Table Of Contents; Packaging; Introduction; General Information - Superior Fireplaces Signature DRT6340TYN Installation Instructions Manual
Signature series 40 and 45 in. power vent direct-vent gas fireplaces
Hide thumbs
Also See for Signature DRT6340TYN:
- Installation and operation instructions manual (56 pages) ,
- Installation and operation instruction manual (56 pages)
Table of Contents
Advertisement
INNOVATIVE HEARTH PRODUCTS • POWER VENT DV GAS FIREPLACES (DRT63__TYN / DRC63__TYN) • INSTALLATION INSTRUCTIONS
TABLE OF CONTENTS
Packaging .........................................Page 2
Introduction ......................................Page 2
General Information ..........................Page 2
Massachusetts Requirements ...........Page 4
Cold Climate Insulation .....................Page 5
Manufactured Home Requirements ..Page 5
Location ............................................Page 5
Vent Termination Clearances ............Page 6
Pre-Installation Steps ........................Page 9
Typical Installation Sequence ...........Page 9
Detailed Installation Steps .................Page 9
Step 1. Framing ...............................Page 9
Step 2. Routing Gas Line ................Page 11
Proper Sizing of Gas Line ..................Page 11
Step 3. Install the Vent System .......Page 12
General Vent Information ..................Page 12
Power Vent Components...................Page 12
Vent Section Length Chart ................Page 13
Offset Installation ..............................Page 13
Horizontal Termination System .........Page 16
Installing Power Vent Termination ....Page 16
Step 4. Field Wiring .........................Page 18
Page ....................................20
Step 6. Connecting Gas Line ...........Page 21
Step 7 Install Firebox Liner ............Page 21
Step 9. Installing Logs ...................Page 22
Step 10. Install/Remove Glass
Door Assembly .................................Page 24
Step 11. Burner Adjustments ............Page 24
Finishing Requirements ....................Page 26
Installation Accessories ....................Page 28
Please read and understand these instruc-
tions before beginning your installation.
PACKAGING
The assembled vented gas fireplace is packaged with:
BOX 1 - Fireplace:
•
Literature Kit (plastic bag shipped inside
firebox),
•
Pull Screen
•
Door Modesty Shield
•
Adaptor with Probe Assembly
•
(1) Remote Control Kit and Receiver Kit
2
BOX 2 - Power Vent Components:
•
(1) Power Vent Termination
•
(1) Termination Adaptor
•
(1) Horizontal Firestop Assembly
•
(1) Vacuum Hose
•
(1) 11/32" Hose Clamp
•
(1) Strain Relief
•
(1) Bushing
•
(4) Insulated 1/4" Male Terminals
•
(2) #10 Ring Terminals
Traditional Fireplaces
• Log set
• Ceramic Firebox Liner Kit
• One (1) bag Glowing Embers
• One (1) bag Platinum Embers
• One (1) bag Volcanic Stone
• Log Grate
Contemporary Fireplaces
• Porcelain Firebox Liner Kit
• One (1) bag Glass Media
INTRODUCTION
These Electronic appliances are designed to
operate on natural gas and have an electronic
intermittent pilot ignition system. External 120
Volt AC electrical power is required to operate
these units.
These vented gas fireplaces are sealed combus-
tion gas fireplaces designed for residential,
manufactured home, and commercial ap-
plications.
Use Only These Approved Vent Components
These fireplaces are designed, tested and
listed for operation and installation with, the
following (4-1/2" inner and 7-1/2" outer) vent
components only:
• Secure Vent
Direct-vent system compo-
®
nents manufactured by Security Chimneys
International.
These approved vent system components are
labeled for identification. Do NOT use any other
manufacturer's vent components with these
appliances.
GENERAL INFORMATION
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at risk individuals out of
the room and away from hot
surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique
si des personnes à risques habi-
tent la maison. Pour empêcher
l'accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d'avoir accès à la pièce et aux
surfaces chaudes.
Children and adults should be alerted to the haz-
ards of high surface temperature and should stay
away to avoid burns or clothing ignition.
Les enfants et les adultes devraient être
infor-més des dangers que posent les tem-
pératures de surface élevées et se tenir à
distance afin d'éviter des brûlures ou que
leurs vêtements ne s'enflamment.
DO NOT ATTEMPT TO ALTER OR MODIFY
ThE CONSTRUCTION OF ThE APPLIANCE
OR ITS COMPONENTS. ANY MODIFICATION
OR ALTERATION MAY VOID ThE WARRANTY,
CERTIFICATION AND LISTINGS OF ThIS UNIT.
Advertisement
Table of Contents
