Table of Contents
Advertisement
Disassembly Procedures
!
Door Disassembly
1. Disconnect power to oven.
2. Remove oven door, (see "Door Removal").
3. Begin at the bottom of the door near hinge, insert flat
blade screwdriver between choke cover and outer
door panel. Gently pry upward on choke cover to
release tabs. Work in clockwise direction to remove
choke cover.
!
CAUTION
To avoid property damage, care must be taken when
prying choke cover from oven door.
4. Slide latch assembly upward and pull away from door
frame to release tabs from frame.
5. Disconnect latch spring from door frame.
6. Begin at hinge side of door near bottom, insert flat
blade screwdriver between door frame/choke
assembly and outer door panel. Gently pry outer
door panel away from door frame to release tabs.
Work in clockwise direction to remove door frame.
7. Reassemble in reverse order.
Choke
cover
Slats
Outer
door
panel
!
CAUTION
A microwave leakage test must be performed anytime
a door assembly is removed, replaced, disassembly,
or adjusted for any reason.
NOTE: When disassembling door, use caution to
prevent deformation of slats on door frame/
choke assembly.
22
WARNING
Top
hinge
cap
Latch
assembly
Spring
Door frame/
choke assembly
16022150 Rev. 0
To avoid the risk of electrical shock, personal injury, or
death, disconnect power to oven and discharge
capacitors before following any disassembly procedure.
Outer Case
1. Disconnect power to oven.
2. Remove screws securing outer case to unit.
3. Slide outer case towards rear of unit.
4. Reassemble in reverse order.
Control Panel Removal
1. Disconnect power to oven and remove outer case,
(see "Outer Case" procedure).
2. Disconnect and label wires from controller/timer.
3. Open oven door.
4. Remove screw securing top of control panel to
cavity. Lift control panel up and out to release bottom
tabs.
5. Reassemble in reverse order.
NOTE: Be sure to re-install earth wire when securing
control panel to cavity.
Securing screw
Earth screw
©2003 Maytag Appliances Company
Advertisement
Table of Contents
