Installation And Service Certificate - Weil-McLain Ultra 3 series User Manual

- -
gas gas fired water boiler fired water boiler

Installation and Service Certificate

Boiler Model
BTU Input
Installer
(Company) (Address)
Boiler Model
Fuel Natural ____ LP ____ CO High fire
Was orifice changed? ______________________________________
Natural gas input rate measured _________________________ Btuh
Boiler Model
High Altitude yes ____ no _____ Adjust Outdoor
Manual Reset Temp
PRIORITY 1 Settings
System Type
Max Supply
Min Supply
Max OD Reset
Min OD Reset
Modulate On Diff
Modulate Off Diff
Max On Time
Min On Time
Boost Interval
Pre-pump Time:
Post-pump Time:
Circulator 1
Circulator 2
Circulator 3
Maximum Rate
Minimum Rate
Circulator Exercising
Circulator 1 on _______
Circulator 2 on _______
Circulator 3 on _______
124
— Boiler Manual — Boiler Manual
Series CP Number
❏ Installation instructions have been followed.
❏ Check-out sequence has been performed.
❏ Above information is certified to be correct.
❏ Information received and left with owner/maintenance person.
START-UP DATA
CO High fire
2
Was gas valve throttle adjusted (Ultra-399) for propane? __________________
U-CONTROL SET-UP DATA
WWSD Temp
°F
PRIORITY 2 Settings
System Type
°F Max Supply
°F Min Supply
°F Max OD Reset
°F Min OD Reset
°F Modulate On Diff
°F Modulate Off Diff
minutes Max On Time
— Min On Time
minutes Boost Interval
seconds Pre-pump Time:
seconds Post-pump Time:
on-off Circulator 1
on-off Circulator 2
on-off Circulator 3
%Rate Maximum Rate
%Rate Minimum Rate
off _______
off _______
off _______
®
Date Installed
(Phone) (Installer's Signature)
% CO Low fire
2
ppm CO Low fire
°F Add'l Heat Demand Type
°F Add'l Heat Demand Time
System Type
°F Max Supply
°F Min Supply
°F Max OD Reset
°F Min OD Reset
°F Modulate On Diff
°F Modulate Off Diff
minutes Max On Time
minutes Min On Time
minutes Boost Interval
seconds Pre-pump Time:
seconds Post-pump Time:
on-off Circulator 1
on-off Circulator 2
on-off Circulator 3
%Rate Maximum Rate
%Rate Minimum Rate
Freeze Protection Circulators
Circulator 1 on _______
Circulator 2 on _______
Circulator 3 on _______
ppm
1___ 2___ 3___ 4___
minutes
PRIORITY 3 Settings
minutes
minutes
seconds
seconds
on-off
on-off
on-off
%Rate
%Rate
off _______
off _______
off _______
%
°F
°F
°F
°F
°F
°F
—