Jenn-Air 720-0164 Instructions Manual
Jenn-Air 720-0164 Instructions Manual

Jenn-Air 720-0164 Instructions Manual

Stainless steel lp gas grill

Advertisement

STAINLESS STEEL LP GAS GRILL
MODEL NO.: 720-0164
ITEM NO: 5119
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe's Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

Advertisement

Table of Contents
loading

Summary of Contents for Jenn-Air 720-0164

  • Page 1 STAINLESS STEEL LP GAS GRILL MODEL NO.: 720-0164 ITEM NO: 5119 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE...
  • Page 2: Table Of Contents

    TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions……………………………. Exploded View……………………………… Placement of the Grill………………………… Parts List…………………………………… SECTION TWO SECTION SIX Side Burner, Side Shelf, and Spice Tray Grilling Hints………………………………… Assembly……………………………………… Grill Cooking Chart………………………… 23-25 Side Burner Hose Quick-Connect Assembly Grill Recipe Suggestions…………………..
  • Page 3: Safety Instructions

    SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION...
  • Page 4 SAFETY INSTRUCTIONS CAUTION WARNING When using a match to light the grill make Do not use the grill if the odor of gas is sure to use the attached lighting rod. present. Contact customer service at 1- 800-554-5799. CAUTION Before cleaning, make sure the gas supply WARNING and control knobs are in the “OFF”...
  • Page 5 SAFETY INSTRUCTIONS USING THE SIDE BURNER WARNING Inspect the gas supply hose prior to turning on Do not attempt to light the grill if gas odor is the gas. If there is evidence of cuts, wear or present. Contact customer service at 1-800- abrasion, it must be replaced prior to use.
  • Page 6 SAFETY INSTRUCTIONS The grill is not intended to be installed in or on WARNING recreational vehicles and/or boats. Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section Children should not be left alone or unattended in of this manual.
  • Page 7: Placement Of The Grill

    Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 720-0164 liquid propane gas grill is designed do not use a wet sponge or cloth to clean the grill for optimum performance without the use of while it is hot.
  • Page 8: Assembly

    SIDE BURNER & SIDE SHELF ASSEMBLY Estimated Assembly Time: Approximately 10 minutes Required Tools: Phillips Screwdriver (not included) 1. Open the grill lid and remove the side burner from the fire box. 2. The screws used to attach the side shelf and side burner are already screwed into the side of the grill cart (top drawing).
  • Page 9: Side Burner Hose Quick-Connect Assembly

    SIDE BURNER HOSE QUICK-CONNECT ASSEMBLY Estimated Assembly Time: Approximately 5 minutes No Tools Required 1. Insert the side burner hose with female sleeve through side panel of cart (Top drawing). 2. Push the sleeve of the female socket back and insert the male end of the connector. Release the sleeve.
  • Page 10: Side Shelf Handle & Battery Installation

    SIDE SHELF HANDLE ASSEMBLY Estimated Assembly Time: Approximately 5-7 minutes Required Tools: Phillips Screwdriver (not included) 1. Remove the four side shelf handle screws from the side of the shelf. 2. Align the holes in the side shelf handle with the holes in the shelf. 3.
  • Page 11: Braking System Operations

    BRAKING SYSTEM OPERATIONS Push right to lock. Push left to unlock. LIQUID PROPANE CYLINDER RETENTION SYSTEM 1. Attach the liquid propane gas cylinder to the slide-out tray using the gas cylinder retention screw. Turn the retention screw clockwise to tighten the gas cylinder. Retention Screw...
  • Page 12: Hook-Up

    SLIDE-OUT TRAY LOCKING SYSTEM 1. To lock and unlock the liquid propane gas cylinder tray, press the gas cylinder tray’s top button to lock. Press the side button to unlock. PROPANE REGULATOR HOOK-UP 1. Attach the regulator to the propane cylinder by turning the regulator handle clockwise. 2.
  • Page 13: Gas Hook Up

    Total gas consumption (per hour) of the 720-0164 CONNECTION liquid propane gas grill with all burners set on “HI”: Your grill is equipped with gas supply orifices for use only with liquid propane gas.
  • Page 14: Leak Testing

    LEAK TESTING GENERAL Only those parts recommended by the Although gas connections on the grill are leak manufacturer should be used on the grill. tested prior to shipment, a complete gas tightness Substitutions will void the warranty. check must be performed at the installation site. Periodically, check the whole system for leaks GAS FLOW CHECK following the procedures listed below.
  • Page 15: Installer Final Check

    INSTALLER FINAL CHECK Specified clearance maintained 24 inches The unit has been tested and is free of leaks. from combustible materials/construction. The gas supply shut off valve has been All internal packaging has been removed. located. The hose and regulator are properly All burners are factory installed.
  • Page 16: Operating Instructions

    OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 13,000 BTU/Hr. The After its first use, the stainless steel adjacent to the main grill burners encompass the entire cooking rotisserie burner will most likely turn dark blue. This area and are side ported to minimize blockage from is a normal property of the non-rusting type falling grease and debris.
  • Page 17: Lighting Instructions

    NOTE Adjust the counter balance weight to balance the It is normal for the skewer to flex when larger cuts heavier side of the meat and avoid lopsided rotation of meat are being cooked. of the rotisserie motor. If the meat scrapes on the cooking grids during any CAUTION part of the rotation, the cooking grids must be When using the rotisserie burner, remove the...
  • Page 18: To Match Light The Grill

    TO MATCH LIGHT THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate.
  • Page 19: Lighting Illustrations

    LIGHTING ILLUSTRATIONS MAIN, SIDE & ROTISSERIE BURNER LIGHTING 1. Open the top cover or lid. 2. Push and turn the main, side or rotisserie burner control knobs to the “HI” setting. Push the control knob until the burner ignites. The burner should ignite within 4 seconds (if burner does not ignite follow match lighting instructions on Page 16.
  • Page 20: Using The Side Burner

    USING THE SIDE BURNER Inspect the gas supply hose prior to turning on 4. If the smell of gas is detected and the igniter the gas. If there is evidence of cuts, wear or is not functioning, immediately turn the control abrasion, it must be replaced prior to use.
  • Page 21: Care And Maintenance Of Grill

    CARE & MAINTENANCE OF THE GRILL STAINLESS STEEL GRILL BURNERS Grease specks can gather and bake onto the Extreme care should be taken when moving a surfaces of the stainless steel, giving the burner. It must be correctly centered on the appearance of rust.
  • Page 22: Troubleshooting

    TROUBLESHOOTING WHEN TO LOOK FOR SPIDERS You should inspect the burners at least twice a WARNING year or immediately after any of the following Spiders and insects can nest inside the burners conditions occur: of the grill and disrupt gas flow. This very dangerous condition could cause a fire behind 1.
  • Page 23: Exploded View

    EXPLODED VIEW...
  • Page 24: Parts List

    PARTS LIST Model No. 720-0164 REF# DESCRIPTION REF# DESCRIPTION Main Lid Rear Baffle Heat Indicator Fire Box Heat Shield Name Plate Side Hose Quick Connector Heat Insulating spacer Rotisserie Gas Pipe Main Lid Handle Assembly Side Burner Gas Hose Rotisserie Burner...
  • Page 25: Grilling Hints

    GRILLING HINTS The preparation of meat, whether rare, medium, To get the juiciest meat, add seasoning or salt or well done, is affected to a large degree by the after cooking is finished and turn the meat only thickness of the cut. once during cooking.
  • Page 26 FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended. A flare-up could occur quickly.
  • Page 27 FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS Breasts Medium 30 to 45 minutes Marinate with Italian dressing well-done FISH AND SEAFOOD Steaks Grill, turning once. Brush with Halibut 3/4 to 1 inch Medium to 8 to 15 minutes Melted butter, margarine or oil Salmon High...
  • Page 28: Grill Recipe Suggestions

    GRILL RECIPES 1tsp. Worcestershire sauce BBQ SALMON Half-hour before cooking, turn the 1tsp. Dry mustard 2 large salmon steaks burner to the grill on high. Drain ¼ tsp. Thyme, crushed 2 tbs. oil seafood-reserving marinade. On each 1 medium onion, sliced Salt &...
  • Page 29 in thin slices. Place on hot platter. Squeeze CHICKEN TANDOORI STYLE 2 oz. lemon juice lemon juice over. Wrap meat and any of 8 large chicken thighs or drumsticks 10 lbs. pork roast the following toppings in tortillas: chopped 1 c. plain nonfat yogurt tomatoes, guacamole, sour cream, and ½...
  • Page 30: Limited Warranty

    LIMITED WARRANTY MODEL #720-0164 STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer-purchaser of each Jenn-Air Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below.

Table of Contents