Long Term Storage; Otherstoragetips; Batteryservice; Battery Replacement(Xg7Oooe & Xg8Oooe) - Generac Power Systems XG series Owner's Manual

3.7 LONG TERM STORAGE
It is important to prevent gum deposits from forming in essential
fuel system parts such as the carburetor,fuel hose or tank during
storage. To avoid engine problems, the fuel system should be
emptied before storage of 30 days or longer,as follows:
• Removeall gasolinefrom the fuel tank.
,_ CAUTION!
,A Drain fuel into approved containeroutdoors,away from
openflame. Be sure engine is cool. Do not smokein the
vicinity or light a cigarette.
• Start and run engineuntil enginestops from lack of fuel.
• Allow the engineto cool, then drain oil from crankcase. Refill
with recommendedgrade.
• Removespark plug and pour about 1/2 ounce (15 ml) of engine
oil into the cylinder. Cover spark plug hole with rag. Pull the
recoil starter a couple times to lubricate the piston rings and
cylinder bore.
_,CAUTION!
,l_Avoid spray from spark plug hole when
cranking engine.
• Install and tighten spark plug. Do not connect the spark plug
wire.
• Cleanthe generatoroutersurfaces. Checkthat cooling air slots
and openingson generatorare open and unobstructed.
• Store the unit in a clean, dry place.
3.8 OTHER STORAGE T iPS
• Do not store gasolinefrom one seasonto another.
• Replaceany gasoline canthat starts to rust. Rust and/or dirt in
the gasoline will cause problems with the carburetor and fuel
system.
• If possible,store the unit indoors and cover it to give protection
from dust and dirt. Cover the unit with a suitable protective
cover that does not retainmoisture.
• BE SURE TO EMPTY THE FUEL TANK. If it is not practical
to empty the fuel tank and the unit is to be stored for some
time, use a commercially availablefuel stabilizeradded to the
gasolineto increasethe life of the gasoline.
_,CAUTION!
,l_ NEVER cover the generator while engine and
exhaust area are warm.
4.1 BATTERY REPLACEMENT (XGT000E &XGS000E)
NOTE:
The battery shippedwith the generatorhas beenfully charged.
A battery may lose some of its chargewhen not in use for
prolonged periodsof time. if the batteryis unableto crank
the engine, plugin the 12V chargerincludedin the accessory
box (see the Charginga Batterysection).RUNNING THE
GENERATOR DOESNOT CHARGE THE BATTERY.
The battery shipped with the generator has been provided fully
charged.To replacethe battery (See Figure16):
Remove the side panel as shown. Remove the four bolts
securingthe fuel tank.
Turnthe fuel valve on the control panel to the "OFF"position.
Pull the fuel tank back slightly and remove the fuel hose that
runs from the engine to the fuel valve.
,A CALITION!
,A Drain fuel into approvedcontaineroutdoors, away from
openflame. Be sure engineis cool. Do not smokein the
vicinityor light a cigarette.
• Disconnectthe recovery hosefrom the rollovervalve. Pushthe
hose through the grommet in the corner of the fuel tank. This
will allow for removal of the fuel tank.
• Pushthe fuel valve from the control panel and remove the fuel
tank.
• Removethe battery wire connections (black wire first) and the
battery hold-down bracket.
• Replacethe battery, connecting the RED wire to the POSITIVE
(+) terminal and the BLACKwire to the NEGATIVE (-) terminal
NOTE:
Start all four screws on the side panel before tighteningor fl
may not be possibleto get all the screwsin place.
15