Table of Contents
Advertisement
User's Manual & Operating Instructions
Model Numbers
HH-150T-DFV / HH-220T-DFV
CONSUMER: READ AND SAVE THESE INSTRUCTIONS
GENERAL HAZARD WARNING:
DANGER
READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL
BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER. Be sure to comply with the
instructions and warnings provided with this heater. Failure to comply can result in fire or explosion
that can cause property loss, bodily injury, or loss of life. Only persons who can follow and
understand these instructions should operate or service this heater. If you need heater info; such as
an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996.
NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES
DANGER
WITHOUT ADEQUATE VENTILATION. INDOOR USE PERMITTED ONLY FOR
THE TEMPORARY HEATING OF BUILDINGS OR STRUCTURES UNDER CONSTRUCTION,
ALTERATION OR REPAIR. This is an unvented portable heater that uses air (Oxygen) from within
the area in which it is used. Failure to provide adequate combustion and ventilation air will result in
asphyxiation, carbon monoxide poisoning, bodily injury or death. Refer to "Ventilation" on Page 6.
668 Stony Hill Road #302 Yardley, PA 19067 USA
Fax: (215)-891-8461
HEATER SHOWN WITHOUT SAFETY GUARD. PLEASE
ATTACH SAFETY GUARD BEFORE USING HEATER.
© 2014 Pinnacle Products International, Inc.
• Web: www.remingtonheater.com • Email: info@pinnacleint.com
Toll Free (800)-641-6996
•
Advertisement
Table of Contents
Related Manuals for Remington HH-150T-DFV
Summary of Contents for Remington HH-150T-DFV
- Page 1 User’s Manual & Operating Instructions Model Numbers HH-150T-DFV / HH-220T-DFV HEATER SHOWN WITHOUT SAFETY GUARD. PLEASE ATTACH SAFETY GUARD BEFORE USING HEATER. CONSUMER: READ AND SAVE THESE INSTRUCTIONS GENERAL HAZARD WARNING: DANGER READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER.
-
Page 2: Table Of Contents
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Table Of Contents Safety Information..........1-2 Wiring Diagram..........10 Features and Specifications.........3 Troubleshooting Guide........11 Assembly............4-5 Exploded View...........12 Operation............6-7 Parts List............13-14 Ventilation.............6 Warranty.............15 Storage..............8 Safety Information FIRE, BURN, INHALATION AND EXPLOSION HAZARD. Keep combustibles such WARNING as;... -
Page 3: Safety Information
Keep all combustible materials away from this heater. serviced and check for proper ventilation. Some people are more affected by carbon monoxide Minimum Clearance From Combustibles than others. These include: pregnant women, HH-150T-DFV HH-220T-DFV those with heart or lung problems, anemia or those 4 ft. 4 ft. -
Page 4: Features And Specifications
Volts: AC/Hz 120VAC ~ 60 Hz 120VAC ~ 60 Hz Amps Phase 1Ø 1Ø Specifications subject to change without notice. Features Models: HH-150T-DFV / HH-220T-DFV Shell Control Panel Front Safety Guard Rear Guard Rear Handle Power Cord Support Frame Front Handle... -
Page 5: Assembly Instructions
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Model: HH-150T-DFV / HH-220T-DFV Remove the heater and all packaging Tools Needed: materials from the shipping carton. - Phillips Head Screw Driver - 8 mm open end wrench... - Page 6 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Assembly Instructions Models: HH-150T-DFV / HH-220T-DFV 1. Insert axle through holes in wheel support. 2. Slide then spacer onto axle. 3. Slide wheel onto axle with the air valve facing Handle out and hold in place with the axle nuts.
-
Page 7: Operation
THE HEATER IS ON LEVEL GROUND WHEN FUELING, AND NEVER OVERFILL THE TANK. Minimum Ventilation Opening Needed DO NOT USE GASOLINE OR HH-150T-DFV HH-220T-DFV WARNING CRANKCASE DRAININGS. 5.3 ft.² 6.5 ft.²... - Page 8 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Operation Starting the Heater: (Ignition) Control Panel: 1. Fill the tank with kerosene or other approved fuel until needle on fuel gauge points to “F”. 2. Replace fuel cap and tighten firmly. 3.
-
Page 9: Storage
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Long Term Storage: Service: Never service heater while it is WARNING 1. Drain fuel through the drain plug in the bottom plugged in or hot! of the fuel tank. 2. - Page 10 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance Service (Continued): SPARK PLUG: FAN BLADES: Clean and re-gap every 600 hours of operation, or Blades should be cleaned at least once per replace as needed. After removing the spark plug, heating season, depending on conditions.
-
Page 11: Wiring Diagram
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Maintenance NOZZLES: Nozzles should be cleaned or replaced at least once per heating season. Contaminated fuel could make this necessary immediately. To clean dirt from nozzle, blow compressed air through nozzle front. -
Page 12: Troubleshooting Guide
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Troubleshooting Guide Locating Your Serial Number: Your serial number can be found on a white label on the right side cover of your heater. It will begin with 2 digits, the letter “H”... -
Page 13: Exploded View
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Exploded View © 2014, Pinnacle Products International, Inc. Dual Fusion Forced Air Heater User’s Manual... -
Page 14: Parts List
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Parts List Item # Description HH-150T-DFV HH-220T-DFV Front Shell 70-001-5100 70-001-5105 Upper Shell 70-001-5010 70-001-5010 Combustion Chamber 70-011-1000 70-011-1010 Control PCB 70-027-1000 70-027-1000 Power PCB Case 70-027-1250... - Page 15 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE Parts List Item # Description HH-150T-DFV HH-220T-DFV Fuel Gauge 70-007-0215 70-007-0216 Fuel Cap 70-006-0120 70-006-0120 Fuel Tank 70-002-1000 70-002-1100 Fuel Filter 70-003-1000 70-003-1000 Drain Plug 70-002-0105 70-002-0105...
-
Page 16: Limited Warranty
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE LIMITED WARRANTY Pinnacle Products International, Inc. warrants this heater If Pinnacle Products International, Inc. finds the item to to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect. - Page 17 © 2014 Pinnacle Products International, Inc. 668 Stony Hill Road #302 Yardley, PA 19067 USA • Toll Free (800)-641-6996 Fax: (215)-891-8461 • Web: www.pinnacleint.com • Email: info@pinnacleint.com...