FMI CD36RN Owner's Manual

Direct-vent

Hide thumbs Also See for CD36RN:

Owner's operation and installation manual (52 pages)

Owner's operation and installation manual (57 pages)

Table of Contents

Quick Links

DIRECT-VENT FIREPLACE

OWNER'S OPERATION AND INSTALLATION MANUAL

PFS

NATURAL GAS MODELS

(V)CD36RN, (V)CD36RNE

(V)CD36TN, (V)CD36TNE,

PROPANE/LP GAS MODELS

(V)CD36RP, (V)CD36RPE

(V)CD36TP, (V)CD36TPE

WARNING: If the information in this manual is not

— WHAT TO DO IF YOU SMELL GAS

For more information, visit www.fmiproducts.com

Table of Contents

Need help?

Do you have a question about the CD36RN and is the answer not in the manual?

Questions and answers

Summary of Contents for FMI CD36RN

Page 1 DIRECT-VENT FIREPLACE OWNER’S OPERATION AND INSTALLATION MANUAL ® NATURAL GAS MODELS NATURAL GAS MODELS (V)CD36RN, (V)CD36RNE (V)CD36TN, (V)CD36TNE, PROPANE/LP GAS MODELS PROPANE/LP GAS MODELS (V)CD36RP, (V)CD36RPE (V)CD36TP, (V)CD36TPE WARNING: If the information in this manual is not — WHAT TO DO IF YOU SMELL GAS...
Page 2 TABLE OF CONTENTS SAFETY State of Massachusetts: alteration, service or maintenance can cause for correct installation chemicals known to the State of California to cause cancer or additional information stalled in an aftermarket,* www.fmiproducts.com 116035-01K...
Page 3 SAFETY Continued adults away from hot surface to dren when they are in the room WARNING: Do not allow fans www.fmiproducts.com 116035-01K...
Page 4: Product Identification
SAFETY Continued Cleaning and Maintenance National Electrical Code, ANSI/NFPA 70. PRODUCT IDENTIFICATION Figure 1 - Top and Rear Direct-Vent Fireplaces LOCAL CODES National Fuel Gas Code ANSI Z223.1/NFPA 54* www.fmiproducts.com 116035-01K...
Page 5: Product Features
PRODUCT FEATURES PRE-INSTALLATION PREPARATION LOCATION AND SPACE REQUIREMENTS Figure 2 - Common Fireplace Locations www.fmiproducts.com 116035-01K...
Page 6 PRE-INSTALLATION PREPARATION Continued Figure 4 - Removing Collar Protector (Rear Vent Fireplace) CLEARANCES 25" (63.5 cm) 15" (38.1 cm) Mantel Clearances 36" (91.4 cm) Figure 3 - Fireplace Bottom Dimensions Note: On rear vent models you must remove venting system. See Figure 4. www.fmiproducts.com 116035-01K...
Page 7: Framing And Finishing
PRE-INSTALLATION PREPARATION Continued FRAMING AND FINISHING MANTEL CLEARANCES Accessories used and the face are sealed with Figure 5 - Framing Clearances for Installation Against an Exterior Wall THESE DIMENSIONS ALLOW FOR 1" OF CLEARANCE AT THE " (6.3 cm) SIDES AND BACK OF MIN.
Page 8 PRE-INSTALLATION PREPARATION Continued Outer Surround Combustible Material May Be Used " SAFE ZONE (3.8 cm) 6" 33° (15.2 cm) " (14 cm) " (9.5 cm) Perpendicular To Fireplace 12" Side Wall Opening (30.5 cm) Figure 8 - Side Clearances for Combustible Materials "...
Page 9: Location Of Termination Cap
LOCATION OF TERMINATION CAP Fixed Openable Fixed Closed Closed Openable TERMINATION CAP GAS METER RESTRICTED AREA AIR SUPPLY INLET (TERMINATION PROHIBITED) A = clearance above grade, veranda, porch, deck, or I = clearance to service regulator vent outlet [*72" (182.9 cm) balcony [*12"...
Page 10: Requirements For The Commonwealth Of Massachusetts
REQUIREMENTS FOR THE COMMONWEALTH OF MASSACHUSETTS INSPECTION MONOXIDE DETECTORS MANUFACTURER REQUIREMENTS Provided SIGNAGE www.fmiproducts.com 116035-01K...
Page 11: Venting Installation
VENTING INSTALLATION NOTICE: Read these instruc- NOTICE: Failure to follow these in- NOTICE: Do not seal termination INSTALLATION PRECAUTIONS WARNING: Read all instruc- on the horizontal sections, Failure to do so could result in IMPORTANT: www.fmiproducts.com 116035-01K...
Page 12: Installation Planning
VENTING INSTALLATION Continued INSTALLATION PLANNING Horizontal Termination Installation IMPORTANT Figure 11 - Vent Pipe Connections Vent Opening Combustible Wall " Inside Framing (29.2 cm) " (29.2 cm) " (29.2 cm) Twist-Lock Procedure: (Framing Detail) Vent Opening Noncombustible Wall " (21.6 cm) IMPORTANT: Figure 12 - Vent Opening Requirements www.fmiproducts.com...
Page 13 VENTING INSTALLATION Continued WARNING: Do not recess Figure 13 - Installing Horizontal Vent Cap (Noncombustible Exterior) sidings (see Figure 13). Figure 14 - Installing Siding Standoff (Combustible Exterior Wall) IMPORTANT: Figure 15 - Installing Outer Wall Firestop (Combustible Exterior Wall) www.fmiproducts.com 116035-01K...
Page 14 VENTING INSTALLATION Continued NOTICE: Do not seal termination WARNING: Never run vent downward as this may cause IMPORTANT Figure 16 - Installing Inner Wall Firestop Figure 17 - Typical Horizontal Termination Cap Mounting with Additional Siding Standoff Installed Figure 18 - Horizontal Termination (Model (V)CD36R) www.fmiproducts.com 116035-01K...
Page 15 VENTING INSTALLATION Continued Corner Installation Corner Installation Figure 21 - Horizontal Termination Figure 19 - Horizontal Termination Using One 90° Elbow (Model (V)CD36T) (Model (V)CD36R) Figure 20 - Horizontal Termination (Model (V)CD36T) GROUND FLOOR INSTALLATION Figure 22 - Horizontal Termination 90°...
Page 16 VENTING INSTALLATION Continued Horizontal (H (Model (V)CD36T) www.fmiproducts.com 116035-01K...
Page 17 VENTING INSTALLATION Continued Horizontal (H (Model (V)CD36T) TERMINATION all vertical installations. WS-58 OSR58-30 (305 Figure 26 - 45° and 30° Offset with Wall Strap www.fmiproducts.com 116035-01K...
Page 18 VENTING INSTALLATION Continued 1.5" 1" 3" Offset 1" Clearance 1" 20° Offset 3.5" 1.5" Clearance Figure 27 - OSR58-30 Offset and Return for (V)CD36T Series Units Figure 28 - Installing Firestop www.fmiproducts.com 116035-01K...
Page 19 VENTING INSTALLATION Continued Note: Install a VR-58 vertical restrictor ring attaching vent Note: Install a VR-58 vertical restrictor ring attaching vent Horizontal Horizontal (H Note: Figure 29 - Vertical Venting (Model (V)CD36R with Vertical Round Figure 30 - Vertical Venting High Wind Termination) (Model (V)CD36R with Vertical Round High Wind Termination)
Page 20 VENTING INSTALLATION Continued Note: Install a VR-58 vertical restrictor ring Note: Install a attaching vent VR-58 vertical restrictor ring attaching vent termination Figure 32 - Vertical Venting (Model (V)CD36T with Vertical Round High Wind Termination) Horizontal Note: Install a VR-58 vertical restrictor ring Horizontal (H Horizontal (H...
Page 21 VENTING INSTALLATION Continued Note: Install a VR-58 vertical restrictor ring attaching vent WS-5 8 Note: Install an OSR58-30 30° as necessary to maintain 1" Clearance to all Figure 34 - Vertical Venting (Model (V)CD36T with Vertical Round High Wind Termination) AND COMPONENTS OSR58-30 www.fmiproducts.com...
Page 22: Electrical Supply Connection
FIREPLACE INSTALLATION ELECTRICAL SUPPLY CONNECTION CAUTION: Disconnect the of local code, with the current National Electric Code, ANSI/ NFPA 70. ACCESSORIES electrical outlet installed in the to do this may result in serious Figure 35 - Relocating Junction Box Receptacle and Electrical Supply Connection www.fmiproducts.com 116035-01K...
Page 23 FIREPLACE INSTALLATION Continued Figure 36 - Blower Model BK Figure 37 - Attaching Speed Control to Firebox (Millivolt Models) Figure 38 - Attaching Speed Control to Firebox (Electronic Models) www.fmiproducts.com 116035-01K...
Page 24 FIREPLACE INSTALLATION Continued Figure 39 - Location of Wiring Diagram Decal (Model May Vary From Illustration) nections securely. Figure 40 - Blower Model BKT www.fmiproducts.com 116035-01K...
Page 25: Wiring Diagrams
FIREPLACE INSTALLATION Continued Pilot Burner Ignitor Lead Orange Transformer Gas Valve Black Black Black Ground Blue Blue Green Figure 43 - Electronic Ignition Wiring Diagram WIRING DIAGRAMS INSTALLING OPTIONAL WALL Variable Fan Switch Fan Switch (N.O.) Black 110/115 Blue V.A.C. Black Blower IMPORTANT:...
Page 26 FIREPLACE INSTALLATION Continued INSTALLING OPTIONAL WIRELESS Held Remote Control Unit HAND-HELD REMOTE CONTROL Figure 47 - Installing Battery in Hand- Held Remote Control Unit INSTALLING OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL FOR ELECTRONIC IGNITION Figure 45 - Attaching Alkaline Battery to Receiver REMOTE ON OFF Towards Front...
Page 27: Installing Gas Piping To Fireplace Location
FIREPLACE INSTALLATION Continued Accessories INSTALLING GAS PIPING TO FIREPLACE LOCATION Figure 49 - Installing Battery Into Handset WRC HIGH ALTITUDE INSTALLATION Installation Items Needed IMPORTANT: www.fmiproducts.com 116035-01K...
Page 28: Connecting Fireplace To Gas Supply
FIREPLACE INSTALLATION Continued CAUTION: Use only new, Natural IMPORTANT: CONNECTING FIREPLACE TO GAS SUPPLY Installation Items Needed Figure 50 - External Regulator with Vent Pointing Down (Propane/LP Only) www.fmiproducts.com 116035-01K...
Page 29 FIREPLACE INSTALLATION Continued to Millivolt Valve and connections, internal and external to unit, for leaks after WARNING: Never use an Figure 53 - Equipment Shutoff Valve PRESSURE TESTING GAS SUPPLY PIPING SYSTEM www.fmiproducts.com 116035-01K...
Page 30 FIREPLACE INSTALLATION Continued PRESSURE TESTING FIREPLACE GAS CONNECTIONS Figure 56 - Removing Lower Louver Access Panel DOOR Replacement Parts Figure 57 - Removing Top Louver Trim Panel www.fmiproducts.com 116035-01K...
Page 31 FIREPLACE INSTALLATION Continued Note Figure 59 - Installing Logs Door www.fmiproducts.com 116035-01K...
Page 32: For Your Safety
FIREPLACE INSTALLATION Continued Figure 60 - Applying Ember Material OPERATION FOR YOUR SAFETY WARNING: If you do not fol- low these instructions exactly, WHAT TO DO IF YOU SMELL GAS MILLIVOLT MODELS LIGHTING INSTRUCTIONS Figure 61 - Control Valve www.fmiproducts.com 116035-01K...
Page 33: Manual Lighting Procedure
OPERATION Continued MILLIVOLT MODELS Lighting Instructions Removing/Re- OPTIONAL HAND-HELD REMOTE OPERATION Note: All remote control accessories must Accessories, the remote control. Lighting Instructions TO TURN OFF GAS TO APPLIANCE hand-held remote control unit. IMPORTANT: MANUAL LIGHTING PROCEDURE Removing/Re- Figure 62 - Setting the Selector Switch, Lighting Instructions Knob for Remote Operation...
Page 34 OPERATION Continued MILLIVOLT MODELS Safety Features Auto Shutoff Feature Figure 63 - On/Off Hand-Held Remote Control Unit HRC100 Manual Mode AUTO ROOM TEMP TEMP TEMP LOCK POWER MANU AUTO ºC/ºF AUTO Figure 64 - Thermostat Hand-Held Remote Control Unit HRC200 www.fmiproducts.com 116035-01K...
Page 35 OPERATION Continued MILLIVOLT MODELS OPERATING OPTIONAL OPERATING OPTIONAL THERMOSTAT WARNING: Do not con- Lighting Instructions IMPORTANT: ELECTRONIC IGNITION MODELS LIGHTING INSTRUCTIONS Figure 65 - Turning Equipment Shutoff Valve to the OFF Position Figure 66 - Pilot www.fmiproducts.com 116035-01K...
Page 36: To Turn Off Gas To Appliance
OPERATION Continued ELECTRONIC IGNITION MODELS OPERATING OPTIONAL THERMOSTAT WARNING: Do not con- Lighting Instructions TO TURN OFF GAS TO APPLIANCE OPTIONAL WIRELESS IMPORTANT: REMOTE OPERATION OPERATING OPTIONAL rately (see Accessories remote control. IMPORTANT: IMPORTANT: Figure 67 - Control Knob and Variable Control Knob for Remote Operation www.fmiproducts.com 116035-01K...
Page 37: Inspecting Burners
INSPECTING BURNERS Cleaning and Maintenance Figure 70 - Typical Flame Pattern Figure 68 - Pilot Assembly (Millivolt) Figure 69 - Pilot Assembly (Electronic) www.fmiproducts.com 116035-01K...
Page 38: Cleaning And Maintenance
CLEANING AND MAINTENANCE (see Replacement Parts GLASS DOOR CAUTION: Do not vacuum if ment Parts Remov- unlatched, removed, cracked www.fmiproducts.com 116035-01K...
Page 39: Troubleshooting
CLEANING AND MAINTENANCE Continued LOGS Installing Logs, Parts TROUBLESHOOTING REMEDY www.fmiproducts.com 116035-01K...
Page 40 TROUBLESHOOTING Continued REMEDY Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance www.fmiproducts.com 116035-01K...
Page 41 TROUBLESHOOTING Continued REMEDY Cleaning and Maintenance Cleaning and Maintenance Cleaning and Maintenance www.fmiproducts.com 116035-01K...
Page 42 TROUBLESHOOTING Continued REMEDY Light- ing Instructions, Cleaning and Maintenance Installation Plan- ning Install- www.fmiproducts.com 116035-01K...
Page 43: Electronic Ignition
TROUBLESHOOTING ELECTRONIC IGNITION REMEDY Note: www.fmiproducts.com 116035-01K...
Page 44 TROUBLESHOOTING Continued REMEDY See Warn- tions See Warn- www.fmiproducts.com 116035-01K...
Page 45: Specifications
SPECIFICATIONS REPLACEMENT PARTS SERVICE HINTS TECHNICAL SERVICE When Gas Pressure Is Too Low www.fmiproducts.com 116035-01K...
Page 46 PARTS www.fmiproducts.com 116035-01K...
Page 47 PARTS DESCRIPTION 116108-01 1-1 116109-01 1-2 116110-01 1-3 111802-05 1-4 111802-04 115615-01 114889-01 114880-01 114875-01 114875-02 114876-01 114876-02 114873-01 114872-01 114871-01 110973-01 24460 21171 14418 14123 11408 26290 25580 27253 55240 www.fmiproducts.com 116035-01K...
Page 48 PARTS www.fmiproducts.com 116035-01K...
Page 49 PARTS DESCRIPTION 116317-01 114886-01 108085-01 108085-02 108085-03 108084-02 108084-05 108084-03 27206 26482 26808 24389 24360 14500 14399 14396 14389 117370-01 14390 14299 14261 11226 11214 11187 11107 11105 11102 www.fmiproducts.com 116035-01K...
Page 50 PARTS www.fmiproducts.com 116035-01K...
Page 51 PARTS DESCRIPTION 116719-01 116719-02 116719-03 116316-01 114886-01 111059-03 110286-01 108863-01 108867-01 108867-02 108866-01 108866-02 27206 26482 26808 24389 24360 14569 14570 14500 14399 14396 14299 14129 11404 11226 11214 11201 11186 11187 11109 11107 11105 11102 www.fmiproducts.com 116035-01K...
Page 52 ACCESSORIES NOTE: All accessories may PROPANE/NATURAL GAS Note: Not Intended For Use With High- Altitude Models (V)CD36RN-HA or (V)CD36TN-HA THERMOSTATICALLY - THERMOSTAT REMOTE CONTROL SERIES WALL MOUNTED THERMOSTAT WALL MOUNTED ON/OFF SWITCH www.fmiproducts.com 116035-01K...
Page 53 NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ www.fmiproducts.com 116035-01K...
Page 54 NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ www.fmiproducts.com 116035-01K...
Page 55 NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ www.fmiproducts.com 116035-01K...
Page 56: Warranty
WARRANTY KEEP THIS WARRANTY _____________________________ __________________________ __________________________ FMI PRODUCTS, LLC LIMITED WARRANTIES New Products Standard Warranty: Factory Reconditioned Products Limited Warranty: Terms Common to All Warranties 116035-01 1-866-328-4537 www.fmiproducts.com...

This manual is also suitable for:

Cd36rpe Cd36rne Vcd36rp Vcd36rpe Cd36tn Cd36tne ... Show all

FMI CD36RN Owner's Manual

Quick Links

Need help?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for FMI CD36RN

Summary of Contents for FMI CD36RN

This manual is also suitable for:

Table of Contents