Table of Contents
Advertisement
Quick Links
SERVICE MANUAL
1100 & ADA ELECTRONIC CONTROL MODELS
®
WINE CAPTAIN
MODELS
U-1115WCB-00
U-1115WCB-02
U-1115WCS-00
U-1115WCS-02
U-1115WCS-09
U-1175WCB-00
U-1175WCB-02
U-1175WCB-13
U-1175WCS-00
U-1175WCS-02
U-1175WCS-13
U-1175WCS-15
The Built-In Undercounter Leader Since 1962
Models Covered
BEVERAGE CENTER
U-1175BEVSS-00
U-1175BEVSS-02
U-1175BEVSS-13
U-1175BEVSS-15
REFRIGERATOR
U-1115RB-00
U-1115RS-00
U-1115RS-01
U-1175RB-00
U-1175RB-02
U-1175RB-13
U-1175RS-00
U-1175RS-01
U-1175RS-02
U-1175RS-13
U-1175RS-15
U-1175RW-00
U-1175RW-02
U-1175RW-13
®
ADA HEIGHT
COMPLIANT
REFRIGERATOR
U-ADA24RB-13
U-ADA24RGLB-13
U-ADA24RGLS-13
U-ADA24RGLS-15
U-ADA24RS-13
U-ADA24RS-15
U-LINE.COM
Advertisement
Table of Contents
Related Manuals for U-Line U-1115WCB-00
Summary of Contents for U-Line U-1115WCB-00
- Page 1 SERVICE MANUAL ® 1100 & ADA ELECTRONIC CONTROL MODELS Models Covered ADA HEIGHT ® WINE CAPTAIN COMPLIANT MODELS BEVERAGE CENTER REFRIGERATOR REFRIGERATOR U-1115WCB-00 U-1175BEVSS-00 U-1115RB-00 U-ADA24RB-13 U-1115WCB-02 U-1175BEVSS-02 U-1115RS-00 U-ADA24RGLB-13 U-1115WCS-00 U-1175BEVSS-13 U-1115RS-01 U-ADA24RGLS-13 U-1115WCS-02 U-1175BEVSS-15 U-1175RB-00 U-ADA24RGLS-15 U-1115WCS-09 U-1175RB-02...
-
Page 2: Product Liability Policy
U-Line Customer Assurance Department. If U-Line’s evaluation finds the unit not to be defective, does not repeat a failure or does not leak any water from the U-Line unit or U-Line P60 pump, all claims for damage will be declined. -
Page 3: Table Of Contents
Table Of Contents General Information Safety Alert Definitions ............................1 General Precautions .............................1 Models Covered ..............................2 Warranty Claims Procedure ..........................3 Proof of Purchase ..............................3 Serial Number ................................4 Replacement Parts ..............................4 Checking Product Temperature ........................5 Normal Operating Sounds ..........................5 System Default Values ............................6 Interior Lighting ..............................7 1000 Series Electronic Control .........................8 1000 Series Service Menu ...........................9... -
Page 4: General Information
• Allow unit temperature to stabilize for 24 hours before use. • Do not Block any internal Fans. Use only genuine U-Line replacement parts. Imitation parts can damage the unit, affect its operation or performance and may void the warranty. -
Page 5: Models Covered
GLASS SHELVES U-1175RW-02 230V Right Hand Hinge SOLID WHITE GLASS SHELVES U-1175RW-13 120V Right Hand Hinge SOLID WHITE W/LOCK GLASS SHELVES U-1115WCB-00 120V Right Hand Hinge GLASS BLACK WINE RACKS U-1115WCB-02 230V Right Hand Hinge GLASS BLACK WINE RACKS U-1115WCS-00... -
Page 6: Warranty Claims Procedure
Department at 1-800-779-2547. This will allow you to get a proof of purchase, if needed, before you submit the claim. At U-Line, parts and labor claims are paid separately. Included in labor are freon and recovery charges, all other parts are handled by the parts department. -
Page 7: Serial Number
If we require that a part be returned to The next two digit segment, 11, represents the month the unit was U-Line, you will be informed at the time the order is placed. It will be made. -
Page 8: Checking Product Temperature
• The number of door openings and the time the door is open. • The time the internal light is illuminated. (This mainly affects product on the top rack or shelf.) • The front grille or condenser are obstructed. U-Line Service... -
Page 9: System Default Values
Set Point Code Offset Length Interval U-1115RB-00 U-1115RS-00 U-1115RS-01 U-1175RB-00 U-1175RB-02 U-1175RB-13 U-1175RS-00 U-1175RS-01 U-1175RS-02 U-1175RS-13 U-1175RS-15 U-1175RW-00 U-1175RW-02 U-1175RW-13 U-1115WCB-00 U-1115WCB-02 U-1115WCS-00 U-1115WCS-02 U-1115WCS-09 U-1175WCB-00 U-1175WCB-02 U-1175WCB-13 U-1175WCS-00 U-1175WCS-02 U-1175WCS-13 U-1175WCS-15 U-1175BEVSS-00 U-1175BEVSS-02 U-1175BEVSS-13 U-1175BEVSS-15 U-ADA24RB-13 U-ADA24RGLB-13 U-ADA24RGLS-13 U-ADA24RGLS-15... -
Page 10: Interior Lighting
2. The interior light and control display (3) will go dark for the next 36 hours. 3. NOTE: Although the display will not be visible, the temperature controls in the unit remain active, and preserve the interior temperature. To exit the Blackout (Sabbath) Mode before the 36-hour period, repeat Step 1. U-Line Service... -
Page 11: 1000 Series Electronic Control
If desired, you can manually cancel this mode by When adjustment is complete stop touching the display and the set- touching the LIGHT button. Release and the unit will automatically point will be saved in approximately five seconds. start normal operation. U-Line Service... -
Page 12: 1000 Series Service Menu
15. Adjust thermistor 1 differential the display. Repeat if desired. Once viewed perform option 12 to This number should not be adjusted. clear the errors from memory. 16. Software number This will show the software on the board. U-Line Service... -
Page 13: Error Codes
. t i g i l e r i ADA24R 120V c t i s t l s f f g i l l a i g i l & - t i . n i U-Line Service... -
Page 14: Convection Cooling
• Remove 4 screws from inside of cover. • Remove evaporator fan and replace. • To assemble replace parts in reverse order. NOTICE Do not plug fan in until evaporator cover is in place. The wire could be pulled off of the fan motor. U-Line Service... -
Page 15: Standard Doors
2. Remove corresponding screws on opposite side of cabinet. On side of the cabinet. some models there may be a nut behind one or both screws on either side. Plastic Plastic Plug Hole Plug Hole Right Side Left Side Door Swing Door Swing U-Line Service... - Page 16 Install the grille, see MAINTENANCE section of this guide. 4. Remove the U-Line nameplate (3) from door. This will reveal mounting holes for the door actuator bracket. 5. Remove door actuator (4) from door. Be sure to only remove the two screws holding the actuator to the door.
-
Page 17: Maintenance
NOTICE 3. Some grilles are equipped with a plastic filler (2) on the non-hinge ALWAYS use a genuine U-Line replacement 120V 10 watt side. bulb (Part Number 31317) in the light housing. Use of any other bulb within the housing will produce excessive heat, causing damage to the light housing and cabinet interior, and will compromise the precise temperature control of the unit. -
Page 18: Wire Shelf Removal/Installation
Install shelf retention clip. Insert the shelves as follows: Reposition the shelf as required, ensure the raised white edge strip is toward the rear of the unit and graphics, if applied, are on the underside of the shelves. Wire Shelf Removal/Installation U-Line Service... -
Page 19: Removing And Installing Door Shelves
Ensure an even track engagement on both sides by gently pushing the rack into the cabinet until it stops. Before reloading the rack, ensure proper movement of the travel stops in the left and right track rails by pulling the rack out gently until it stops. U-Line Service... -
Page 20: Troubleshooting
• Is the door or drawers sealing properly? If the door or drawer is not sealed properly, it allows heat into the unit. U-Line’s warranty is 90 days for door or drawer adjustments. -
Page 21: Compressor Information
The hot high pressure gas is pumped out the discharge line and into the condenser. The cycle continues. EMI30HER EMU30HSC EMU40HNP Voltage Frequency Start Winding 21.20 COMPRESSOR Run Winding CONDENSER DRYER EVAPORATOR OVERLOAD PROTECTOR CAPILLARY TUBE STARTING RELAY RELAY COVER CAPACITOR (IF EQUIPPED) U-Line Service... -
Page 22: Refrigeration Systems
No refrigeration Lower than Restriction vacuum temperature temperature temperature temperature normal (cool) (cool) (cool) (cool) No Gas 0 PSIG Room Cool to hot Room Room No refrigeration Lower than to 25" temperature temperature temperature normal (cool) (cool) (cool) U-Line Service... -
Page 23: Thermistors
If the door or drawers are left open for longer than 5 minutes, the switch will trigger an error code and set an audible warning Magnet Away From Switch Magnet Close To Switch (Door Open) (Door Closed) (Switch Open) (Switch Closed) U-Line Service... -
Page 24: Service
Service Service Before Calling for Service If you think your U-Line product is malfunctioning, read the OPERATION section of this guide to understand clearly the function of the control. If the problem persists, read the NORMAL OPERATING SOUNDS and TROUBLESHOOTING GUIDE section of this guide to help you quickly identify common problems, and possible causes and remedies. -
Page 25: Cleaning
For best ® results use Claire Stainless Steel Polish and Cleaner, which can be purchased from U-Line Corporation (Part Number 173348). NOTICE Comparable products are acceptable. Frequent cleaning will The drain pan was not designed to capture the water remove surface contamination that could lead to rust. -
Page 26: Condenser Cleaning
RISK OF CHILD ENTRAPMENT. Before you throw away your old refrigerator or freezer, take off the doors and leave shelves in place so children may not easily climb inside. 3. Remove the cabinet door. 75 Models Typical Model Shown U-Line Service... -
Page 27: Product Information
E-mail: onlineparts@u-line.com BUILDING ON THREE GENERATIONS OF INNOVATION For nearly five decades and three generations, U-Line continues to be the leader in innovation, quality and value in the premium built-in undercounter ice making, refrigeration and wine preservation market. U-Line has captivated those with an appreciation for the finer things with exceptional functionality, style, inspired innovation and attention to even the smallest details.