Table of Contents
Advertisement
Model #s: HH-45-KFA, HH-70T-KFA,
HH-125T-KFA, HH-175T-KFA, HH-215T-KFA
IMPORTANT: Read and understand all of the directions in this manual before assembling,
starting, or servicing the heater. Improper use of this heater can cause serious injury. Keep this
manual for future reference.
GENERAL HAZARD WARNING:
DANGER
Be sure to comply with the instructions and warnings provided with this heater, or death,
serious bodily injury and property loss, damage from the hazards of fire, explosion, burn,
asphyxiation, and carbon monoxide poisoning can result.
Only persons who can follow and understand these instructions should use or service this
heater. If you need heater information such as an instruction manual, labels, etcetera, contact
the manufacturer.
Not for use in residential living areas or in non-adequately ventilated enclosed
DANGER
spaces.
Pinnacle Products International, Inc. 668 Stony Hill Road #302 Yardley, PA 19067 USA
Phone: 215-891-8460 Fax: 215-891-8461 Web: www.pinnacleint.com Email: info@pinnacleint.com
User's Manual and
Operating Instructions
CONSUMER: Retain this manual for future reference.
Kerosene
Forced Air Heaters
701000290-09
Advertisement
Table of Contents
Related Manuals for Remington HH-45-KFA
Summary of Contents for Remington HH-45-KFA
- Page 1 Kerosene User’s Manual and Forced Air Heaters Operating Instructions Model #s: HH-45-KFA, HH-70T-KFA, HH-125T-KFA, HH-175T-KFA, HH-215T-KFA CONSUMER: Retain this manual for future reference. IMPORTANT: Read and understand all of the directions in this manual before assembling, starting, or servicing the heater. Improper use of this heater can cause serious injury. Keep this manual for future reference.
-
Page 2: Table Of Contents
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Table of Contents Safety Information Safety Information ..........2-3 Indicates an imminently hazardous DANGER situation which, if not avoided, WILL Features ..............3 result in death or serious injury. -
Page 3: Safety Information
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Safety Information (Continued) Never use this heater in living or sleeping areas. NEVER use this heater where flammable vapors may be NEVER refill the heater’s fuel tank while heater is operating or present. -
Page 4: Specifications
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Specifications Model # HH-45-KFA HH-70T-KFA HH-125T-KFA HH-175T-KFA HH-215T-KFA Rating BTU/Hr 45,000 70,000 125,000 175,000 215,000 Fuel Consumption Gal/Hr 0.35 0.53 1.34 1.63 Fuel Tank Capacity 10.0... -
Page 5: Unpacking
Remove the heater and all of the packaging materials from the missing, call 215-891-8460 for assistance in receiving the miss- shipping carton. ing components. NOTE: Save the box and packaging materials for future storage. Assembly HH-45-KFA HH-70T-KFA HH-125T-KFA HH-175T-KFA HH-215T-KFA Wheel support frame Wheel (2 pieces) Front and Rear Handle... -
Page 6: Assembly
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Assembly Continued) ASSEMBLING CORDWRAP MODELS HH-45/70T-KFA ONLY 1. Align holes in cordwrap with corresponding holes in front han- dle. Insert screws (B) through holes, attach nuts and tighten - Tools required: Medium phillips screw driver. -
Page 7: Fuels
F. Push the Power switch to the “ON” position (See figure 9). The power indicator lamp and room temperature display (125/175/215 only) will light and the heater will start. Model HH-45-KFA does not have a thermostat NOTE: The room temperature display (125/175/215 only) will WARNING indicate the following: - When temperature is less than 0 °... -
Page 8: Operation
Drain Plug at the bottom of the Fuel Tank. Control Knob 2. To remove the Drain Plug (125/175/215),pull the Plug Grip Model HH-45-KFA Models HH-70T / 125T / 175T / 215T-KFA downward and remove seal head from drain hole in tank (See Figure 11). -
Page 9: Maintenance
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE NOZZLES: Store heater in a dry, well-ventilated area Nozzles should be cleaned or replaced at least once per heating Be sure that the storage area is free of dust and corrosive season. - Page 10 NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Maintenance (Continued) SPARK PLUG: Clean and re-gap every 600 hours of operation, or replace as needed.After removing the Spark Plug, clean the terminals with a wire brush.
- Page 11 While heater is operating, turn relief valve clockwise to increase, counterclockwise to decrease (see Figure 20). Use flat blade screwdriver to turn valve. Correct pump pressure is as follows: Adjusting Model # Pump Pressure Screw HH-45-KFA 3.0 PSI HH-70T-KFA 4.0 PSI HH-125T-KFA 5.0 PSI HH-175T-KFA 7.5 PSI...
-
Page 12: Exploded Parts Drawing
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Exploded Drawing Part Breakdown (HH-125 / 175 / 215T-KFA only) (HH-125 / 175 / 215T-KFA only) (HH-40 / 70T-KFA only) (HH-125 / 175 / 215T-KFA only) (HH-125 / 175 / 215T-KFA only) 5 42... -
Page 13: Replacement Part Listing
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE Ref. Part Number for Models: Description HH-45-KFA HH-70T-KFA HH-125T-KFA HH-175T-KFA HH-215T-KFA Fuel Tank Assembly 70-002-0100 70-002-0100 70-002-0200 70-002-0300 70-002-0300 Drain Plug –... -
Page 14: Wiring Diagrams
MOTOR02 FAN 2 ACN2 ACN 1 CN2 R-TH ACN2 ACN 1 BLACK Figure 23 Model HH-70T-KFA Figure 22 Model HH-45-KFA MOTOR01 MOTOR02 ACN2 CN2 R-TH ACN 1 BLACK Figure 24 Model HH-125T/ 175T/ 215T-KFA Page 14 Pinnacle Products International, Inc. Kerosene User’s Manual... -
Page 15: Troubleshooting
1. Thermostat is set too low (Does not 1. Rotate thermostat to a higher setting plugged in and Power Switch is in the apply to HH-45-KFA) “ON” position. The lamp is flickering or 2. Inspect all electrical connections. See 2. Broken electrical connection between on and LED Display shows “E1”... -
Page 16: Limited Warranty
NEVER LEAVE HEATER Kerosene UNATTENDED WHILE BURN- ING OR WHILE CONNECTED Forced Air Heaters TO A POWER SOURCE LIMITED WARRANTY AFTER THE PERIOD OF THE ONE (1) YEAR EXPRESS WARRANTY EXPIRES, Pinnacle Products International, Pinnacle Products International, Inc. warrants this Inc.