Bunn ITCB Single Series Daily Cleaning Instructions

AIRPOT
STEP 1
Open the airpot by pressing
the buttons located on either
side of the nozzle and lifting.
Remove the pump tube as-
sembly.
BREWER
STEP 1
Once a day, clean and sanitize
the brew funnels, funnel tips
and screen assemblies.
STEP 6
Thoroughly clean the entire
inside surface of the dis-
penser and the faucet shank
using a small brush (BOM
#00674.0000) mild detergent
and water solution. Thor-
oughly rinse the dispenser
with clean water.
DO NOT KEEP BREWED BEVERAGES OVERNIGHT
45917.0000A 03/12 ©2012 Bunn-O-Matic Corporation
ITCB & ITCB-HV SINGLE/TWIN SERIES
DAILY CLEANING INSTRUCTIONS
STEP 2
Thoroughly rinse the entire
server.
TEA RESERVOIR
STEP 1
Once a day, turn the faucet in
a counterclockwise direction
and remove the faucet from
the dispenser. Unscrew the
faucet cap from the faucet
body and disassemble all
faucet parts.
STEP 7
Prepare a sanitizer solu-
tion in a clean bucket (1/4
gallon). Use a commercial
sanitizer that has 50-100 ppm
of available chlorine with a
concentration level of at least
3% available chlorine (KAY-5
Sanitizer). Follow the mixing
instructions to ensure 100
ppm of available chlorine.
TF SERVER
STEP 1
Remove the lid, fi ll server
with cleaning solution and
thoroughly clean the inside
of server.
STEP 2
Transfer these parts to a three
compartment sink for clean-
ing. Fill the fi rst sink with a
soap solution using a mild
detergent, the second sink
is used for clean rinse, and
the third sink with a sanitizer
solution (75°F warm chlorine
solution of at least 50-100
ppm).
STEP 8
Pour a small amount of
sanitizer solution into the
dispenser. Use a bristle
brush (BOM #00674.0000)
to clean all the way through
the faucet shank. Repeat
several times.
STEP 2
Rinse server thoroughly using
fresh water rinse.
STEP 3
Use a bristle brush (BOM
#00674.0000) to thoroughly
scrub the faucet body.
STEP 9
Thoroughly rinse the dis-
penser with clean water. Al-
low the dispenser to air dry
over night
STEP 3
Fully fi ll server with sanitiz-
ing solution for 5 minutes
then drain through fully open
faucet.
STEP 4
Allow the parts to soak in a
sanitizer solution for a mini-
mum of ten minutes.
Remove the faucet parts from
the sanitizer solution and rinse
thoroughly. Allow parts to air
dry over night.
STEP 10
Assemble the faucet compo-
nents and attach the faucet
to the dispenser turning
clockwise.
45917 012512