Opel Corsa Owner's Manual page 240

234 Opel Service, maintenance
Service work
⊕o Remove brake drum, clean, carry out visual check
Visually inspect steering system boots, track rods, final drive
Check track rod end and supporting ball joint
Change brake and clutch fluids (manual transmission automated)
⊕
Loosen wheel mounting and tighten to 110 Nm
Grease or apply oil to bolt taper when fitting.
Check tyre condition and pressure (including spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
Annual service check if the annual distance travelled is greater than 20000 km.
⊕
Visually check the first aid kit (that it is where it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle
Check headlamp settings (including auxiliary headlamps), adjust if necessary
Lubricate door hinges, check arms, cylinder lock, door latch, bonnet catch, rear panel
⊕o
hinge
OPC: check function of central locking system
clean door lock from outside and grease
Test run, final check (check steering and ignition lock, instrument and warning lamps,
entire brake system, steering, air conditioning system, engine, bodywork and chassis,
reset service/interval display with TECH 2.
⊕ Germany only: carry out emissions check, main inspection
If used commercially to transport passengers, taxis, ambulances, hire cars etc.
1)
Depending on what occurs first.
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
1)
after year 1 2 3
1)
km (x1000) 30 60 90
every 4 years/60 000 km
x x x
x x x
every 2 years
x
every 2 years
x
x
x x x
x x x
First time after three years, then every 2 years
annually
4 5
120 150
x x
x x
x
x
x
x x
x x
Back to overview