Portable Electrical Generator Owner’s Manual Manual del Propietario HW7000EH Read and Save These Instructions - Lea y Conserve Estas Instrucciones For product inquiries or support, visit www.honeywellgenerators.com or call toll-free at 1-888-HWHELP1 (494-3571). Si tiene preguntas acerca de los productos o requiere de asistencia, visite...
Page 2
Congratulations on owning a Honeywell portable generator! This manual contains important instructions for operating this generator. For your safety and the safety of others, read this manual thoroughly before operating the generator. Failure to properly follow all instructions and precautions can cause you and others to be seriously hurt or killed.
PHONE COUNTRY EMAIL CHECK HERE TO RECEIVE ANNUAL MAINTENANCE REMINDERS AND SPECIAL OFFERS FROM HONEYWELL GENERATORS CHECK HERE TO RECEIVE INFORMATION FROM OTHER COMPANIES VIA EMAIL, UNDERSTANDING YOUR EMAIL ADDRESS MAY BE SHARED OR COMBINED WITH INFORMATION FROM OTHER SOURCES...
Page 4
3 - DEMOGRAPHIC INFORMATION GENDER: HOUSEHOLD INCOME: MALE LESS THAN $15,000 $100,000 - $124,999 FEMALE $15,000 - $29,999 $125,000 - $149,999 $30,000 - $49,999 $150,000 - $174,999 MARITAL STATUS: $50,000 - $79,999 $175,000 - $199,999 MARRIED $80,000 - $99,999 $200,000 OR OVER SINGLE PRIMARY METHOD OF PURCHASING HOUSEHOLD DATE OF BIRTH:...
SPECIFICATIONS AND WIRING DIAGRAM ..............29 WARRANTY ........................31 NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY ..........31 NORTHSHORE POWER SYSTEMS EVAPORATIVE EMISSIONS CONTROL WARRANTY ....32 INDEX ..........................35 MAINTENANCE PARTS ....................37 HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 6
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Indicates a situation which, if not NOTICE avoided, may result in damage to the generator components. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 8
• This portable generator is not for use with gasoline / • Avoid repeated or prolonged contact with skin or ethanol blends with over 15% ethanol. breathing of vapor. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
SIEMPRE LLENE LA UNIDAD EN UN ÁREA BIEN VENTILADA. SIEMPRE LIMPIE CUALQUIER DERRAME DE COMBUSTIBLE. SIEMPRE DEJE QUE LA UNIDAD SE ENFRÍE ANTES DE LLENARLA DE COMBUSTIBLE. p/n 101796D 102455A p/n 102455A 102029B 1-888-HWHELP1 (494-3571) p/n 102029B 100886C p/n 100886C 102094B HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 10
The Smart Start instruction card (see F above) is NOT intended to replace information provided in this Owner’s Manual. Thoroughly read and understand all information provided in Owner’s Manual before operating generator. Failure to properly follow all instructions and precautions can cause you and others to be seriously injured or killed. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Northshore Power Systems, LLC Frequency 60Hz Max. Ambient Temp. 40 Milwaukee, WI 53212 USA Phase Single Insulation Class Engine RPM 3600 Duty Cycle Continuous Fuel Gasoline Model Number HW7000EH Serial Number FIGURE 2: Generator Nameplate Location HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
FIGURE 3: Accessory Kit Assembly NOTICE • Accessory kit is intended to be used specifically with this generator. • NEVER use accessory kit for any other purpose. • NEVER use accessory kit on-road. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Page 13
FIGURE 6: Support Leg Attached to Generator FIGURE 4: Tip onto Generator Recoil Side Gently set generator onto the recoil side or elevate the generator by placing solid wood pieces under- neath unit. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 14
Install other bracket (included in hardware bag) to frame. FIGURE 9: Snap Pin Installation Return generator to upright position (so that wheels and leg supports are touching the ground). FIGURE 7: Wheel Axle Attached to Generator www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Page 15
Slide handle bar through center of each bracket and tor frame. line up bolt holes. • To return handles to horizontal position, pull up on handle and lock with pins. FIGURE 12: Insert Handle Bar to Bracket HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 16
Actual battery appearance may vary from illustration pro- vided. NOTE: While the engine is running, a small “trickle” charge is applied to the battery.This keeps an adequate battery FIGURE 15: Electric Start Battery—Remove Retaining Plate charge. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
• In some areas, generators are required to be regis- tered with local utility companies. • If generator is used at a construction site, there may be additional regulations which must be observed. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 18
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Use information provided in this section to become familiar with your generator’s components. The information below is provided for reference only. Refer to “OPERATION” on page 15 for instructions on operating the generator. FIGURE 18: HW7000EH Portable Electrical Generator A—Power Control Center E—Engine Control Switch Control used to start and stop the engine.
Page 20
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Equipped with plugs that have a ground terminal. You must add fuel before using the generator for the first time See “Adding Engine Fuel” on page 22. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
While engine is running, a small “trickle” charge is applied to starting battery.This keeps an adequate battery charge. FIGURE 20: Fuel Shut-off Valve — ON/OFF Position Pull choke control to the ON position. FIGURE 21: Choke Control www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Allow the generator to run until it stops and the gaso- line in the fuel line has been consumed. Press the engine control switch to the STOP position. FIGURE 26: Engine Control Switch For long-term storage instructions, see page 25. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
• Inform your electrical provider immediately if a loss of power would cause you or anyone in your household to experience a medical emergency. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Page 25
TABLE 1. Typical Appliance Running Wattages * Allow up to three times normal running watts for starting this appliance. Total Running Watts † Using drying feature greatly increases energy consumption. Highest Additional Starting Watts TOTAL STARTING WATTS HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 26
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
If the unit is stored for more than a year without running, a battery charger may necessary to recharge the generator battery. ** These items should be serviced by a Honda service dealer, unless you have the proper tools and are mechanically proficient. Refer to the Honda shop manual for service procedures. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Replace oil fill dipstick and fully tighten. fuel or fuel vapor may ignite. If any fuel is spilled, be sure area is dry before starting engine. Reinstall the fuel cap (A) and tighten. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Contact an authorized Honda service dealer for engine maintenance and repairs. In some locations, authorized Honeywell service dealers are also Honda service dealers. Contact your local dealer before transporting your generator for service. FIGURE 31: Electric Start Battery—Remove Retaining Plate Gasoline and flammable solvents can cause fire or explosion.
Remove spark plug and add a tablespoon of clean engine oil into spark plug hole. Place rag over spark plug hole and pull recoil starter handle slowly to turn engine and distribute oil. Reinstall spark plug. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 32
FIGURE 39: Tip Generator to Completely Drain Fuel Allow fuel to completely drain into container. Reinstall bolt. Run engine until it stops due to lack of fuel. Turn fuel shut-off valve to the OFF position. www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
For all customer service inquiries, call 1-888-HWHELP1 (494-3571) or visit www.honeywellgenerators.com. NOTE: Contact an authorized Honda service dealer for engine maintenance and repairs. In some locations, authorized Honeywell service dealers are also Honda service dealers. Contact your local dealer before transporting your generator for service. PROBLEM...
Page 34
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
EST EXTENT PERMITTED BY APPLICABLE LAW, THIS Warranty is also available by keeping and showing your origi- LIMITED WARRANTY IS EXCLUSIVE AND EXPRESSLY IN nal receipt from date of purchase to an authorized Honeywell LIEU OF ANY AND ALL OTHER WARRANTIES, INCLUD- Generator Dealer.
Northshore Power Systems. Notwithstanding the provisions herein, warranty services OWNER’S WARRANTY RESPONSIBILITIES or repairs will be provided at an authorized Honeywell As the portable generator owner, you are responsible for per- Service Center at no charge to the owner. formance of the required maintenance listed in your owner’s The portable generator owner will not be charged for manual.
Page 39
Warranty Department at Northshore Power Systems. By phone: 1-877-HWTECHS (498-3247) By email: service@nspsystems.com By US mail: Northshore Power Systems, LLC Attention: Service and Warranty Dept. 4425 N. Port Washington Road Suite 105 Milwaukee, WI 53212-1082 HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 40
THIS PAGE INTENTIONALLY LEFT BLANK www.honeywellgenerators.com HW7000EH Portable Electrical Generator Owner’s Manual...
Rubber Stopper with Bushing 102297A Spark Arrestor with Screws, Large 102119A Support Leg 102298C Wheel, 10” Diameter 100844C HW7000EH Maintenance Parts List For part numbers of replacement product labels, see page 3 and page 4. HW7000EH Portable Electrical Generator Owner’s Manual www.honeywellgenerators.com...
Page 45
Northshore Power Systems, LLC P/N 101539E 2010 Northshore Power Systems, LLC 4425 N. Port Washington Road The Honeywell Trademark is used under license Suite 105 from Honeywell International Inc. Milwaukee, WI 53212-1082 USA Honeywell International Inc. makes no representation 1-888-HWHELP1 (494-3571) or warranties with respect to this product.