ELECTRICAL HAZARD • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels - Use only a Power Wheels - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system.
• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. • Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded.
Page 5
Parts Key Assembly 6 Volt Charger Microphone Radio Dial 25 Amp Fuse - 1* Shifter 6 Volt Battery Steering Wheel Cap Radio Knob - 2 Gas Cap Assembly Not Shown: Label Sheets - 2 Traction Band - 4 #8 x 1" Screw - 12 #6 x "...
Note: Some of the parts shown are assembled to both sides of the vehicle. Vehicle Body Steering Column Grille Sport Bar Sport Bar Cover Set Taillight Lens - 2 Taillight Housing - 2 Headlight Lens - 2 Steering Wheel Cap Spark Plug Wires Traction Band - 4 Type H 6 Volt Charger...
ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels It is a safety device. - Use only a Power Wheels - Never modify the electrical system.
Page 8
25 Amp Fuse GOOD FUSE "BLOWN" FUSE • If you are charging the battery for the first time, insert a 25 amp fuse into the battery. Note: The top of the fuse will not be flush with the top of the battery when properly installed.
WARNING Children can be harmed by small parts, sharp edges and sharp points in the vehicle’s unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, including the battery, or help in assembly of the vehicle.
Page 10
Steering Wheel • Fit the steering wheel cap into the center of the steering wheel with the screw holes aligned. • Insert two #8 x 1" screws through the holes in the steering wheel cap and into the steering wheel. •...
Page 11
Microphone Plastic • Bend the plastic tip at the end of the microphone cord to form a “T”. • Insert the plastic tip into the small hole in the left side of the vehicle body. Pull gently on the cord to make sure it is secure.
Page 12
Grille • Lift the hood. • Fit the tabs at the bottom of the grille into the slots in the vehicle body. • Press near the top of the grille to snap it into the vehicle body. • Lower the hood. Grille •...
Page 13
Seat Hole • With the sport bar positioned to angle towards the rear of the vehicle, fit the ends of the sport bar into the holes in the vehicle body on either side of the seat. • Press firmly on each side of the sport bar to fit it into the vehicle body.
Page 14
Ridge Wheel Bottom View • Turn the vehicle on its side. • Fit a traction band around a wheel. • Slide a slotted screwdriver under the traction band to push the traction band onto the ridge in the center of the wheel.
Proper label application will help to keep the labels looking their best! Keep the following guidelines in mind when applying labels: • Wash your hands before applying the labels. • Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. •...
Battery Installation and Battery Clamp IMPORTANT! Use only a Power Wheels tery with a Power Wheels ® 25 amp fuse installed. Use of any other battery or fuse will damage your vehicle. Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels ®...
Care If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. See information below for proper disposal. If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes and call a physician. If acid is internally ingested, give water, milk of magnesia or egg whites immediately.
RIDING HAZARD WARNING Prevent Injuries and Deaths • Direct Adult Supervision Required • Keep Children Within Safe Riding Areas These areas must be: - away from swimming pools and other bodies of water to prevent drownings - generally level to prevent tipovers - away from steps, driveways, roads and alleys.
How to Operate Your Vehicle To Drive • Push the top button (FWD) on the FORWARD/REVERSE switch to drive forward • Press down on the foot pedal forward at a maximum of 2 • Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward.
Problems and Solutions Guide IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Power Wheels toll-free at 1-800-348-0751 between 8 AM and 6 PM (EST) Monday through Friday. Or, contact your local Power Wheels Authorized Service Center list beginning on page 25.
Page 21
Problems and Solutions Guide Problem Vehicle was running but Loose wire or loose connectors suddenly stopped Wrong type or improperly installed fuse Blown fuse Vehicle is overloaded Driving conditions are too stressful Short run time Undercharged battery Overcharged battery Battery is old and will not accept full charge Wrong type or improperly installed fuse Driving conditions are too stressful...
Page 22
Problems and Solutions Guide Problem Vehicle runs sluggishly Undercharged battery Battery needs charging Wrong type or improperly installed fuse Battery is old and will not accept full charge Vehicle is overloaded Driving conditions are too stressful Sometimes the vehicle doesn’t Loose wire or loose connectors run but other times it does Motor or electrical switch damage...
Page 23
Problems and Solutions Guide Problem Vehicle constantly blows fuses Wrong type of fuse used Child is switching between FORWARD and REVERSE without stopping. Loud clacking or grinding Broken gears noise from a motor-gearbox Charger gets warm during use It is normal for some chargers to get warm during use and is not reason for concern.
Bumper-to-Bumper Limited Warranty *One year limited warranty from the date of purchase on the Power Wheels ® vehicle. Six month limited warranty on 6 volt battery. For the original purchaser, this one year limited warranty covers the Power Wheels ® ride-on vehicle (purchased from Power Wheels ) against defects in materials and workmanship.
We are continually expanding our Authorized Service Center Network. Please check this listing for the Authorized Service Center nearest you. If there is not one in your area, please call Power Wheels ® Consumer Relations at 1-800-348-0751. ALABAMA BIRMINGHAM - Frigid Service & Sales, 701 Graymont Ave.
Page 26
TERRE HAUTE - Corey Electronics,1101 S. 8th Street, 47802, (812) 232-8786, (888) 232-8786 IOWA BETTENDORF - K & K True Value Hardware, 1818 Grant Street, 52722, (319) 359-4473 CEDAR RAPIDS - Stalker Electric, Inc.,110 3rd Ave. SW, 52404, (319) 364-5646 COUNCIL BLUFFS - Millard Television Inc., 1840 Madison Avenue, 51501, (712) 322-9552 DES MOINES - Quality Appliance Repair Center,...
Page 27
DICKINSON - Fix It Shop, 316 21st Street E, 58601, (800) 871-0766 FARGO - General Parts & Supply Co.,10 S. 18th St, 58103, (701) 235-4161, (800) 279-9987 OHIO AKRON - Advanced Appliance Service Company, 73 W. Exchange Street, 44308, (330) 762-8968 BROOKLYN HEIGHTS - Philips Consumer, 950 Keynote Circle, 44131, (216) 741-3334, (800) 331-7037...
Page 28
Over 400 Authorized Service Centers Fisher-Price and Power Wheels by Fisher-Price are U.S. trademarks of Mattel, Inc. Fisher-Price, Inc., a subsidiary of Mattel, Inc., East Aurora, New York 14052 U.S.A. Printed in the U.S.A. If you are missing parts or need assistance,...