAL CONTROL MODELS Models Covered ® WINE CAPTAIN MODELS BEVERAGE CENTER REFRIGERATOR FREEZER U-1075WCS-00 U-1075BEVS-00 ULN-29RB-00 ULN-75FB-00 U-1075WCS-02 U-1075BEVS-02 ULN-29RB-02 ULN-75FB-13 U-1075WCS-13 U-1075BEVS-13 ULN-29RB-06 ULN-75FWH-00 U-1075WCS-15 U-1075BEVS-15 ULN-29RB-09 ULN-75FWH-13 ULN-29RB-13 ULN-29RB-15 ULN-29RWH-00 ULN-29RWH-02...
-
Page 2: Product Liability Policy
U-Line Customer Assurance Department. If U-Line’s evaluation finds the unit not to be defective, does not repeat a failure or does not leak any water from the U-Line unit or U-Line P60 pump, all claims for damage will be declined. -
Page 3: Table Of Contents
Table Of Contents General Information Safety Alert Definitions............................1 General Precautions ..............................1 Models Covered..............................2 Warranty Claims Procedure ..........................3 Proof of Purchase..............................3 Serial Number.................................4 Replacement Parts ..............................4 Checking Product Temperature.........................5 Normal Operating Sounds...........................5 Control Dial ................................6 Adjusting Air Temperature..........................6 Standard Doors Door Alignment and Adjustment........................7 Door Reversability..............................7 Reversing the Door ...............................7 Maintenance... -
Page 4: General Information
• Allow unit temperature to stabilize for 24 hours before use. • Do not Block any internal Fans. Use only genuine U-Line replacement parts. Imitation parts can damage the unit, affect its operation or performance and may void the warranty. -
Page 5: Models Covered
Right Hand Hinge Stainless Glass Door w/Lock Glass Shelves/Wine Racks U-1075BEVS-15 120V Left Hand Hinge Stainless Glass Door w/Lock Glass Shelves/Wine Racks U-1075WCS-00 120V Right Hand Hinge Stainless Glass Door Wine Racks U-1075WCS-02 230V Right Hand Hinge Stainless Glass Door... -
Page 6: Warranty Claims Procedure
Department at 1-800-779-2547. This will allow you to get a proof of purchase, if needed, before you submit the claim. At U-Line, parts and labor claims are paid separately. Included in labor are freon and recovery charges, all other parts are handled by the parts department. -
Page 7: Serial Number
If we require that a part be returned to The next two digit segment, 11, represents the month the unit was U-Line, you will be informed at the time the order is placed. It will be made. -
Page 8: Checking Product Temperature
• The number of door openings and the time the door is open. • The time the internal light is illuminated. (This mainly affects product on the top rack or shelf.) • The front grille or condenser are obstructed. U-Line Service... -
Page 9: Control Dial
The unit is shipped with the control dial in a position suggested for rechecking. standard room conditions. • Factory recommended set-point is MID setting on dial control. To adjust the set point temperature: Adjust the temperature by turning the numbered dial (1) in small increments. U-Line Service... -
Page 10: Standard Doors
2. Remove corresponding screws on opposite side of cabinet. On side of the cabinet. some models there may be a nut behind one or both screws on either side. Plastic Plastic Plug Hole Plug Hole Right Side Left Side Door Swing Door Swing U-Line Service... - Page 11 Install the grille, see MAINTENANCE section of this guide. 4. Remove the U-Line nameplate (3) from door. This will reveal mounting holes for the door actuator bracket. 5. Remove door actuator (4) from door. Be sure to only remove the two screws holding the actuator to the door.
-
Page 12: Maintenance
The unit must be located on a level surface, for proper door and ice maker (if equipped) operation. Use a level to check the levelness of the unit from front to back and from side to side. Place the level along top edge and side edge as shown (1). U-Line Service... -
Page 13: Removing And Installing Interior Shelves
For models equipped with door shelves: To remove the door shelf. 1. Grasp shelf in center, and lift until the shelf notches (1) clear the pins (2). 2. Carefully pull the shelf away from the door. U-Line Service... -
Page 14: Troubleshooting
• Is the door or drawers sealing properly? If the door or drawer is not sealed properly, it allows heat into the unit. U-Line’s warranty is 90 days for door or drawer adjustments. -
Page 15: Troubleshooting Guide
Obstructed drain cup or tube Clear as needed, test flow. Problem Kinked condensate drain line Reroute condensate drain line and test flow. Drain trough and cup misaligned Trough is slotted for adjustment. Loosen retainers and adjust as needed. U-Line Service... -
Page 16: Compressor Information
The hot, high pressure gas is pumped out the discharge line and into the condenser. The cycle continues. EMI30HER EMU30HSC EMU40HNP Voltage Frequency Start Winding 21.20 Run Winding COMPRESSOR CONDENSER OVERLOAD PROTECTOR DRYER STARTING RELAY EVAPORATOR CAPILLARY TUBE RELAY COVER CAPACITOR (IF EQUIPPED) U-Line Service... -
Page 17: Refrigeration Systems
In deep vacuum temperature temperature temperature temperature No refrigeration Restriction normal (cool) (cool) (cool) (cool) Room Room Room Lower than No Gas 0 PSIG to 25" temperature Cool to hot temperature temperature No refrigeration normal (cool) (cool) (cool) U-Line Service... -
Page 18: Service
Service Service Before Calling for Service If you think your U-Line product is malfunctioning, read the OPERATION section of this guide to understand clearly the function of the control. If the problem persists, read the NORMAL OPERATING SOUNDS and TROUBLESHOOTING GUIDE section of this guide to help you quickly identify common problems, and possible causes and remedies. -
Page 19: Cleaning
For best ® results use Claire Stainless Steel Polish and Cleaner, which can be purchased from U-Line Corporation (Part Number 173348). NOTICE Comparable products are acceptable. Frequent cleaning will The drain pan was not designed to capture the water remove surface contamination that could lead to rust. -
Page 20: Condenser Cleaning
RISK OF CHILD ENTRAPMENT. Before you throw away your old refrigerator or freezer, take off the doors and leave shelves in place so children may not easily climb inside. 3. Remove the cabinet door. 75 Models Typical Model Shown U-Line Service... - Page 21 Cleaning U-Line Service...
-
Page 22: Product Information
E-mail: onlineparts@u-line.com BUILDING ON THREE GENERATIONS OF INNOVATION For nearly five decades and three generations, U-Line continues to be the leader in innovation, quality and value in the premium built-in undercounter ice making, refrigeration and wine preservation market. U-Line has captivated those with an appreciation for the finer things with exceptional functionality, style, inspired innovation and attention to even the smallest details.