Table Of Contents - Quadra-Fire MTVERNON-AE-CSB Installation Manual

MT. VERNON AE
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided may result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, may result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information .............3
1
A. Appliance Certifi cation ......................................................3
B. BTU & Effi ciency Specifi cations........................................3
C. Glass Specifi cations .........................................................3
D. Electrical Rating................................................................3
E. Mobile Home Approved .................................................... 3
Getting Started ....................................4
2
A. Design, Installation & Location Considerations ..........................4
B. Thermostat Wall Control Location......................................5
C. Tools And Supplies Needed ..............................................5
D. Inspect Appliance and Components .................................5
E. Install Checklist ..................................................................6
Dimensions and Clearances ..............7
3
A. Appliance Dimensions ......................................................7
B. Clearances to Combustibles (UL and ULC) .......................8
C. Hearth Pad Requirements (UL and ULC) ..........................8
Vent Information ..................................9
4
A. Venting Termination Minimum Requirements ...................9
B. Avoiding Smoke and Odors ...............................................10
C. Negative Pressure .............................................................11
D. Draft ........ ..........................................................................11
E. Chimney and Exhaust Connection ...................................11
F. Equivalent Feet of Pipe .....................................................12
G. Pipe Selection Chart .........................................................12
2

TABLE OF CONTENTS

300 Watt Igniters come installed in brand new Mt. Vernon AE
units and are for pellet fuel only. The 380 Watt Igniter is required
for burning multi-grain fuels and is included in the component
pack. Multi-fuels include, corn, sunfl ower seeds, and wheat.
7034-277E
Venting Systems ...............................13
5
A. Alcove ..............................................................................13
B. Through The Wall .............................................................14
C. Vertical into Existing Class A Chimney .............................15
D. Through The Wall & Vertical - Exterior ..............................15
E. Vertical - Interior - Typical Installation ................................15
F. Masonry.............................................................................16
G. Alternate Masonry ............................................................16
Appliance Set-Up ..............................17
6
A. Leg Leveling System .......................................................17
B. Outside Air Kit Instructions ................................................17
C. Top Vent Adapter Installation ............................................18
D. Rear Vent & Rear Vent to Top Vent Adapter Installation ....18
E. Optional Log Set Placement Instructions ..........................19
F. Wall Control Thermostat Installation .................................20
Mobile Home Installation ..................21
7
Accessory List ..................................22
8
May 5, 2015