Prefabricated (Factory-Built) Installation - Jøtul GI 450 DV Installation And Operation Instructions Manual

Prefabricated Fireplace Installation
A factory-built fireplace will require modification prior
to installation of the insert.
Modification
1. Remove any fuel grate and other components if
attached. On most models, the firegrate is attached
to the unit with brackets which can be cut or pried off.
2. Remove the damper assembly. This includes the
damper blade, handle and any linkage. Two 3" liners
must be able to pass through the damper area.
3. Remove any firescreen or door assembly. This is
usually accomplished with removal of a support rod
on the inside of the fireplace frame.
4. Remove the metal ashlip, if appropriate, to allow the
insert to sit flat within the fireplace. Be sure to
reinstall any screws removed.
IMPORTANT:
BEFORE STARTING THIS INSTALLATION, MAKE
SURE THAT A GAS LINE CAN BE INSTALLED
OR IS INSTALLED TO THE FIREBOX. THIS
SHOULD ONLY BE DONE BY A QUALIFIED OR
LICENSED PLUMBER OR GAS FITTER.
Installation
Follow the same installation procedural steps detailed
on the preceding page for masonry fireplaces.
VERY IMPORTANT NOTICE:
THE USE OF AN EXISTING CHIMNEY AS AN
AIR INTAKE IS NOT COVERED UNDER THE
ANSI Z21.88-1999-CSA 2.33-M99 TEST
METHODS AND RESULTING ITS/WHI
PRODUCT CERTIFICATION. THE CODE
AUTHORITY HAVING JURISDICTION MUST
BE CONSULTED PRIOR TO PROCEEDING
WITH THIS INSTALLATION METHOD.
Exhaust
Collar
Figure 3. Duct collar locations.
Dual 3" Listed Liners
Air Inlet
Collar
Figure 4. Venting through prefabricated
fireplace chimney.
Listed Direct Vent
Termination Cap
Required
Top sealing
anchor plate
required
Intake air for
combustion
Listed flexible
gas liners
Max. Height: 35 ft.
Min. Height: 10 ft.
Factory-built
chimney pipe
Maintain the proper
clearance to mantel
and trim
Intake flex must
extend minimum 6'
into the chimney pipe
Metal block off
plate must be
installed if the
intake duct
does not extend
to the chimney
termination.
Warning:
Failure to position the
parts in accordance with
this diagram or failure to
use only parts specifically
approved with this
appliance may result in
property damage or
personal injury.
1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6 1 2 3 4 1 2 3 4 5
1 2 3 4 5 6
1 2 3 4 5 6
1 2 3 4 5 6
1 2 3 4 5 6
1 2 3 4 5 6
1 2 3 4 5 6
GI 450 DV
KATAHDIN
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2
1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2
9