Refueling - Ford TRANSIT Owner's Manual

6. Remove the spout from the diesel
exhaust fluid container and replace the
cap.
Note: If there is diesel exhaust fluid left in
the container retain it for later use. The
spout is re-useable. Wash the spout with
clean water prior to storage. Do not use the
diesel exhaust fluid spout with any other
fluid.
Filling the Diesel Exhaust Fluid Tank in
Cold Climates
Diesel exhaust fluid may freeze if the
ambient temperature is below 12°F (-11°C).
Your vehicle has a preheating system
which allows diesel exhaust fluid to
operate below 12°F (-11°C). If you do not
use your vehicle for an extended period
when the ambient temperature is below
12°F (-11°C), the fluid in the tank may
freeze. If the tank is overfilled and the fluid
freezes it may damage the tank. This is not
covered by the vehicle warranty.
Inoperative Selective Catalytic
Reduction System, Poor Quality or
Contaminated Diesel Exhaust
Fluid
If the system becomes
contaminated or inoperative, the
diesel exhaust fluid warning
lamp will illuminate and a message will
appear in the information display. See
Information Messages (page 68).
Note: To service a contaminated or
inoperative system, see an authorized
dealer.
Transit (TTG) Vehicles Built From: 26-01-2015, CG3612en enGBR, Edition date: 12/2014, First Printing
Fuel and Refueling

REFUELING

Never smoke or use a cell phone while
refueling. Fuel vapor is extremely
hazardous under certain conditions. Avoid
inhaling excess fumes.
fuel to drain into the fuel tank.
the expansion space in the fuel tank which
could lead to fuel overflowing.
process.
and fire.
Do not attempt to start the engine if you
have refueled the fuel tank with the
incorrect fuel. This can cause damage not
covered by the vehicle warranty. Have your
vehicle checked by an authorized dealer
immediately.
If you use a high pressure spray to wash
your vehicle, only spray the fuel filler door
briefly from a distance not less than 8 in
(200 mm).
104
WARNINGS
When refueling always shut the
engine off and never allow sparks or
open flames near the filler neck.
Wait at least 10 seconds before
removing the fuel pump nozzle from
the filler neck to allow any residual
Stop refueling after the fuel pump
nozzle automatically shuts off for the
second time. Additional fuel will fill
Do not remove the fuel pump nozzle
from its fully inserted position in the
filler neck during the entire refueling
Do not overfill the fuel tank. The
pressure in an overfilled tank may
cause leakage and lead to fuel spray