Starting Generator - Honeywell HW7500E Owner's Manual

Preparing for Operation

Starting Generator

WARNING
Before starting generator, be sure to thoroughly read
all information provided in this Owner's Manual.
NOTICE
It is very important to maintain proper level of engine oil to
keep engine in good running condition.
• Check engine oil level prior to each use.
Starting generator with appliances connected can cause
permanent damage to appliances.
• NEVER start generator with electrical appliances
plugged in and turned on.
Electric Start
1. Be sure generator is placed outside, in well-ventilated
area.
NOTICE
Keep the generator at a minimum of 6 feet (2 meters) from
any building, object, or wall.
Confirm the circuit breakers are set.
2.
Set
FIGURE 21: Circuit Breaker Position
Turn fuel valve to ON position.
3.
FIGURE 22: Fuel Valve Lever — ON/OFF position
Move choke control to ON position.
4.
ON
OFF
FIGURE 24: Choke Lever
16 www.honeywellgenerators.com
Tripped
Press and hold engine control switch in START posi-
5.
tion until engine starts.
ENGINE
FIGURE 25: Engine Control Switch
NOTICE
If engine will not start, move the choke to the OFF posi-
tion to reduce fuel to the engine.
NOTICE
• Holding engine control switch for more than 5 seconds
can damage starter motor. If engine fails to start after 5
seconds, release engine start switch and wait 10 sec-
onds before attempting to start engine again.
• If you notice engine cranking speed drop after a period
of time, it may be an indication that battery should be
recharged.
6. When the engine starts, release the engine control
switch allowing it to settle to the RUN (center) posi-
tion.
CAUTION
To avoid generator damage, NEVER press the engine con-
trol switch to the START position while generator is running.
7. As engine warms up, and RPM stabilizes, gradually
push choke control to OFF position.
NOTE:
While engine is running, a small "trickle" charge is applied
to starting battery.This keeps an adequate battery charge.
HW7500E/HW7500EL Portable Electrical Generator Owner's Manual
START
STOP