Replacement Parts List - Lopi Liberty Owner's Manual

Baffle Removal and Replacement Instructions (Continued)
REMOVING THE
SECONDARY AIR TUBES
Follow the directions to the right
to remove any of the three
seconary air tubes.
NOTE: When replacing, make sure the
two holes on the secondary air tube
sleeve line up with the hole on the
secondary air tube and the hole on the
air tube stub welded to the side air
channel.
R P
EPLACEMENT ARTS
PART
Door Gasket
Glass Gasket
Door Glass
Retainer for Door Glass
Handle for Door
Door Handle
Door Cam
Air Control Handle
Firebrick
Secondary Air Tube
Front Baffle Support
Center Baffle Support
Bypass Support
Bypass Damper
Bypass Yoke and Bypass Extender
Bypass Handle
Owner's Manual
Air Control Slider
Air Control Floating Plate with Springs
Bypass Pull Tool
M
AINTAINING
Pry out both pins on the secondary
air tube sleeve (use a screwdriver).
Slide the secondary air
tube sleeve to the left.
Slide the secondary air tube to the right
until it disengages from the left side.
L
IST
PART DESCRIPTION
Black 7/8" dia. Fiberglass rope 64" long
Black 3/4" x 1/8" fiberglass channel tape 60" long
5 mm neoceram, 11 7/8" tall @ center, 19 1/4" wide
Cast steel retainer attaches to door with ten screws (included)
Brass spring (1/2")
Steel shaft with threaded end (includes spring handle)
Cast brass
Brass spring (3/8")
1 1/4" x 4 1/2" x 9" silicon based refractory - some firebrick will require cutting
22 7/8" long with 3/16" holes every 3/4", includes two pins
23 5/8" long, 1 1/2" angle iron welded to 21 1/8" long 1" deflector at 45° angle
23 5/8" long, 1 1/2" angle iron welded to 23 5/8" long 1" strip to form a "t"
9" by 9" square 5/16" thick with two 7 1/4" x 1" guides top & bottom, stop
6 11/16" dia. Circle of 5/16" thick steel, two 1" tubes welded to top for yoke
All 3/8" dia. Rod, 6" (before bending) yoke welded to 4 1/2" rod, + 13 1/4" extender
Cast iron eye bolt
This document
Steel plate with air control rod
8 springs and the floating plate used to guide air control slider
Tool used to adjust bypass
Y A
OUR PPLIANCE
Pin
Side Air Channel
(Welded to side of Firebox)
3.
(C )
ONTINUED
Secondary Air
Tube Sleeve
1.
2.
Air Tube Stub
(welded to the
side air channel)
4.
P 29
AGE