Related Manuals for Jøtul C 550 Rockland
Summary of Contents for Jøtul C 550 Rockland
- Page 1 Jøtul C 550 Rockland Jøtul C 550 Rockland Fireplace Insert Installation and Operating Instructions for the United States & Canada Keep these instructions for future reference.
- Page 2 Jøtul C 550 Rockland NOTICE: YOU SHOULD CONSULT THE AUTHORITY HAVING JURISDICTION IN YOUR LOCALE (SUCH AS MUNICIPAL BUILDING DEPARTMENT, FIRE DEPARTMENT, FIRE PREVENTIOIN BUREAU, ETC.) BEFORE INSTALLATION TO DETERMINE THE NEED TO OBTAIN A PERMIT.
-
Page 3: Table Of Contents
You may also wish to attach your Specifications sales receipt to this manual for future reference. Jøtul C 550 Rockland Fireplace Insert ....6 Model: Jøtul C 550 Installation Masonry Fireplace Requirements ......7 Factory-built Fireplace Requirements .... -
Page 4: Standards / Codes
Check Building Codes Standards When installing, operating and maintaining your The Jøtul C 550 Fireplace Insert has been tested Jøtul C 550 Fireplace Insert, follow the guidelines and listed to: U.S: ANSI/UL 1482 presented in these instructions, and make them Canada: CAN/ULC-S628-93 available to anyone using or servicing the stove. -
Page 5: Safety Notices
• BURN SOLID WOOD FUEL ONLY We strongly urge you to have your authorized Jøtul • DO NOT USE CHEMICALS OR FLUIDS TO START dealer install your new Jøtul C 550 Fireplace Insert. THE FIRE. DO NOT BURN Garbage OR FLAM- MABLE FLUIDS. -
Page 6: Specifications
Jøtul C 550 Rockland Jøtul C 550 Rockland Specifications Performance The Jøtul C 550 Rockland Fireplace Insert meets U.S. Fuel: up to 24” Logs EPA emission limits for wood heaters sold after Heat Output 65,000 BTU/Hr. July 1990, and is tested and listed to ANSI/UL 1482, Heating Capacity up to 2000 sq. -
Page 7: Installation
Jøtul C 550 Rockland Installation Factory-Built Fireplace Requirements Masonry Fireplace Requirements The Jøtul C 550 Rockland may be installed into a • The entire fireplace and chimney must be factory-built fireplace with the following condi- cleaned and inspected to NFPA 211 Level II tions: standards before installation. -
Page 8: Hearth Protection
Jøtul C 550 Rockland Hearth Protection Requirements Factory-Built Fireplace Requirements, cont’d. The floor area in front of fireplace insert must be • The convection chamber/louvers of the zero- protected from live sparks and radiant heat. clearance fireplace MUST NOT be blocked off. The •... - Page 9 Jøtul C 550 Rockland Clearance to Combustible Materials Mantel Clearances • There may be no combustible materials located The installation must conform to the minimimum anywhere within 36” (914 mm) of the front of mantel clearances specified in the chart below. These the fireplace insert.
-
Page 10: Chimney Connection
Jøtul C 550 Rockland Chimney Connection Requirements U.S. Only Requirements: Canada Requirement: 1. The insert must be connected to a code-approved The insert must be installed with a continuous masonry chimney with a direct (positive) flue chimney liner of 6” (152 mm) diameter extending connector into the first chimney liner section. - Page 11 Jøtul C 550 Rockland Fireplace Chimney Preparation 1. Remove the existing damper and linkage compo- nents from the fireplace. Alternatively, you can wire the damper plate to lock it in the open position. Thoroughly clean the firebox and smokeshelf area with a wire brush.
-
Page 12: Firebox Installation
Jøtul C 550 Rockland Installing the Fireplace Insert Quik-connectors Inner Shroud Power Cord Orientation 1. Determine to which side the blower power cord will be routed. DO NOT ROUTE THE POWER CORD Phillips ACROSS THE FRONT OF THE FIREPLACE. screw 2. -
Page 13: Surround Assembly
Jøtul C 550 Rockland Figure 13. Left Breastplate Right Breastplate Surround Panel assembly viewed from backside. Alignment Set Screw T T T T T ools R ools R ools R ools R ools Requir equir equir equir equired: • 10 mm socket or wrench... -
Page 14: Operation
Jøtul C 550 Rockland Operation Air Control Settings A single lever regulates the Primary Air flow that Read the following section carefully before building controls the intensity of the fire and consequent a fire in your fireplace insert.. heat output and burn time. This lever is located... -
Page 15: Starting / Maintaining The Fire
Jøtul C 550 Rockland Starting and Maintaining a Fire Burn only solid wood directly on the bottom plate of the stove. Do not elevate the fire in any way. Andirons 1. Set the Air Control Lever in the full open position. -
Page 16: Blower
SWITCH NOTE: Terminals and switch markings are on HIGH opposite ends of the switch. See below. Manual Circuit Auto Circuit Terminal Terminal Auto Switch Manual Switch Position Position Figure 17. Blower and speed controls. Figure 18. C 550 Wiring diagram. -
Page 17: Maintenance
The container of ashes should be placed on a Replace glass only with part # 156467 noncombustible floor or on the ground, well away specifically designed for the Jøtul C 550 from all combustible materials, pending final Rockland Fireplace insert. Do not use disposal. -
Page 18: General Maintenance
Jøtul C 550 Rockland General Maintenance Regular maintenance will assure proper perfor- Canada Installations (Full Reline): mance and prolong the life of your fireplace insert.. The chimney liner can be swept directly into a The following procedures do not take long and are bucket placed under the flue outlet, with removal of generally inexpensive. - Page 19 Jøtul C 550 Rockland Gasket Replacement See the chart below for replacement gasket specifi- cations. See also figs. 19-20 for locations. 1. Remove the old gasket material with a pliers and thoroughly clean the channel with a wire brush. 2. Lay out the new gasket around the channel to determine length.
-
Page 20: Exploded View
Jøtul C 550 Rockland Jøtul C 550 Rockland Illustrated Parts Diagram Figure 20. -
Page 21: Parts Listing
Jøtul C 550 Rockland Jøtul C 550 Rockland Parts List No..Description Description P P P P P ar ar ar ar art t t t t Number Number Number No..Description... -
Page 22: Alternate Hearth Protection
Jøtul C 550 Rockland Appendix A Alternate Hearth Protection Leg Leveler Installation All hearth protection materials must be noncombustible; Two leg leveler bolts are contained within the i.e: metal, brick, stone, or mineral fiber boards. Any combus- Miscellaneous Kit included inside the firebox. The tible material may not be used. -
Page 23: Door Knob Assembly
Jøtul C 550 Rockland Door Knob Installation The Door Knob components are included in a separate bag contained within the Miscellaneous Kit included with the firebox. Install the parts in the order shown in fig. 22. Phillips screwdriver required. Door Handle... - Page 24 Jøtul C 550 Rockland This appliance must be installed in conformance with local and national building regulations. It is important that the these instructions be carefully read and understood before beginning the installation. Jøtul pursues a policy of continual product development. Consequently, products may differ in specification, color or type of accessories from those illustrated or described in various publications.