For a complete list of abbreviations and acronyms, see the Dell Inspiron Help file. To access the help file, click the Start button, click Help and Support, click

User and system guides, click User's guides, and click Dell Inspiron Help.

If you purchased a Dell™ n Series computer, any references in this document to Microsoft® Windows® operating systems are not applicable.

Information in this document is subject to change without notice.

Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden.

Trademarks used in this text: Dell, the DELL logo, and Inspiron are trademarks of Dell Inc.; Microsoft and Windows are registered trademarks of Microsoft Corporation; Bluetooth is a

trademark owned by Bluetooth SIG, Inc. and is used by Dell Inc. under license.

Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any

proprietary interest in trademarks and trade names other than its own.

Model PP14L

February 2005 Rev. A00

Table of Contents

Summary of Contents for Dell Inspiron XPS Gen 2

Page 1 Bluetooth SIG, Inc. and is used by Dell Inc. under license. Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any proprietary interest in trademarks and trade names other than its own.
Page 2: Removing The Battery Latch Assembly
Back to Contents Page Battery Latch Assembly Dell™ Inspiron™ XPS Service Manual Removing the Battery Latch Assembly Replacing the Battery Latch Assembly Removing the Battery Latch Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 3: Replacing The Battery Latch Assembly
2 battery latch assembly 9. Remove the spring from the hook on the bottom panel by lifting it up and away with a screwdriver or a plastic scribe. 1 hook 2 spring 10. Remove the plastic battery latch assembly by twisting the assembly slightly and lifting it out of the channel and away from the bottom panel. 1 battery latch assembly Replacing the Battery Latch Assembly ...
Page 4: Before You Begin
Hold a component such as a processor by its edges, not by its pins. NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty.
Page 5: Computer Orientation
3. Disconnect any telephone or network cables from the computer. 4. Disconnect your computer and all attached devices from their electrical outlets. 5. Close the display and turn the computer upside down on a flat work surface. NOTICE: To avoid damaging the system board, you must remove the main battery before you service the computer.
Page 6 number of screws and their sizes. Hard Drive: Fans (2): Keyboard: (2 each) (4 total – 2 per fan) (2 each) Display Panel: Display Assembly: Display Bezel: (8 each) (4 each) (4 each, under display bumpers) Display Ground Screw: ...
Page 7 Optical Drive: System Board: Door to Card with Bluetooth® Wireless Technology (1 each) (4 each) (1 each) Back to Contents Page ...
Page 8: Flashing The Bios
Back to Contents Page Flashing the BIOS Dell™ Inspiron™ XPS Service Manual NOTICE: Plug the AC adapter into a known good power source to prevent a loss of power. Failure to do so may cause system damage. 1. Ensure that the AC adapter is plugged in and that the main battery is installed properly.
Page 9: Internal Card With Bluetooth® Wireless Technology
Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ Inspiron™ XPS Service Manual Removing the Card Replacing the Card Removing the Card CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 10: Removing The Coin-Cell Battery
Back to Contents Page Coin-Cell Battery Dell™ Inspiron™ XPS Service Manual Removing the Coin-Cell Battery Replacing the Coin-Cell battery Removing the Coin-Cell Battery CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 11 Back to Contents Page ...
Page 12: Removing The Microprocessor Module
Back to Contents Page Microprocessor Module Dell™ Inspiron™ XPS Service Manual Removing the Microprocessor Module Replacing the Microprocessor Module Removing the Microprocessor Module CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 13: Replacing The Microprocessor Module
NOTE: The ZIF-socket cam screw secures the microprocessor to the system board. Take note of the arrow on the ZIF-socket cam screw, which indicates the direction to turn the cam screw. 8. Lift the microprocessor module from the ZIF socket. Replacing the Microprocessor Module NOTICE: Ensure that the cam lock is in the fully open position before seating the microprocessor module.
Page 14: Display Assembly
Back to Contents Page Display Dell™ Inspiron™ XPS Service Manual Display Assembly Display Bezel Display Panel Display Latch Display Assembly Removing the Display Assembly CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 15 antenna cables 4. Turn the computer top-side up. 5. Remove the center control cover. 6. Open the display all the way (180 degrees) so that it lies flat against the work surface. 7. Use the pull-tab to disconnect the display cable, and then disengage the display cable from the cable channel. ...
Page 16: Display Bezel
10. Lift the display assembly away from the computer. Replacing the Display Assembly 1. Align the display assembly over the screw holes in the base of the computer. 2. Thread the Mini PCI antenna cables back through the hole in the base of the computer. ...
Page 17: Removing The Display Bezel
1 M2.5 x 5-mm screws (4) 2 screw covers (2) 3 rubber display bumpers (6) 4 shoulder screws (2) Removing the Display Bezel CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 18: Display Panel
tabs 7. Repeat step 6 for the lower-left corner of the bezel. Then use your fingers to release the snaps around the rest of the bezel and lift it away from the cover. display bezel display panel Replacing the Display Bezel ...
Page 19: Removing The Display Panel
1 display grounding screw 2 display 3 M2 x 3-mm screws (8) 4 display back cover Removing the Display Panel CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: To avoid damaging the system board, you must remove the main battery before you begin working inside the computer.
Page 20: Display Latch
6. Replace the display bezel. Display Latch Removing the Display Latch CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: To avoid damaging the system board, you must remove the main battery before you begin working inside the computer.
Page 21: Removing The System Fans
Back to Contents Page System Fans Dell™ Inspiron™ XPS Service Manual Removing the System Fans Replacing the System Fans Removing the System Fans CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 22: Replacing The System Fans
1 fan 2 M2.5 x 5-mm screws (2) 3 LED system board connector 4 fan system board connector Replacing the System Fans 1. Align and place each fan over its respective screw holes on the system board. 2. Replace the four M2.5 x 5-mm screws (two on each fan). ...
Page 23 Back to Contents Page Battery Latch Assembly Dell™ Inspiron™ XPS Service Manual Removing the Battery Latch Assembly Replacing the Battery Latch Assembly Removing the Battery Latch Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 24 1 screw 2 battery latch assembly 9. Remove the spring from the hook on the bottom panel by lifting it up and away with a screwdriver or a plastic scribe. 1 hook 2 spring 10. Remove the plastic battery latch assembly by twisting the assembly slightly and lifting it out of the channel and away from the bottom panel. 1 battery latch assembly Replacing the Battery Latch Assembly ...
Page 26 Hold a component such as a processor by its edges, not by its pins. NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty.
Page 27 3. Disconnect any telephone or network cables from the computer. 4. Disconnect your computer and all attached devices from their electrical outlets. 5. Close the display and turn the computer upside down on a flat work surface. NOTICE: To avoid damaging the system board, you must remove the main battery before you service the computer.
Page 28 number of screws and their sizes. Hard Drive: Fans (2): Keyboard: (2 each) (4 total – 2 per fan) (2 each) Display Panel: Display Assembly: Display Bezel: (8 each) (4 each) (4 each, under display bumpers) Display Ground Screw: ...
Page 29 Optical Drive: System Board: Door to Card with Bluetooth® Wireless Technology (1 each) (4 each) (1 each) Back to Contents Page ...
Page 30 Back to Contents Page Flashing the BIOS Dell™ Inspiron™ XPS Service Manual NOTICE: Plug the AC adapter into a known good power source to prevent a loss of power. Failure to do so may cause system damage. 1. Ensure that the AC adapter is plugged in and that the main battery is installed properly.
Page 31 Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ Inspiron™ XPS Service Manual Removing the Card Replacing the Card Removing the Card CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 32 Back to Contents Page Coin-Cell Battery Dell™ Inspiron™ XPS Service Manual Removing the Coin-Cell Battery Replacing the Coin-Cell battery Removing the Coin-Cell Battery CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 33 Back to Contents Page ...
Page 34 Back to Contents Page Microprocessor Module Dell™ Inspiron™ XPS Service Manual Removing the Microprocessor Module Replacing the Microprocessor Module Removing the Microprocessor Module CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 35 NOTE: The ZIF-socket cam screw secures the microprocessor to the system board. Take note of the arrow on the ZIF-socket cam screw, which indicates the direction to turn the cam screw. 8. Lift the microprocessor module from the ZIF socket. Replacing the Microprocessor Module NOTICE: Ensure that the cam lock is in the fully open position before seating the microprocessor module.
Page 36 Back to Contents Page Display Dell™ Inspiron™ XPS Service Manual Display Assembly Display Bezel Display Panel Display Latch Display Assembly Removing the Display Assembly CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 37 antenna cables 4. Turn the computer top-side up. Remove the center control cover. 6. Open the display all the way (180 degrees) so that it lies flat against the work surface. 7. Use the pull-tab to disconnect the display cable, and then disengage the display cable from the cable channel. ...
Page 38 10. Lift the display assembly away from the computer. Replacing the Display Assembly 1. Align the display assembly over the screw holes in the base of the computer. 2. Thread the Mini PCI antenna cables back through the hole in the base of the computer. ...
Page 39 1 M2.5 x 5-mm screws (4) 2 screw covers (2) 3 rubber display bumpers (6) 4 shoulder screws (2) Removing the Display Bezel CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 40 tabs 7. Repeat step 6 for the lower-left corner of the bezel. Then use your fingers to release the snaps around the rest of the bezel and lift it away from the cover. display bezel display panel Replacing the Display Bezel ...
Page 41 1 display grounding screw 2 display 3 M2 x 3-mm screws (8) 4 display back cover Removing the Display Panel CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: To avoid damaging the system board, you must remove the main battery before you begin working inside the computer.
Page 42 6. Replace the display bezel. Display Latch Removing the Display Latch CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by touching an unpainted metal surface on the computer. NOTICE: To avoid damaging the system board, you must remove the main battery before you begin working inside the computer.
Page 43 Back to Contents Page System Fans Dell™ Inspiron™ XPS Service Manual Removing the System Fans Replacing the System Fans Removing the System Fans CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 44 1 fan 2 M2.5 x 5-mm screws (2) 3 LEDsystem board connector 4 fan system board connector Replacing the System Fans 1. Align and place each fan over its respective screw holes on the system board. 2. Replace the four M2.5 x 5-mm screws (two on each fan). ...
Page 45: Removing The Hard Drive
NOTICE: Hard drives are extremely fragile; even a slight bump can damage the drive. NOTE: Dell does not guarantee compatibility or provide support for hard drives from sources other than Dell. Removing the Hard Drive 1. Follow the instructions in "Before Working Inside Your...
Page 46: Returning A Hard Drive To Dell
Returning a Hard Drive to Dell Return your old hard drive to Dell in its original or comparable foam packaging. Otherwise, the hard drive may be damaged in transit. hard drive foam packaging Back to Contents Page ...
Page 47: Removing The Center Control Cover
Back to Contents Page Center Control Cover Dell™ Inspiron™ XPS Service Manual Removing the Center Control Cover Replacing the Center Control Cover Removing the Center Control Cover CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 48: Removing The Keyboard
Back to Contents Page Keyboard Dell™ Inspiron™ XPS Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 49 display panel. 1. Reconnect the keyboard to the system board connector. 2. Slide the bottom of the keyboard into the computer base. NOTE: You may need to push the bottom of the keyboard down slightly to seat the keyboard into the computer base. ...
Page 50 Back to Contents Page Customizable LEDs Dell™ Inspiron™ XPS Service Manual Replacing the Customizable LEDs The system has 3 pairs (total of 6) of Light Emitting Diode sets (LEDs) that can be customized to display a chosen color. These customizable LEDs emit light from the top, front, and sides of the computer.
Page 51 Back to Contents Page MCH Heat Sink Dell™ Inspiron™ XPS Service Manual Removing the MCH Heat Sink Replacing the MCH Heat Sink Removing the MCH Heat Sink CAUTION: Before you perform the following procedures, see the safety instructions in the Product Information Guide.
Page 52 ...
Page 53: Removing The Memory Module
You can do so by touching an unpainted metal surface. NOTE: Memory modules purchased from Dell are covered under your computer warranty. NOTE: To get maximum performance/dual-channel memory bandwidth capability, both memory module connectors must contain memory modules and the modules must be of the same size and configuration.
Page 54: Replacing The Memory Module
Replacing the Memory Module NOTE: To get maximum performance/dual-channel memory bandwidth capability, both memory module connectors must contain memory modules and the modules must be of the same size and configuration. NOTE: If a memory module is not installed properly, the computer will not boot. ...
Page 55: Removing The Mini Pci Card
If you are removing and/or installing a 2.4-GHz (802.11b, 802.11b/g) Mini PCI card, follow the instructions noted below. Only products approved for use in your portable computer may be installed. Approved Mini PCI cards may be purchased only from Dell.
Page 56: Replacing The Mini Pci Card
NOTICE: To prevent damage to the Mini PCI card connector, do not use tools to spread the securing clips that secure the card. 5. Release the Mini PCI card by spreading the metal securing tabs until the card pops up slightly. ...
Page 57 1 antenna cables (2) 3. Replace the cover. Back to Contents Page ...
Page 58: Removing The Modem
Back to Contents Page Modem Dell™ Inspiron™ XPS Service Manual Removing the Modem Replacing the Modem Removing the Modem CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 59: Replacing The Modem
NOTICE: Do not disconnect the modem cable from the system board. 5. Disconnect the modem cable from the modem. Replacing the Modem 1. Connect the modem cable to the modem. NOTICE: Ensure that the modem cable is routed correctly when you replace the modem. ...
Page 60: Removing The Optical Drive
Back to Contents Page Optical Drive Dell™ Inspiron™ XPS Service Manual Removing the Optical Drive Replacing the Optical Drive Your computer ships with a fixed optical drive installed. Removing the Optical Drive NOTICE: To prevent damage to drives, store them in a safe, dry place when they are not installed in the computer. Avoid pressing down on them or placing heavy objects on top of them.
Page 61: Removing The Palm Rest
Back to Contents Page Palm Rest Dell™ Inspiron™ XPS Service Manual Removing the Palm Rest Replacing the Palm Rest Removing the Palm Rest CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 62: Replacing The Palm Rest
1 M2.5 x 8-mm screws (11) 9. Remove the Internal Card With Bluetooth® Wireless Technology. 10. Turn the computer top-side up and disconnect the touch-pad connector from the system board. 11. Remove the LED board connector. 12. Lift the palm rest and remove it from the computer. 1 touch-pad connector 2 LED board connector Replacing the Palm Rest...
Page 63 8. Replace the display assembly. 9. Replace the keyboard. 10. Replace the center control cover. Back to Contents Page ...
Page 64 Back to Contents Page PC Card Reader Cage Dell™ Inspiron™ XPS Service Manual Removing the PC Card Reader cage Removing the PC Card Reader cage CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 65: Pin Assignments For I/O Connectors
Back to Contents Page Pin Assignments for I/O Connectors Dell™ Inspiron™ XPS Service Manual USB Connector Video Connector S-Video TV-Out Connector IEEE 1394 Connector USB Connector Signal USB5V+ USBP– USBP+ Video Connector Signal Signal CRT_R 9 CRT_G 10 CRT_B 11 MONITOR_DETECT–...
Page 66: Ieee 1394 Connector
DLUMA-L DCRMA-L Composite Video Signal DCMPS-L IEEE 1394 Connector Signal TPB– TPB+ TPA– TPA+ Back to Contents Page ...
Page 67: Removing The System Board
Back to Contents Page System Board Dell™ Inspiron™ XPS Service Manual Removing the System Board Replacing the System Board Removing the System Board CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 68 13. Remove the M2 x 3-mm screw that holds the stiffener bracket next to the hard drive cage and remove the stiffener bracket. 1 PC Card connector 2 M2.5 x 5-mm stiffener bracket screw 3 stiffener bracket 4 PC Card connector on system board ...
Page 69: Replacing The System Board
2 PC Card connector 3 cable connector for internal card with Bluetooth wireless technology 4 speaker connector 5 subwoofer connector 24. Remove the three M2.5 x 5-mm screws from the system board. 1 system board M2.5 x 5-mm screws (4) ...
Page 70 4. Enter the system setup program to update the BIOS on the new system board with the computer Service Tag sequence. Back to Contents Page ...
Page 71: Removing The Speakers
Back to Contents Page Speakers Dell™ Inspiron™ XPS Service Manual Removing the Speakers Replacing the Speakers Removing the Speakers CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 72 4. Re-route the speaker cables into the cable guides and re-adhere the tape to secure the speaker cables in place on the computer base. Back to Contents Page ...
Page 73: System Components
System Components Dell™ Inspiron™ XPS Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this document assumes that a part can be replaced by performing the removal procedure in reverse order.
Page 74: Removing The Microprocessor Thermal-Cooling Assembly
Back to Contents Page Microprocessor Thermal-Cooling Assembly Dell™ Inspiron™ XPS Service Manual Removing the Microprocessor Thermal-Cooling Assembly Replacing the Microprocessor Thermal-Cooling Assembly Removing the Microprocessor Thermal-Cooling Assembly CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide.
Page 75 Back to Contents Page ...
Page 76 A CAUTION indicates a potential for property damage, personal injury, or death. For a complete list of abbreviations and acronyms, see the Dell Inspiron Help file. To access the help file, click the Start button, click Help and Support, click User and system guides, click User's guides, and click Dell Inspiron Help.
Page 77: Removing The Usb Port Board
Back to Contents Page USB Port Board Dell™ Inspiron™ XPS Service Manual Removing the USB Port Board Replacing the USB Port Board Removing the USB Port Board CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 78 5. Replace the palm rest. 6. Replace the display assembly. 7. Replace the keyboard. 8. Replace the center control cover. 9. Replace the battery and other items removed in "Before Working Inside Your Computer." Back to Contents Page ...
Page 79: Removing The Video Card/Thermal Cooling Assembly
Back to Contents Page Video Card/Thermal Cooling Assembly Dell™ Inspiron™ XPS Service Manual Removing the Video Card/Thermal Cooling Assembly Replacing the Video Card/Thermal Cooling Assembly Removing the Video Card/Thermal Cooling Assembly CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide.
Page 80 2. Tighten the four captive screws on the video card/thermal cooling assembly. Back to Contents Page ...
Page 81: Removing The Subwoofer
Back to Contents Page Subwoofer Dell™ Inspiron™ XPS Service Manual Removing the Subwoofer Replacing the Subwoofer Removing the Subwoofer CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 82 Back to Contents Page ...
Page 83 NOTICE: Hard drives are extremely fragile; even a slight bump can damage the drive. NOTE: Dell does not guarantee compatibility or provide support for hard drives from sources other than Dell. Removing the Hard Drive 1. Follow the instructions in "Before Working Inside Your...
Page 84 Returning a Hard Drive to Dell Return your old hard drive to Dell in its original or comparable foam packaging. Otherwise, the hard drive may be damaged in transit. hard drive foam packaging Back to Contents Page ...
Page 85 Back to Contents Page Center Control Cover Dell™ Inspiron™ XPS Service Manual Removing the Center Control Cover Replacing the Center Control Cover Removing the Center Control Cover CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 86 Back to Contents Page Keyboard Dell™ Inspiron™ XPS Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 87 display panel. 1. Reconnect the keyboard to the system board connector. 2. Slide the bottom of the keyboard into the computer base. NOTE: You may need to push the bottom of the keyboard down slightly to seat the keyboard into the computer base. ...
Page 88 Back to Contents Page Customizable LEDs Dell™ Inspiron™ XPS Service Manual Replacing the Customizable LEDs The system has 3 pairs (total of 6) of Light Emitting Diode sets (LEDs) that can be customized to display a chosen color. These customizable LEDs emit light from the top, front, and sides of the computer.
Page 89 Back to Contents Page MCH Heat Sink Dell™ Inspiron™ XPS Service Manual Removing the MCH Heat Sink Replacing the MCH Heat Sink Removing the MCH Heat Sink CAUTION: Before you perform the following procedures, see the safety instructions in the Product Information Guide.
Page 90 ...
Page 91 You can do so by touching an unpainted metal surface. NOTE: Memory modules purchased from Dell are covered under your computer warranty. NOTE: To get maximum performance/dual-channel memory bandwidth capability, both memory module connectors must contain memory modules and the modules must be of the same size and configuration.
Page 92 Replacing the Memory Module NOTE: To get maximum performance/dual-channel memory bandwidth capability, both memory module connectors must contain memory modules and the modules must be of the same size and configuration. NOTE: If a memory module is not installed properly, the computer will not boot. ...
Page 93 If you are removing and/or installing a 2.4-GHz (802.11b, 802.11b/g) Mini PCI card, follow the instructions noted below. Only products approved for use in your portable computer may be installed. Approved Mini PCI cards may be purchased only from Dell.
Page 94 NOTICE: To prevent damage to the Mini PCI card connector, do not use tools to spread the securing clips that secure the card. 5. Release the Mini PCI card by spreading the metal securing tabs until the card pops up slightly. ...
Page 95 1 antenna cables (2) 3. Replace the cover. Back to Contents Page ...
Page 96 Back to Contents Page Modem Dell™ Inspiron™ XPS Service Manual Removing the Modem Replacing the Modem Removing the Modem CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 97 NOTICE: Do not disconnect the modem cable from the system board. 5. Disconnect the modem cable from the modem. Replacing the Modem 1. Connect the modem cable to the modem. NOTICE: Ensure that the modem cable is routed correctly when you replace the modem. ...
Page 98 Back to Contents Page Optical Drive Dell™ Inspiron™ XPS Service Manual Removing the Optical Drive Replacing the Optical Drive Your computer ships with a fixed optical drive installed. Removing the Optical Drive NOTICE: To prevent damage to drives, store them in a safe, dry place when they are not installed in the computer. Avoid pressing down on them or placing heavy objects on top of them.
Page 99 Back to Contents Page Palm Rest Dell™ Inspiron™ XPS Service Manual Removing the Palm Rest Replacing the Palm Rest Removing the Palm Rest CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 100 1 M2.5 x 8-mm screws (11) 9. Remove the Internal Card With Bluetooth® Wireless Technology. 10. Turn the computer top-side up and disconnect the touch-pad connector from the system board. 11. Remove the LED board connector. 12. Lift the palm rest and remove it from the computer. 1 touch-pad connector 2 LED board connector Replacing the Palm Rest...
Page 101 8. Replace the display assembly. 9. Replace the keyboard. 10. Replace the center control cover. Back to Contents Page ...
Page 102 Back to Contents Page PC Card Reader Cage Dell™ Inspiron™ XPS Service Manual Removing the PC Card Reader cage Removing the PC Card Reader cage CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 103 Back to Contents Page Pin Assignments for I/O Connectors Dell™ Inspiron™ XPS Service Manual USB Connector Video Connector S-Video TV-Out Connector IEEE 1394 Connector USB Connector Signal USB5V+ USBP– USBP+ Video Connector Signal Signal CRT_R 9 CRT_G 10 CRT_B 11 MONITOR_DETECT–...
Page 104 DLUMA-L DCRMA-L Composite Video Signal DCMPS-L IEEE 1394 Connector Signal TPB– TPB+ TPA– TPA+ Back to Contents Page ...
Page 105 Back to Contents Page Speakers Dell™ Inspiron™ XPS Service Manual Removing the Speakers Replacing the Speakers Removing the Speakers CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 106 4. Re-route the speaker cables into the cable guides and re-adhere the tape to secure the speaker cables in place on the computer base. Back to Contents Page ...
Page 107 Back to Contents Page System Board Dell™ Inspiron™ XPS Service Manual Removing the System Board Replacing the System Board Removing the System Board CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 108 1 PC Card connector 2 stiffener bracket screw 3 stiffener bracket 4 PC Card connector on system board 14. If applicable, remove the video card/thermal cooling assembly. NOTE: Remove the video card/thermal cooling assembly as a single unit. Do not separate the heat sink from the video card. ...
Page 109 3 cable connector for internal card with Bluetooth wireless technology 4 speaker connector 5 subwoofer connector 24. Remove the three M2.5 x 5-mm screws from the system board. 1 system board M2.5 x 5-mm screws (3) 25. Remove the system board, slowly easing the connectors out of their access holes on the back and side of the computer base: a.
Page 110 Back to Contents Page ...
Page 111 System Components Dell™ Inspiron™ XPS Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure in this document assumes that a part can be replaced by performing the removal procedure in reverse order.
Page 112 Back to Contents Page Microprocessor Thermal-Cooling Assembly Dell™ Inspiron™ XPS Service Manual Removing the Microprocessor Thermal-Cooling Assembly Replacing the Microprocessor Thermal-Cooling Assembly Removing the Microprocessor Thermal-Cooling Assembly CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide.
Page 113 Back to Contents Page ...
Page 114 Bluetooth SIG, Inc. and is used by Dell Inc. under license. Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any proprietary interest in trademarks and trade names other than its own.
Page 115 Back to Contents Page USB Port Board Dell™ Inspiron™ XPS Service Manual Removing the USB Port Board Replacing the USB Port Board Removing the USB Port Board CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide.
Page 116 5. Replace the palm rest. 6. Replace the display assembly. 7. Replace the keyboard. 8. Replace the center control cover. 9. Replace the battery and other items removed in "Before Working Inside Your Computer." Back to Contents Page ...
Page 117 Back to Contents Page Video Card/Thermal Cooling Assembly Dell™ Inspiron™ XPS Service Manual Removing the Video Card/Thermal Cooling Assembly Replacing the Video Card/Thermal Cooling Assembly Removing the Video Card/Thermal Cooling Assembly CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide.
Page 118 2. Tighten the four captive screws on the video card/thermal cooling assembly. Back to Contents Page ...
Page 119 Back to Contents Page Subwoofer Dell™ Inspiron™ XPS Service Manual Removing the Subwoofer Replacing the Subwoofer Removing the Subwoofer CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Page 120 Back to Contents Page ...

This manual is also suitable for:

Inspiron xps Xps m170

Dell Inspiron XPS Gen 2 Service Manual

Quick Links

Related Manuals for Dell Inspiron XPS Gen 2

Summary of Contents for Dell Inspiron XPS Gen 2

This manual is also suitable for:

Table of Contents